2012 Toyota Tacoma Recalls, Ratings & Complaints

Incident: August 1, 2026 · Filed: August 31, 2026

Vehicle: 2012 Toyota Tacoma VIN: [XXX] Toyota Special Service Campaign 20TC01 was performed on September 19, 2024, at approximately 103,417 miles. The campaign addressed the secondary air injection system, including the air injection pump and air switching valves. According to Toyota's repair records, the dealer installed an air switching valve kit, air pump repair kit, and air pump cover under campaign SSC 20TC01. On XXX, at approximately 111,187 miles, the same Toyota dealership diagnosed failure of the air pump and air switching valves and estimated $3,664.13 for repair. The recurrence occurred after only about 7,770 miles and less than two years after completion of Toyota's campaign repair. I am concerned that the campaign remedy did not provide a lasting correction of the condition affecting the air injection system. Toyota has declined assistance despite the failure involving the same system that was the subject of SSC 20TC01. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 28, 2026 · Filed: January 30, 2026

- Driver’s seat back recliner mechanism / seatback locking mechanism. During a rear-end interstate collision while stopped in traffic, the driver’s seat suddenly reclined backward unexpectedly. After the accident, the recliner adjustment knob/handle was found detached at the tow yard. The vehicle is currently at a tow/salvage yard and may be available for inspection upon request. - Because the seat reclined unexpectedly during impact, the driver’s body position changed suddenly and the front airbag did not appear to make protective contact. The driver briefly lost consciousness and is experiencing significant neck stiffness and pain following the crash. The seat movement may have reduced the effectiveness of the airbag and seatbelt system and increased risk of head and neck injury. - No. The vehicle has not been evaluated by a dealer or independent service center at this time due to collision damage. - The vehicle has been inspected by police at the accident scene and is pending inspection by insurance. The seat mechanism has not yet been specifically evaluated by the manufacturer. - No warning lights, messages, or prior symptoms related to the seat or restraint system were observed before the accident.

Incident: October 4, 2025 · Filed: January 22, 2026

Odometer Fraud. The contact purchased a 2012 Toyota Tacoma. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 51,350 and at the time of registration, it was discovered that the mileage was 212,400. The VIN was not available

Incident: January 12, 2026 · Filed: January 14, 2026

The contact owns a 2012 Toyota Tacoma. The contact stated that while driving at 35-40 MPH, coming up on fog, the driver, attempting to slow down, traveled over a slush patch in the roadway, and an approaching vehicle was in view. She lost control of the vehicle, spun around, and went face-first into a ditch, and the vehicle flipped and rolled over onto the hood. There were no warning lights illuminated. The contact stated that she sustained a concussion, hematoma, and pain on the left side of her neck and head, and the next day, there was pain on the right side of her neck and shoulder. She was taken by ambulance to the hospital, where medical attention was provided. The side curtain on the driver's and passenger's sides deployed. The front airbags failed to deploy. The vehicle was towed to an independent auto center. There was no reported fire. A police report was filed. Previously, while turning around in a parking lot, the contact crashed into a cement barrier. The airbags did not deploy. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 240,000.

Incident: October 21, 2021 · Filed: July 30, 2025

The contact owns a 2012 Toyota Tacoma. The contact stated that the undercarriage of the vehicle was significantly rusted. The TPMS warning light was illuminated. The vehicle was taken to the local dealer, where it was repaired under the warranty; however, the failure recurred. The dealer informed the contact that the rear bumper and brackets were rusted, and there was no recall or warranty coverage. The contact stated upon pulling into the driveway of the residence, the contact noticed a trail of fluid leak on the street. The contact stated that the transmission lines were fractured due to rust. The vehicle was taken to an independent mechanic, where the contact was informed that the vehicle was significantly rusted. The vehicle was not repaired. The manufacturer was contacted and a case was filed. The failure mileage was approximately 71,000.

Incident: February 1, 2025 · Filed: June 2, 2025

My leaf spring(s) is noisy/loosened and to the best of my limited knowledge is at risk for breaking off and puncturing the fuel tank per repair shops. This issue is not covered under Safety Recall E02 (E12) by Toyota for the model year 2012 Tacoma. As a consumer, I don't understand the determination of when the recall is cut off for specific model years. I would like for NHTSA and Toyota to analyze this issue as the model year 2012 Tacoma could be at risk. I have case with Toyota Customer Resolutions that has been closed. Thanks for your attention into this matter.

Incident: May 21, 2025 · Filed: May 22, 2025

While driving on the road truck locks up occassionally in a curve. i know of mulitple trucks its happening to and only in curves- will end up hurting someone if a fix for it isnt found - no one seems to know what is going on

Incident: May 13, 2025 · Filed: May 15, 2025

The contact owned a 2012 Toyota Tacoma. The contact stated that while his son was driving 40 MPH, the rear driver-side wheel rim detached. The traction control and ABS warning lights were illuminated. The vehicle veered to the right, accelerated independently, and went up the embankment, hit a tree, and accelerated independently down the embankment when the vehicle flipped on the passenger side, where it came to a stop.  The driver-side and passenger-side air bags deployed, and the side curtain air bags deployed. A police report was not filed. There were no injuries sustained. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The insurance company was contacted, and pending results. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was not available.

Incident: September 18, 2023 · Filed: December 28, 2024

My truck started having a vibration when driving around 45-55 mph. This problem first became noticeable when it had about 115,000 miles on it. Over time the speed that the vibration became noticeable at gradually increased. By 125,000 miles on the truck, it was vibrating hard between 60 and 70 mph. The dealership determined that the problem was that the drive shaft was out of balance and that it had to be replaced. They replaced the drive shaft, but this doesn't seem like a problem that should creep up with that relatively few miles on the vehicle, and I have read that if the drive shaft actually fails, it can severely damage the vehicle and potentially cause injury.

Incident: October 20, 2023 · Filed: December 18, 2023

Under the bottom of my truck, there is tons of rust. I know a lot of the trucks my year, make, and model has been recalled for rust on the body and other parts of the truck. I was told that a Toyota dealership should replace it with the amount it has, and now a hole has appeared but they only told me a price to fix everything that is rusted. Just puts my vehicle at risk driving it back and forth to work.