2012 Ford F-250 SD Recalls & Complaints

Incident: February 23, 2023 · Filed: February 27, 2023

Ford super duty has been in shop for death wobble numerous times and when we get vehicle back still is the issue. Very unsafe and hard to stable once it starts. Even auto shop people when thought fixed drove and scared them. Whole truck shakes uncontrollably. Very poor on Ford for no recall with this happening. Why buy truck if you can’t drive it for work duties.

Incident: March 2, 2019 · Filed: January 6, 2020

WHILE TRAVELING EAST BOUND ON INTERSTATE 10 CROSSING OVER SIEGEN LANE, TRUCK PASSED OVER SMALL BUMP IN INTERSTATE AND STARTED TO VIOLENTLY SHAKE THE ENTIRE TRUCK ALMOST TO THE POINT OF NO CONTROL. I IMMEDIATELY PULLED OVER TO INSPECT MY TRUCK. THERE WAS NO DAMAGE AND ALL TIRES WERE IN GOOD CONDITION. WHEN I STARTED AGAIN THE VEHICLE WAS FINE. THIS WAS THE FIRST OF 12 INCIDENTS OF WHAT I HAVE COME TO KNOW FROM RESEARCH AS THE "DEATH WOBBLE". I HAVE TAKEN MY TRUCK THE THE FORD DEALERSHIP ON NUMEROUS OCCASIONS AND HAVE SPENT THOUSANDS OF DOLLARS TO CORRECT THE ISSUE TO NO AVAIL. THE PROBLEM PERSISTS AND FORD CANNOT FIGURE OUT THE ISSUE. THIS IS THE MOST UNNERVING EXPERIENCE. THIS WAS A $70000 VEHICLE WHICH HAS BEEN KEPT UP TO DATE ON ALL MAINTENANCE AND REPAIRS. THE VEHICLE HAS NOT BEEN WRECKED OR EVER TAKE OFF ROAD. THIS IS OBVIOUSLY A DEFECT IN ENGINEERING AND SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL TRUCK.

Incident: July 25, 2019 · Filed: July 25, 2019

VEHICLE MILEAGE APPROXIMATELY 70,000. AT SPEEDS BETWEEN 35-65 MPH ANY MINOR BUMP WILL CAUSE TRUCK TO BEGIN TO VIBRATE THROUGHOUT THE STEERING SYSTEM AND SUBSEQUENTLY WOBBLE VIOLENTLY. APPLYING THE BRAKES MAKES IT WORSE UNTIL THE TRUCK SLOWS DOWN BELOW 35MPH. THE TRUCK IS NOT ABLE TO BE STEERED DURING THIS EVENT. I HAVE TAKEN IT TO SEVERAL REPUTABLE MECHANICS AND THEY HAVE ASSURED ME THIS DISCREPANCY IS IN MANY F-250S AND NO ONE HAS THE COMPLETE SOLUTION. I CONTACTED FORD MOTOR COMPANY CUSTOMER SERVICE AND THEY HAVE NO INTEREST OR EXPECTATION OF A RECALL. THEY DID TELL ME TO TAKE IT TO A FORD DEALERSHIP FOR REPAIR. THE LOCAL FORD DEALERSHIP GAVE ME A QUOTE TO REPLACE- TIE RODS, TIE ROD ENDS, BALL JOINTS, DRAG LINK, AND 'STEERING COMPONENTS'. THEY SAID IT WAS THE SECOND TRUCK BROUGHT IN THIS WEEK. THE WOULD WARRANTY THE PARTS BUT NOT THE PROBLEM AND THIS WOULD HELP ELIMINATE WHICH COMPONENTS WERE THE CULPRIT. SO IN EFFECT I'D BE PAYING TO REBUILD THE FRONT END AND NOT NECESSARILY FIX THE MOST DANGEROUS EXPERIENCE IN I'VE HAD IN A VEHICLE. NHTSA PLEASE DO A RECALL ON THIS VEHICLE AND HELP HOLD FORD ACCOUNTABLE.

Incident: April 25, 2019 · Filed: May 8, 2019

ON HIGHWAY DRIVING ABOUT 55 MPH LOST CONTROL OF VEHICLE NO DEATH WOBBLE THEY SPEAK OF BUT WENT INTO NEXT LANE OVER AND COULD NOT CONTROL TRUCK UNTIL SPEED WAS LOWER. THIS HAPPENED AT LEAST THREE TIMES ALREADY SENT IT INTO SHOP FRONT END TIGHT HAD ALL THE TIRES REPLACED FRONT END ALIGNED STILL PULLS LEFT AND RIGHT.

Incident: April 11, 2019 · Filed: April 13, 2019

DEATH WOBBLE - HAVE BEEN EXPERIENCING VIOLENT SHAKING AND INSTABILITY WHILE AT SPEEDS OF 55-65 MPH. STEERING WHEEL CAN ALMOST BE SHAKEN OUT OF MY HANDS WITH A TIGHT GRIP. SOLUTION IS TO SLOW TO BELOW 25MPH. THEN START OVER. WOBBLE STARTS SOMETIMES ON ITS OWN OR IF HITTING SMALL UNEVEN SURFACE SUCH AS BRIDGE/ROAD JOINT.

Incident: March 28, 2019 · Filed: April 1, 2019

VEHICLE HAS HAD RANDOM TIMES WHEN IT JUST CUT OFF COMPLETELY OR IT IS UNABLE TO START. THIS HAS BEEN ONGOING SINCE THE VEHICLE WAS PURCHASED USED IN 2015. DEALER HAS RECENTLY IDENTIFIED A DEFECT IN THE BRB BUT THE REPAIR EXPENSE IS EXORBITANT DUE TO TIME INVOLVED.

Incident: February 8, 2018 · Filed: February 20, 2019

OWNED TRUCK FOR LESS THAN A YEAR, I HAD LESS THAN 50,000 MILES ON TRUCK AND HAD 'DEATH WOBBLE' ON HIGHWAY MULTIPLE TIMES. AFTER A $1000+ BILL FROM THE DEALERSHIP, IT STILL HAPPENS BUT NOT TO THE SAME EXTENT AS ORIGINALLY.

Incident: November 25, 2018 · Filed: November 26, 2018

EXPERIENCING WHAT IS KNOWN AS "DEATH WOBBLE". WHEN HITTING A SMALL BUMP IN THE PAVEMENT, VEHICLE BEGINS SHAKING (SOMETIMES VIOLENTLY). MUST APPLY BRAKES AND SLOW SPEED TO REMEDY

Incident: November 19, 2018 · Filed: November 21, 2018

TL* THE CONTACT OWNS A 2012 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STARTED TO WOBBLE VIOLENTLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT MENTIONED THAT THE ONLY WAY TO STOP THE WOBBLE WAS TO REDUCE THE SPEED. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED ONE OTHER TIME. THE VEHICLE WAS TAKEN TO KENLY FORD INC (500 S GARNER AVE, KENLY, NC 27542) WHERE THE STEERING ARM AND TORSION BAR WERE REPLACED, AND AN ALIGNMENT WAS PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Incident: May 14, 2014 · Filed: July 24, 2018

DRIVING ON A HIGHWAY AT ABOUT 65 MPH ,MY TRUCK STOPED RUNNING. THE COMPUTER SAID IT WAS LOW ON OIL,IT WAS NOT. THIS HAPPENED APPROX. 6 MORE TIMES BEFORE I GOT HOME. I DIDN'T WHERE A FORD DEALER WAS SO I TOOK MY TRUCK TO A TRUCK REPAIR SHOP,THE TRUCK STOPPED 3 MORE TIMES. THEY FIXED A WIREING PROBLEM IN THE ENGINE COMPARTMENT, THAY CHARGED ME 526.58 FOR THE REPAIRS. FORD WOULD NOT REIMBURSE ME. HAS THIS BEEN A PROBLEM?