2023 Ford F-250 SD Recalls & Complaints

Incident: September 18, 2024 · Filed: October 23, 2026

The contact owns a 2023 Ford F-250 SD. The contact stated that the vehicle was parked, and while inspecting under the hood, the contact became aware that there was battery fluid leaking from the top of the battery. The vehicle was taken to the dealer where the battery was replaced; however, the failure reoccurred. The vehicle was taken to the dealer, and the battery was replaced a second time. Additionally, while driving at an undisclosed speed, the contact noticed an abnormal sound coming from the steering column. The contact referenced an undisclosed Technical Service Bulletin with a similar failure. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the vehicle to the dealer.

Incident: January 5, 2026 · Filed: June 3, 2026

I bought this truck and its got 50000 miles on it and it has a clunking noise c coming from the steering shaft took it to ford to have trailer module recall fixed and had them inspect the noise and they said the whole steering shaft needs replaced and I have co workers with f250s and they have the same noise... something comes apart in steering shaft could cause a wreck and even death... dealer said its a common issue in the f250s they replace the whole shaft to fix the issue!

Incident: July 13, 2025 · Filed: April 30, 2026

My Ford brake malfunction when i was applied the brake while towing a UHaul trailer. It locked up and warning light showed up on the dashboard. The trailer got away from my truck, hit the rear of my truck and went on the other side of road and hit an oncoming car

Incident: March 20, 2026 · Filed: March 20, 2026

Rear passenger seatbelt came UNSECURED from the rear seat mounting bracket. Unknowingly ENDANGERED my child by becoming dislodged therefore leaving her WITHOUT any restraint mechanism in the event of a crash! The incident happened at evening after hours and NOT been reported to manufacturer, dealership, law enforcement, or any other as of present. There were no warning signs or indicators other than the safety belt just freely coming up into her hand when we parked and she unbuckled.

Incident: January 15, 2026 · Filed: February 19, 2026

The contact owned a 2023 Ford F-250 Super Duty. The contact stated that while driving at 35 MPH, the engine seized. The contact was able to coast to the side of the road. The contact exited the vehicle and noticed flames were emitting from under the hood and wheel well. No warning lights were illuminated. The contact did not sustain any injuries. The police and fire department were called to the scene. The fire department extinguished the flames. The contact suspected that the fire started near the fuel pump. The vehicle was towed to a tow yard. The contact attempted to tow the vehicle out of the towing yard, and the towing company refused to release the vehicle to the contact. The manufacturer was notified of the fire and informed the contact that the vehicle was in their possession and was at an unknown location. The insurance company was notified about the fire. The contact stated that it was unclear if the vehicle was insured. The failure mileage was 44,000.

Incident: February 10, 2026 · Filed: February 11, 2026

I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down shifted several times and the engine was roaring, I'm guessing around 3K rpms or more and pulling me forwards. I put as much pressure as I could on the brake pedal and got it down to 4-5 mph and then as it was almost at a stop, still with the motor roaring, I slammed it into park and turned the key off. The motor turned off thank goodness. I sat there for about 20 seconds or so, luckily no one was behind me, then I turned it on again and it was idling just fine. I crept through the intersection and proceeded down the on ramp at 10mph or so and pulled over. Turned it off again and called the wife and a few friends about it. It ran ok, albeit I was super cautious, to my destination 25 minutes on down the highway. Something freaked out big time in the computer. Had there been traffic or someone in front of me it would have lead to a serious crash.

Incident: December 20, 2025 · Filed: December 20, 2025

SCREEN DASHBOARD ( INSTRUMENT CLUSTER) BLANK/BLACK AT STARTUP. OCCURRED DEC 20. DEALER CLOSED AND XMAS HOLIDAY CAUSED INABILTY TO MAKE APPOINTMENT.

Incident: November 14, 2025 · Filed: November 17, 2025

My complaint is with the OEM lug nuts applied on my 2023 Ford F250. I recently tried to check the tightness on my wheels lug nuts only to find out that the lug wrench provided with the vehicle when purchased new will not fit 90 percent of the lug nuts. Dealership has rotated tires at routeen intervals since purchased new in spring 2023. Service manager stated that his mechanics routeenly use the next larger socket to loosen and reapply nuts. They are a carbon steel with chrome cap. Evertime you use the wrong size socket you further distort the chrome cap. The caps are loose and swollen so I can not change out a flat without calling and waiting for roadside assistance. My vehicle is still well within the 36 month 36 thousand mile bumper to bumper warranty. Local service manager states that Ford will not warranty faulty lug nuts. It's a safety issue when the nuts are improperly torqued or over torqued because they are using the wrong size impact socket on an impact wrench. It's a safety issue if I get a flat in an area with no cell service, or stuck on the side of the highway and get rearended. Ford and it's dealerships are aware of the failure of these two piece lugnuts and recommend that I go buy single piece lug nuts from an after market manufacturer like Dorman. This is the second time I have been gooned by Ford on lug nuts, Walmart will refuse service if the required size socket cannot be applied to the lug nuts. Back in 2014 I needed two new tires on my 2010 F150 , local auto zone and they only had 8 nuts in stock but enough to do one flat tire, we were on vacation in Kentucky. Drove home with spare on, we live in Belvidere Illinois. These two piece lug nuts should be outlawed, and using the wrong size sockets should be some kind of code violation, and the correct final torque should be checked with an actual torque wrench, not a best guess setting with your battery impact wrench. My walmarts in Belvidere and Rockford Illinois follow these rules for good reason

Incident: October 25, 2025 · Filed: October 25, 2025

Other because it has to do with the stereo system. The BO Unleashed system. When starting the truck a loud deafening high pitched squeal is produced. My ears ring for 1 hour after this happens. Audio system will not operate at that point until the truck is turned off and restarted.

Incident: May 16, 2025 · Filed: October 20, 2025

Speedometer not working correctly analog and digital do no match. Trailer brake and lighting module failure warnings displayed. Both have been looked at by Ford Dealership, twice. You don’t know what is true, you can’t rely on any warning lights as all have proven wrong. I am in the process of 3rd trip in tomorrow to leave the vehicle a few days since it has to be parked on the Ford lot and stored there in order to try to get another speedometer to install to see if it fixes the one problem.