2024 Ford F-250 SD Recalls & Complaints

Incident: October 10, 2026 · Filed: October 13, 2026

Multiple times while I am driving my 2024 F250 on the highway while using cruise control, my truck's speed limit sign reading system mis-reads the 70 mph speed limit signs as a 35 mph sign and automatically activates emergency braking down to 35 mph unless I disengage the cruise control system. My local dealer confirmed the problem during a test drive, updated the software and advised the problem was solved. However, the same problem occurred several times this weed while I was driving on the highway. I believe that it is only a. matter of time until my truck causes an accident on the highway.

Incident: May 29, 2025 · Filed: October 8, 2026

Wrench light on dash comes on sporadically with message that there is a powertrain malfunction / reduced power. It said the system has detected a powertrain or 4 WD fault. Reduced power may put both the driver and others at risk depending on the area in which this occurs, ex interstate. Dealer has yet to remedy problem. Car has been to the dealer service department 4 times for this issue. Codes present are U0121 (lost communication with ABS control module A), U1012 (invalid internal control module data received from ABS control module), and U3035 (communication authentication signal invalid data)

Incident: March 14, 2026 · Filed: September 14, 2026

The contact owns a 2024 Ford F-250 SD. The contact received notification of NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting). The contact stated that while towing a trailer, several messages and warning lights were displayed informing the contact that the trailer was disconnected and that the exterior lights were inoperable. The dealer was contacted and performed the recall repair at the residence; however, the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.

Incident: August 8, 2026 · Filed: August 8, 2026

When Google rolled out Gemini and forced it as an interface with the Android Auto (SOLD AS A FEATURE BY FORD) it was not ready. It is still not ready. As soon as I experienced the problem with the onscreen and voice navigation integration I looked for a solution. At the time that was a rollback to the older interface, Google Assistant. I was content to just use the older interface, but Google has sent out a push notification informing everybody they are killing Google Assistant September 4th 2026. Gemini AI is still not ready. All you have to do is talk to it to find it often gives wrong results even when exact correct data is available in Google's own database. The case that broke me was trying to drive to a business location I had never been to before. Its local and I am familiar with the road layout of the area, but enroute Gemini AI kept trying to get me to go to a wrong location on a block where the street address can not exist. I have seen Google maps be wrong before, and I have seen address look ups be wrong before. This was different. It was willfully wrong. Google maps and all other lookup tools where correct. Gemini AI was taking me to a wrong location, and even when told to double check the actual data from Google Maps, or the actual data from the company's own website it insisted on taking me to the wrong location. I tried a huge array of methods to get it unbroken down to letting it know when I arrived at the correct location, that it was wrong, and it needed to correct its process. It actively argued with me. THIS IS A HUGE SAFETY CONCERN when your choices are to not use the navigation system at all, deal with a flakey AI that CAUSES distracted driving, or pull over along a busy roadway and manually enter everything on your cell phone with your thumbs. IT IS DANGEROUS to the point I have investigated alternatives, but Gemini is making inroads into Apple/Carplay as well. It's a real problem.

Incident: June 8, 2026 · Filed: July 17, 2026

At 5k miles there was an intermittent ticking/grinding noise. Dealer could not reproduce. At 10k it became more frequent. Dealer confirmed noise and found metal shavings in filter. Engine replaced per TSB. New engine failed after 100 miles. Blinking check engine light came on. Dealer inspected. Required Ford Engineer to review. More metal found in new engine. Engine replaced again.

Incident: July 7, 2026 · Filed: July 13, 2026

While driving, multiple warning lights illuminate simultaneously — ABS, brake, and all driver assist/safety systems — and the drive mode drops to Standard Locked. During these events the anti-lock braking, stability control, traction control, and trailer sway control systems appear to go offline. I have photographs of the illuminated warnings. My own OBD-II scan on 7/9/26 recorded U0121 (lost communication with ABS module), U0415 (invalid data from ABS module), U3035 (communication authentication failure), and U1012. The dealer's own scan confirmed multiple stored "lost communication with ABS module" codes in module history. The vehicle has a documented history of water intrusion from the sunroof drains, which the dealer was unable to reproduce or repair; water tracked to the windshield/mirror electronics and into the dash. On 7/13/26 the dealer reprogrammed the ABS module with a software update but performed no physical inspection of the wiring, connectors, or modules for water damage or corrosion. The condition is intermittent and unresolved.

Incident: April 29, 2026 · Filed: June 30, 2026

The dealer had attempted to repair the recall 26C10 on my truck that tows daily. The team has attempted to fix this problem with 3 service visits and performed multiple software flashes for Recall 26C10 which have failed to fix the safety defect. The trailer module hardware is bricked. Now I’m being told the module is on national back order and they are unsure what to do next.ñ, if this is even the fix. This is a serious safety issue that makes my truck useless for towing which is a major part of our regular use.

Filed: May 26, 2026

The vehicle looses the display screen and or the camera screen while driving forward and reverse at times. It also freezes up and glitches which then makes the reverse camera not in real-time causing a minor accident. The screen sometimes turns black and sometimes blue. Secondly the trailer towing lights don't work properly and say that the trailer disconnected or not working properly. We tow or move many vessels at work and it is not the trailers. It is the truck. I am sure I saw a recall ref the trailer plug but now it shows that there are no open recalls or issues. Again that is another safety issue. I have a ford bronco that had a reverse camera and display issue and it has a active recall on it. This f250 experiences the same issues. I don't know why it is not recalled

Incident: April 11, 2026 · Filed: April 16, 2026

The contact owns a 2024 Ford F-250 SD. The contact stated that while driving approximately 40 MPH on the highway, the steering wheel failed to turn as intended. Due to the failure, the vehicle struck a curb. There were no injuries or property damage. The vehicle was turned off, and it was shifted into park(P). The brakes were inoperable during the failure. The vehicle was towed to a dealer to be inspected, and it was determined that a bolt was missing from the steering wheel assembly. The missing bolt was replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 6,000. The VIN was not available.

Incident: April 14, 2026 · Filed: April 14, 2026

LT275/65R20 126/123R M+S Bridgestone Dueler A/T Without warning the tread explosively separated at normal highway speed of 70 MPH while driving straight in the morning with an approximate outdoor temperature 75 degrees or less. The truck immediately and uncontrollably swerved into the left passing lane nearly causing vehicle to turn completely sideways. Gained control of vehicle and pulled to side of the road. The tire tread had separated but the tire still retained air pressure making it possible to slow safely into road curb lane. Extensive truck damage occurred to fender, wheel well internal to engine compartment and the front bumper. Amazing that it ruined the front bumper. The tires were recently rotated and inspected by Discount Tire. There were no warnings, symptoms, messages or indications of any kind that the tire was defective. These tires will be replaced today. Fortunately I was not killed in this extreme failure.