2020 Ford F-150 Recalls, Ratings & Complaints

Incident: July 6, 2026 · Filed: October 27, 2026

Passenger side and passenger side rear door sensors say the door is a jar even though it’s not. Opened and closed doors numerous times to make the warning message go away. Seems water or something gets in the sensors, causing the faulty sensors to go off doors will not lock and makes the alarm system go off randomly.

Incident: October 25, 2026 · Filed: October 25, 2026

Transmission has hard/harsh shifts and delayed gear engagement that began around 56,000 miles and have become much worse at 68,000 miles. The delay in engagement when accelerating from a stop, pulling into traffic or merging is a safety concern. A Ford dealer performed a transmission adaptive relearn and software update, but the symptoms continued. The dealer did not verify hydraulic leakage or perform the full diagnostic described in Ford TSB 25-2126 (MC-11016931-0001, harsh/delayed shifts on 2017-2020 F-150), and the only recommendation was to replace the entire transmission at roughly $5,000 after the powertrain warranty expired at 60,000 miles. The incident date entered is today because the symptoms are ongoing and progressive: they developed gradually since about 56,000 miles and are heading toward ultimate transmission failure. Safety concerns: hesitation and delayed engagement when pulling into or merging with traffic, the truck possibly rolling back when engaged on hills, and loss of reliable power on hills.

Incident: October 16, 2026 · Filed: October 23, 2026

On XXX, while the vehicle was parked and not in use, the passenger-side front coil spring abruptly fractured, causing the front passenger side of the vehicle to drop onto the tire. The failure also damaged additional components. The vehicle and failed component are currently located at Hines Park Ford in [XXX], and are available for inspection upon request. This failure presented a serious safety concern. Had the spring fractured while the vehicle was traveling at highway speeds, the sudden drop in the vehicle’s front end, contact with the tire, and damage to additional components could have resulted in a sudden loss of vehicle control, potentially causing a serious crash, significant injuries, or fatalities. I am unaware whether the failure has been independently reproduced. However, the dealership inspected the vehicle and confirmed that the coil spring had broken and that additional components were damaged as a result. There were no warning signs, unusual noises, dashboard warning lights, or other noticeable symptoms before the failure. The spring fractured abruptly and without warning while the vehicle was parked. The sudden failure of a critical suspension component on a vehicle that was not in motion raises serious concerns about the component’s reliability and the potential consequences if the same failure occurs while driving. Video of event - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 21, 2026 · Filed: October 21, 2026

while driving on the highway, my 2020 Ford F-150 equipped with the 10R80 transmission experienced a sudden and catastrophic loss of power. The transmission failed to shift slipped gears, and left the vehicle completely neutralized in traffic. This sudden loss of propulsion created an extremely hazardous situation on the road, nearly causing a severe collision before I could safely pull over.

Incident: December 1, 2025 · Filed: October 21, 2026

The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed with children inside the vehicle, the transmission shifted erratically and began shuddering. The vehicle decelerated unexpectedly. The contact stated that the check engine warning light was intermittently illuminated. The manufacturer and the dealer were notified of the failure. The failure mileage was 90,000.

Incident: September 18, 2026 · Filed: October 19, 2026

The Transmission has failed. Hard shifting, random gear switching while driving at any speed. i put it in reverse and it went forward while in reverse. it slows itself down while on the highway. it acts like it wants to turn off while running, its a matter of time before I'm driving down the road and it decides to stop suddenly and cause an accident. I got it diagnosed by truck works garage and they confirmed that the shifting was all over the place with random high rpms. The dealership quoted me $2500 just to diagnose the problem so i had it diagnosed at truck works garage for $160 to confirm the issues matched the tsb's and recalls that they wont acknowledge my VIN for. The failure 1st appeared 5 years ago when i was under warranty, i took it in (and have the work order still dated 10/22/202) for hard shifting and they brushed me off and sent me away with false information about the cause. 5 years ago (25 days before i brought it in for the hard shifting) there was a tsb 21-2315 published for the exact issue on my truck, They ignored it and sent me away without fixing anything or addressing the issues.

Incident: September 25, 2026 · Filed: October 12, 2026

I put my truck in reverse to get out of a driveway and it kept going and accelerating...the brakes did not work. I ended up goign through a fence at the end of the street and into a shed and my truck finally stopped. I have significant damage to my truck as well as to the homeowners property...the Police classified it as equipment failure and I did not receive a ticket.

Incident: October 8, 2022 · Filed: October 8, 2026

The contact owns a 2020 Ford F-150. The contact stated that after the check engine warning light illuminated on two occasions, the vehicle was taken to the dealer, where the catalytic converters were replaced under warranty. The contact stated that the check engine warning light was intermittently illuminated. The vehicle was taken back to the dealer, where it was determined that one of the catalytic converters needed to be replaced. The contact was informed that the manufacturer would provide partial financial assistance for the repair. Additionally, the contact stated that the fuel efficiency had decreased after the failure started. The manufacturer was notified of the failure by phone. The failure mileage was approximately 30,000.

Incident: October 5, 2026 · Filed: October 7, 2026

I am writing to formally report a severe and dangerous safety defect regarding the 10R80 10-speed automatic transmission in my 2020 Ford F-150. While driving, the vehicle routinely experiences a complete "neutral-out" or severe shift flare when attempting to transition out of 1st gear. Instead of engaging 2nd or 3rd gear, the transmission completely drops out of gear into a false neutral. During this failure, the vehicle experiences an immediate and total loss of forward propulsion for several seconds while the engine revs freely. After a dangerous delay, the transmission violently slams back into gear. This is an acute safety hazard. Losing all forward acceleration unexpectedly—specifically when pulling out from a complete stop, navigating intersections, or merging into fast-moving traffic—leaves the vehicle stranded and completely defenseless against oncoming traffic. It creates an immediate risk of a severe rear-end or broadside collision, as trailing drivers do not expect a vehicle to suddenly lose all power. Ford is fully aware of this mechanical defect, as documented in their internal Technical Service Bulletin TSB 25-2126 (and its predecessors). The bulletin notes that an internal CDF clutch drum bushing physically slips out of place, blocking hydraulic fluid passages and starving the transmission of pressure. Because this is a known factory engineering defect that causes an unpredictable loss of propulsion in active traffic, it should be treated as a critical safety hazard rather than a standard wear-and-tear component. I urge the NHTSA to investigate this systemic 10R80 CDF drum failure to protect consumers from catastrophic accidents.

Incident: October 3, 2026 · Filed: October 6, 2026

I have noticed that my turn signal lights work sometimes, and sometimes they give me the rapid-fire warning light indicating that one of them is out (front or back). The outage may or may not last the entire duration of when the turn signal is deployed - sometimes it fixes itself, and other times it remains out. Sometimes, it even fixes itself and goes back out in the same signal instance. Additionally, I have noticed that one or both of the headlights will sometimes fail. I have learned to turn on the fog lights in order to ensure some sort of light remains working to illuminate my path forward. I've not yet experienced the fog lights going out as they seem to be unaffected by the intermittent outages. If it wasn't for this, I would have stopped driving at night altogether. I have already begun limiting my time on the road after dark, and attempting to handle anything that requires transportation earlier in the day. Please feel free to reach out with any additional questions, as I'd like to ensure this gets resolved for myself and any others ASAP!