2023 Toyota Tacoma Recalls, Ratings & Complaints

Incident: August 25, 2026 · Filed: September 9, 2026

Check BSM light came on Dealer found chafed wiring harness

Incident: August 28, 2026 · Filed: August 28, 2026

After initial start of engine and at idle there is surge of the engine and lunge forward while in drive. The danger is unexpected forward movement of the truck when pulling forward at idle by lunging forward with risk of hitting that which is directly in front such as a parked car or the front of my garage. This is an ongoing event.

Incident: August 13, 2026 · Filed: August 17, 2026

On XXX I was driving on [XXX] at about 70mph, when the rear drivers side window on a 2023 Toyota tacoma crew cab shattered suddenly. If someone had been sitting in the backseat when this occurred they could have been injured. The door panel itself was damaged from the tiny shards of glass. It was a dangerous situation as glass was most likely showering the vehicles behind me as this occurred. This vehicle only had 22,200 miles on it at the time and was a stock vehicle. No modifications were added. I had all the windows closed and the AC and recirculating air was on at 2 bars. It was about 8:30 at night when this happened. When I was able to get off the freeway and look at what happened, the glass was totally gone from the window. There was lots of glass on the door panel & well below that, a little behind the drivers seat on the floor close to the window and a little behind where the seat leaves a gap (when the seat is folded down), close to the window that blew out. There was no glass further into the vehicle, which if something had hit the window from outside, I would think the glass would have been further inside. I found more small glass pieces in the bed of my truck (6’ bed). This was a very scary situation and I didn’t do anything to cause it. A more high strung person might have reacted badly to this sudden boom and caused an accident at high speed on the highway. I have heard that similar things have happened to other drivers of certain models of toyota from 2020 - 2026. The vehicle is still under warranty and I took it to Toyota but they refused to repair it under the warranty. I am taking it to a repair shop tomorrow to get an estimate for my insurance. There was no warning prior to this occurring. It was a shock. A child in a rear seat in this situation could have sustained injury. The door panel had slices in it and the fabric is torn. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 1, 2024 · Filed: August 10, 2026

The contact owns a 2023 Toyota Tacoma. The contact stated that the transmission failed to operate properly while driving 35 MPH and attempting to accelerate. While driving uphill or downhill, the transmission was slow to shift into the intended gear, and the vehicle was slow to accelerate. Additionally, there was an abnormal sound while turning the steering wheel. While driving in the left lane with another vehicle in the right lane, the vehicle stopped suddenly. There were no warning lights illuminated. The local dealer was contacted, and the failure was associated with the gear shaft. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 15,000.

Incident: July 1, 2026 · Filed: August 4, 2026

The contact owns a 2023 Toyota Tacoma. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V152000 (POWER TRAIN). The contact stated that while driving 55 MPH, the steering wheel was firm, the brake pedal was firm, and the vehicle was violently vibrating. Several unknown warning lights were illuminated. The message “Pull Over – Do Not Drive” was displayed before the vehicle lost automotive power. The vehicle was pulled over to the side of the road and was towed back to the dealer. The vehicle was inspected; however, the vehicle was not diagnosed or repaired. The contact was informed that the battery and alternator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.

Incident: February 20, 2024 · Filed: July 15, 2026

Headlight tabs break causing housing to rub against body and crack. Additionally it makes headlights move which necessitates constant readjustment.

Incident: June 30, 2026 · Filed: July 1, 2026

Only the side window airbags deployed during a collision. There was no protection from the front impact. Insurance representatives have the vehicle and we are waiting to hear about the outcome. While in the car pool lane traveling approximately 65mph, a Honda civic left the lane to the right of us and veered directly into our lane. I applied the brakes as hard as I could, but did not swerve due to fear of rolling into the opposite direction of traffic. His back driver side came into my front passenger side at the immediate collision and then we flipped onto the driver side and slid for quite a few feet. Only the airbags on the doors/windows deployed. There was very little reaction time to apply the brakes due to the speed and closeness of the Honda coming into our lane. The airbags in the front console would have protected us from the whiplash we received.

Incident: June 12, 2026 · Filed: June 15, 2026

While checking wiper fluid levels for 2023 Toyota Tacoma TRD Off Road, noticed power steering fluid was below minimum line. No leaks were noticed on the ground where the vehicle is normally parked, underneath the reservoir or along the hoses related to the power steering system. Upon inspecting the tie rod boots, it was noticed that they appeared to be holding fluid, due to signs of moisture on the exterior of the boots. Vehicle was taken to the dealership where purchased. Vehicle was purchased November 2022 and now has approximately 52,000 miles). The dealership service department determined the steering rack seals failed and power steering fluid was dripping into the tie rod boots. Vehicle was out of the 3 year / 36,000 mile warranty and this known issue is not covered by the power train warranty, so 100% of the cost to repair falls upon the owner. Dealer stated that this is a known issue but could not state why a recall was never initiated to alleviate the issue and prevent this costly repair from falling upon the vehicle owners. If not repaired the issue could cause sudden, dramatic increases in steering effort and total loss of vehicle control. Low fluid can also damage internal pump components if not caught early enough.

Incident: March 8, 2026 · Filed: April 21, 2026

Air Bags (Driver and Passenger Curtain Airbags) no other airbags deployed. Been in repair since 3/8/26. Currently 4/21/26. Insurance already sent Body Shop money. Parts on National Backorder and Manufacturer Switch has not been determined yet by Toyota. Truck will not be released back to me until the repair is completed per email. I need adequate transportation provided to continue going to and from work. My insurance has maxed its coverage and cannot extend. I should not be out of pocket more than I already am while waiting on a part that is not in my control. Accident: I hydroplaned and ended in a ditch after going over a T-Intersection. Air bags went off and vehicle was drivable after. Submitted a claim to insurance and here we are.

Incident: January 25, 2026 · Filed: March 31, 2026

I got into a head-on collision with a cement center median going roughly 45-50MPH after fishtailing on black ice. My airbags did not deploy at that speed, I contact toyota corporate and they only removed the CDR information and did not assess the airbag sensors themselves. I was able to press the SOS button for EMS to arrive. My safety was put at risk as none of my airbags deployed. It was not inspected by my insurance company and was taken to an automotive shop to be repaired. No prior warning systems were enacted,