NHTSA vehicle safety data

2005 Ford F-150 Recalls, Ratings & Complaints

The 2005 Ford F-150 has 14 NHTSA recall campaigns and 1,112 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2005 Ford F-150, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Ford F-150 owner complaints

Owners have filed 1,112 complaints with NHTSA about the 2005 Ford F-150, describing incidents dated October 5, 2004 to April 13, 2026.

Most-cited components

Visibility/Wiper 268 complaints
Engine 228 complaints
Power Train 112 complaints
Service Brakes 112 complaints
Air Bags 101 complaints
Fuel/Propulsion System 82 complaints

Of the 1,112 complaints on file, 50 report a crash and 29 a fire; across all 1,112 complaints, owners report 57 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11739978 · Filed May 26, 2026
My sister's 2008 Hyundai Elantra burned completely nothing left my truck was parked next to it it also burned the entire driver's side It was ruled an accident by fire department but progressive has turned down any claim from me the said since there was no one at fault even though her car burned my…
ODI #11704240 · Filed December 10, 2025
The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and discovered that the engine compartment was on fire. The Home…
ODI #11696954 · Filed November 1, 2025
customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of…

Read all 1,112 complaints

Owner-reported

2005 Ford F-150 mileage at failure

963 of the 1,112 complaints on file for the 2005 Ford F-150 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Visibility/Wiper	Median 50,000 miles	Middle half 35,000–70,000 miles	Based on 252 complaints
Engine	Median 90,000 miles	Middle half 60,000–120,000 miles	Based on 199 complaints
Power Train	Median 65,000 miles	Middle half 40,000–95,000 miles	Based on 89 complaints
Service Brakes	Median 35,000 miles	Middle half 11,000–65,000 miles	Based on 94 complaints
Air Bags	Median 80,000 miles	Middle half 55,000–100,000 miles	Based on 80 complaints
Fuel/Propulsion System	Median 65,000 miles	Middle half 45,000–100,000 miles	Based on 74 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Ford F-150 in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA10-001: Inadvertent airbag deployment
Closed April 25, 2011
- Recall 11V-107
Preliminary Evaluation PE09-046: INADVERTENT AIRBAG DEPLOYMENT
Closed January 19, 2010
- Recall 11V-107
Preliminary Evaluation PE08-001: LOSS OF BRAKE POWER-ASSIST
Closed May 9, 2008
- Recall 08V-208

Open and recently closed NHTSA defect investigations

INADVERTENT DRIVER AIR BAG DEPLOYMENT

NHTSA #11V107000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported February 23, 2011 · FORD MOTOR COMPANY

Potentially affected: 1,325,000 vehicles

Ford campaign 11S18 · Owners notified March 23, 2011 · Vehicles built November 1, 2004 – January 24, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.

Safety consequence

THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.

Manufacturer remedy

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 11S18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY

NHTSA #08V208000 · Service Brakes, Hydraulic — Power Assist — Vacuum — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported May 7, 2008 · FORD MOTOR COMPANY

Potentially affected: 605,684 vehicles

Ford campaign 08S05 · Owners notified June 27, 2008 · Vehicles built April 19, 2004 – May 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.

Safety consequence

ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 08S05.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AFTERMARKET HEADLAMP ASSEMBLIES

NHTSA #07E089000 · Exterior Lighting — Headlights · NHTSA notice

Reported October 25, 2007 · SPYDER, INC.

Potentially affected: 238 vehicles

Owners notified November 21, 2007

Defect description

CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

Manufacturer remedy

SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET SPYDER HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F150 PICKUP TRUCKS MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET HEADLAMP ASSEMBLIES

NHTSA #07E080000 · Exterior Lighting — Headlights · NHTSA notice

Reported September 25, 2007 · SONAR AUTO PARTS CO., LTD.

Potentially affected: 700 vehicles

Owners notified December 14, 2007

Defect description

CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

Manufacturer remedy

SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET SONAR HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/REPLACEMENT HEADLAMPS

NHTSA #07E075000 · Exterior Lighting — Headlights · NHTSA notice

Reported September 14, 2007 · EAGLE EYES TRAFFIC INDUSTRIAL CO. LTD

Potentially affected: 2,388 vehicles

Owners notified November 6, 2007

Defect description

CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS/TOW ASSEMBLIE

NHTSA #07E066000 · Equipment — Electrical · NHTSA notice

Reported August 28, 2007 · CEQUENT ELECTRICAL PRODUCTS

Potentially affected: 175 vehicles

Owners notified September 5, 2007

Defect description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Safety consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Manufacturer remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E064000 · Exterior Lighting · NHTSA notice

Reported July 17, 2006 · TRADESONIC

Potentially affected: 4,029 vehicles

Defect description

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E060000 · Exterior Lighting · NHTSA notice

Reported June 29, 2006 · AAI MOTORSPORTS USA, LLC

Potentially affected: 87,745 vehicles

Owners notified August 1, 2006

Defect description

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Manufacturer remedy

AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Notes

THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL LEAK/FIRE

NHTSA #06E056000 · Fuel System, Gasoline · NHTSA notice

Reported June 13, 2006 · UFI FILTERS USA

Potentially affected: 58,640 vehicles

Owners notified August 4, 2006

Defect description

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Safety consequence

FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Notes

THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/HEADLAMP/AMBER SIDE REFLEX REFLECTOR

NHTSA #06E023000 · Exterior Lighting — Headlights · NHTSA notice

Reported March 13, 2006 · ANZO USA, INC.

Potentially affected: 292,000 vehicles

Owners notified May 9, 2006

Defect description

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

INSTRUMENT CLUSTER SOFTWARE/FMVSS 135

NHTSA #06V033000 · Interior Lighting · NHTSA notice

Reported February 6, 2006 · FORD MOTOR COMPANY

Potentially affected: 211,432 vehicles

Ford campaign 06C11 · Owners notified February 27, 2006 · Vehicles built April 7, 2005 – August 25, 2005 (per NHTSA)

Defect description

CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.

Safety consequence

THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.

Manufacturer remedy

DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO.06C11. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 119/PREMATURE TIRE WEAR

NHTSA #05T022000 · Tires — Tread/Belt · NHTSA notice

Reported November 21, 2005 · CONTINENTAL TIRE NORTH AMERICA, INC.

Potentially affected: 34,396 vehicles

Owners notified December 7, 2005

Defect description

CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.

Safety consequence

AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.

Manufacturer remedy

CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Ford F-150 Supercrew 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

3 investigations

2005 Ford F-150 Regular Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

3 investigations

2005 Ford F-150 Supercab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

3 investigations

1,112 owner complaints have been filed with NHTSA for the 2005 Ford F-150.

Unknown or Other

ODI #11739978

Fire

Incident: April 13, 2026 · Filed: May 26, 2026

My sister's 2008 Hyundai Elantra burned completely nothing left my truck was parked next to it it also burned the entire driver's side It was ruled an accident by fire department but progressive has turned down any claim from me the said since there was no one at fault even though her car burned my truck it's my problem

Engine

ODI #11704240

Fire

Incident: November 26, 2025 · Filed: December 10, 2025

The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and discovered that the engine compartment was on fire. The Home Depot employees came out to the vehicle and extinguished the fire with a fire extinguisher. The Fire Department and Police Department were contacted; however, the contact was unsure if a report was filed for either department. The orgin of the fire was not confirmed however, the fire department informed that timing was critical because any longer the fire would have caused an explosion. No warning lights were illuminated. The vehicle was towed back to the residence, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 360,000.

Power Train; Structure; Unknown or Other

ODI #11696954

Incident: November 1, 2025 · Filed: November 1, 2025

customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of this of which they bought a frame repair kit (Pre-cut over frame c-channel steel) to weld onto the frame to support a longer lifespan. The truck is now safe for the roadway.

Engine

ODI #11696761

Filed: October 31, 2025

Spark plug blew out no check enginge lite until after coil an plugs replaced now motor has a knocking sound 5/23 not 1969 like date happended onlys puts down even if i select present day

Unknown or Other

ODI #11685649

Incident: September 5, 2025 · Filed: September 8, 2025

While changing the spark plugs 7 of the eight broke off in the engine block, the threaded section came out but the ceramic bottom portion is what broke. I find that this is somewhat common because Auto Zone rents a spark plug extractor specifically for this. My safety isn’t at risk. Problem not reported to a dealership yet. No inspection yet. The check engine light was on

Power Train

ODI #11683922

Incident: August 28, 2025 · Filed: August 29, 2025

The contact owns a 2005 Ford F-150. The contact stated that while parking the vehicle, the vehicle rolled backwards. The contact shifted the gear shifter into park and turned off the vehicle; however, the vehicle rolled backwards again. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact stated that upon inspecting under the hood, the contact became aware that the shifter cable had melted. The contact purchased a new shifter cable and replaced the shifter cable. The vehicle was started and driven to the residence. In addition, the contact stated that the failure had occurred at night, which was dangerous for being on the side of the road. The contact stated that the shifter cable had melted again within 12 hours. The contact stated that the failure was the result of a design flaw. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 260,000.

Air Bags

ODI #11676188

Incident: April 1, 2025 · Filed: July 25, 2025

My airbag light is on and the dealership says I have no active recalls but when I ask about recall number 11V-107 no one can confirm the when and where for this recall. I would like it repaired at no cost and the criteria of this recall number.

Structure

ODI #11674785

Incident: July 7, 2025 · Filed: July 19, 2025

This is an extended cab - 4 door - the rear doors are half doors with a a handle allowing entry and exit to and from the rear passenger seats. (It is not a crew cab 4 door). The doors LOCKED and the handles failed with a child in the rear seat. THe doors cannot be opened. The child and his mother had to climb over the center console to exit the vehicle. THe vehicle is at a mechanic who states no part are available to repair this faulty and unsafe door mechanism. Both rear doors are LOCKED. QUalified mechanic estimates the cost to rig a fix, in absence of any left door mechanism parts will be near or over $500.00. THe mechanic reports that the control cables from the handles to the door latch stretched and failed. If there had been a collision or engine fire, rear seated passengers would be trapped inside the vehicle. THIS NEEDS TO BE ADDRESSED and REPAIRED BY FORD.

Electrical System

ODI #11674572

Incident: July 18, 2025 · Filed: July 18, 2025

Odometer Fraud. The contact purchased a 2005 Ford F-150. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,180 and at the time of registration, it was discovered that the mileage was 216,350.

Power Train

ODI #11657151

Incident: April 11, 2025 · Filed: April 28, 2025

I don't even have 150,000 miles on this thing. I get it serviced regularly. I've used the 4x4 when needed, as I live in the Sierra Nv Mountains area. I don't overdo it, I don't abuse it. One day with "ZERO" Clues or indications my truck popped out of drive into neutral ON ITS OWN I put it back into drive. Then as I tried to accelerate NOTHING, I got a code/msg saying faulty transmission, my O/D kept turning off and on. I pushed it to the side if the road. I eventually got reverse back, 1st gear, but that's it. And NOBODY KNOWS WHAT IS WRONG WITH IT. Its Automatically you need a transmission. [XXX]!! You go online and this is happening to TONS of people. Are you saying WE ALL NEED NEW TRANSMISSIONS?? Kinda odd same trucks, same issues on the same part. What's the common denominator here ford??? Your [XXX] transmissions. Figure it out!!! My truck is paid off and I can't even drive the [XXX]. I'm walking because of a [XXX] transmission, on top of paying over 20,000 you want me to dish out another 3grand for your [XXX]?? Nah... Figure it the [XXX] out. Take care of your customers as you should!!! Integrity is doing the right thing when no one is looking. Come on Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Other Ford F-150 model years

Check your 2005 Ford F-150 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-150 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN