2024 Ford F-150 Recalls, Ratings & Complaints

Incident: October 21, 2026 · Filed: October 23, 2026

On XXX at approximately 6:50 AM, I was backing out of my driveway. After entering the roadway, I came to a complete stop and shifted from Reverse to Drive while in Normal drive mode. Immediately upon shifting into Drive, the vehicle lurched forward and rapidly accelerated without any accelerator pedal input. My foot was not on the accelerator. The vehicle accelerated to approximately 15-16 MPH and continued moving under power. I had to quickly steer to avoid striking my brick mailbox. The vehicle continued moving until I applied the brakes and brought it to a complete stop. After stopping, the engine RPM returned to normal and the vehicle then operated normally. No warning lights or messages were displayed. This event created a significant safety hazard and nearly resulted in a collision. In addition, the vehicle has experienced intermittent transmission and driveline issues since it was new. Symptoms include harsh upshifts and downshifts, gear hunting, shuddering, driveline clunks, RPM fluctuations under steady throttle, and jerking during acceleration and deceleration. Some downshifts have been severe enough to make the vehicle lurch as if lightly rear-ended. Other events have felt similar to placing a vehicle in Park while still moving. I have experienced abrupt downshifts while slowing from approximately 40 MPH, rapid multiple-gear downshifts accompanied by shuddering, harsh shifts while coming to a stop at low speeds, and repeated gear hunting in traffic. The symptoms occur intermittently, often at low speeds, during the first few miles of driving, and sometimes while traveling uphill. I have returned the vehicle to Ford of [XXX] three times for these concerns. The dealership has been unable to duplicate the condition and no repairs have been performed. I am concerned that the unintended acceleration event and longstanding transmission/driveline abnormalities may be related to an underlying powertrain, transmission, or electronic control defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 19, 2026 · Filed: October 19, 2026

I am the owner of a Ford F-150 Raptor R, a vehicle that Ford specifically engineered to require 5W-50 full synthetic motor oil. Despite following Ford's recommended maintenance schedule, I have been informed by multiple dealerships that they cannot perform a routine oil change because Ford is not supplying sufficient quantities of the required oil. What I find unacceptable is not simply the temporary shortage itself, but Ford's apparent lack of urgency in addressing the problem and the complete absence of a customer solution. I purchased a premium vehicle with the expectation that Ford would be able to support and maintain its own product. Instead, I am being told there is "nothing that can be done" while the vehicle continues to accumulate mileage. This puts owners in an impossible position. If I continue driving the truck, I risk exceeding the recommended service interval and potentially jeopardizing warranty coverage or engine longevity. If I stop driving it, Ford has effectively rendered an expensive vehicle unusable through its inability to provide a basic maintenance requirement. When I contact Ford Customer Service and request escalation to a supervisor, I am repeatedly told that all available resources have been exhausted. However, offering no remedy, no alternative service plan, no approved substitute oil, no reimbursement process, and no timeline for resolution cannot reasonably be considered a remedy. I am asking Ford to provide, in writing: An immediate solution for servicing affected Raptor R vehicles. Written assurance that owners will not suffer warranty consequences if oil changes are delayed due to Ford's inability to supply the required oil. Reimbursement options for customers who must obtain approved oil from third-party sources. A clear timeline for when dealerships will have adequate supplies available. A direct escalation path to management with authority to address this issue. Ford markets the Raptor R as a flagship performance vehicle.

Incident: May 24, 2026 · Filed: October 10, 2026

URGENT SAFETY COMPLAINT – 2024 FORD F-150 TREMOR Since May 2026, my 2024 Ford F-150 Tremor has repeatedly experienced a dangerous transmission gear-shifting malfunction. Without warning, the gear selector locks, preventing the vehicle from engaging Drive, Reverse, or Park, leaving it immobilized. This has occurred in parking garages, blocking entrances and exits, and on interstate highways after stopping in traffic. The vehicle can become stranded in active traffic with no reliable way to move it to safety. This creates an extreme collision risk, potentially resulting in serious injuries or fatalities involving myself, my family, and other motorists. This is not an isolated concern. Ford issued Technical Service Bulletin 25-2276 addressing gear shift module failures in 2021–2025 F-150 trucks, including inability to shift into Park or out of gear. NHTSA complaints 11745086 and 11751717 describe similar failures in 2024 F-150 vehicles. Despite the recurring safety hazard, Ford has refused to repair my vehicle without charging me, citing expiration of the 3-year/36,000-mile warranty due to mileage. A potentially life-threatening safety defect should not be dismissed solely because the vehicle exceeds its warranty mileage. I respectfully request that NHTSA investigate these recurring failures, determine whether a broader safety defect exists, and evaluate whether a safety recall and manufacturer-funded repairs are warranted. I fear that continued operation could result in a preventable fatal accident. Immediate investigation is necessary to protect vehicle owners, passengers, and the public.

Incident: September 30, 2026 · Filed: October 5, 2026

I am reporting a catastrophic component failure on my 2024 Ford F-150 equipped with the 9.75-inch heavy-duty 3/4 float rear axle design. Both the driver-side and passenger-side rear axle hub bolts have completely sheared off due to metal fatigue. The bolt heads are missing entirely, and the threaded studs remain snapped off flush inside the wheel hub assemblies

Incident: October 1, 2026 · Filed: October 1, 2026

The windshields are extremely prone to cracking and chipping. I am now in need of my fourth windshield from an acorn falling off a tree and hitting my windshield while going 25mph. I have had multiple Ford F150s and have never replaced a windshield, I have not changed my driving habits and every one has been from an extremely minuscule incident such as this. I know of at least three other F150 owners at my place of employment who have been through at least one windshield on their newer trucks as well. There is something wrong with these windshields.

Incident: September 5, 2026 · Filed: September 30, 2026

While towing truck shifted harshly and turned on the indicator light (P1744). The truck started having metallic noises while in gear. Dealer inspected and found metal debris throughout transmission. Dealer replaced transmission.

Incident: September 25, 2026 · Filed: September 26, 2026

2024 Ford F150 Lariat caught fire on 9/25/2026 while driving vehicle. White smoke came out of engine compartment, then black smoke. Cab filled with white smoke, then black smoke. We exited vehicle. Flames came out of engine compartment. Within seconds flames & black smoke shot up 20' to our oak tree. Could hear "pops' going off while waiting for fire department. Firefighters stated sounds were from tires & air bags. Vehicle totally destroyed. Everything totally gone from engine compartment up to bed of truck. Left side of vehicle worse that right side. Left side mirror gone. Vehicle is available for inspection. Insurance company claim made. Adjuster hasn't contacted us yet. Police and fire department were here and reports were made. No warning lamps or messages prior to incident.

Incident: June 1, 2026 · Filed: September 24, 2026

Re: Recurring Knock Sensor Failure — 2024 Ford F-150 STX (2.7L) I am writing to document a recurring mechanical issue with my 2024 Ford F-150 STX, 2.7L, currently at approximately 30,900 miles, purchased new. First Incident (late XXX): While driving, the check engine light illuminated, indicating a knock sensor fault. I brought the vehicle to Ted Britt Ford in [XXX], where it remained for five days for sensor replacement. I requested a loaner vehicle, which the dealership stated was unavailable, requiring me to rent a replacement vehicle at my own expense. Second Incident (XXX): Following a period of heavy rainfall, the check engine light returned with an identical knock sensor fault. The vehicle was again taken to the same dealership and held for five days for repair. When I again requested a loaner, I was informed one could not be provided because the vehicle was not originally purchased at that dealership. Rental Costs: Across both repairs, I have incurred rental vehicle expenses for a combined 10 days due to the dealership's lack of loaner availability. Suspected Root Cause: Based on the pattern of failures — particularly the correlation with heavy rain — I believe water may be intruding into the engine compartment through the hood cowl area and affecting the knock sensor. I have found numerous other reports from Ford F-150 owners describing similar symptoms, which suggests this may be a broader design or manufacturing issue rather than an isolated incident. Concerns: Given that this is a low-mileage, recently purchased vehicle experiencing the same failure twice within approximately three to four months, I am concerned this issue will recur once the vehicle is out of warranty, at which point repairs would no longer be covered. I believe this pattern warrants investigation, and potentially a recall, given the apparent frequency of similar complaints among other owners. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 4, 2026 · Filed: September 5, 2026

The seat belt will not latch when I insert the tongue normally. It will only click into the buckle if I hold the release button down while inserting it. This is the back seat behind the driver seat.

Incident: June 28, 2026 · Filed: September 4, 2026

The contact owns a 2024 Ford F-150. The contact stated that following an unsuccessful Over-the-Air (OTA) software update, the display screen and instrument panel were constantly rebooting, with a loss of functionality for several electrical features. The vehicle was taken to a dealer, where technicians associated the failure with NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting). After several service repairs and the inclusion of a field service engineer, the vehicle remained unrepaired and had been with the dealer for over two months. The manufacturer was notified of the failure and provided the contact with a case number. The contact was not provided any status updates because the master technicians were on extended leave. The failure mileage was approximately 25,000.