2004 Toyota Tacoma Recalls, Ratings & Complaints

Incident: September 1, 2026 · Filed: October 25, 2026

LOWER BALL JOINT FAILURE.

Incident: November 20, 2017 · Filed: March 25, 2026

Immediately after the manufacturer recall requiring full frame replacement (completed November 2017 by the same dealership referenced below), the vehicle developed abnormal handling not present before the repair, including improper tracking and rear end instability. No warning lights/diagnostic messages were present. These issues were reported to the servicing dealership within weeks and repeatedly over the following years. Despite multiple short initial inspections and two extended service periods—totaling approximately fourteen months in the dealership’s possession—the dealership repeatedly reported no defect found and continued to advise that the vehicle was safe to operate. Due to ongoing safety concerns, an independent inspection was recently obtained. It confirmed measurable rear axle offset and a thrust angle deviation outside acceptable tolerances. The defect is visually apparent: the rear wheels are not symmetrically aligned, and the vehicle exhibits a noticeable “crab walking” effect when viewed from behind. The root cause remains undetermined and would require further diagnostic work and significant disassembly. All documentation and inspection findings are available upon request. Safety risk: The vehicle does not track correctly and shows instability, especially in low traction conditions such as rain or snow, increasing the risk of loss of control. The manufacturer has been formally notified through repeated outreach, including ongoing contact with the Brand Engagement Center since December 2025 and multiple certified letters to Toyota North America Legal/Consumer Affairs between January and March 2026. The only response received was a generic statement from the Brand Engagement Center indicating that the vehicle is out of warranty and an offer to return it to the same dealership that performed the frame replacement and failed to identify the defect. No other response, investigation, or resolution has been provided by Toyota North America.

Incident: January 31, 2026 · Filed: February 14, 2026

I was turning into a gas station and all the sudden the vehicle came to a complete stop i was unable to move the vehicle and sat there until the tow truck was able to show up. Looked under the vehicle and on the passenger side front suspension the lower ball joint was no longer where it belongs.

Incident: November 18, 2018 · Filed: November 1, 2025

My 2004 Toyota Tacoma was part of the frame replacement back in the fall of 2018 when Bobby Rahal Toyota in Mechanicsburg, PA has by truck for over 6 months while they replaced my frame.  It has been determined that my rear differential is rusted and is now to the point of needing replaced.  For over the last year I have tried working with Bobby Rahal to come to and understanding on having this repaired due to the fact that my mechanic believes that this rust is in fact the same issue as the frame and should have been replaced when the frame was.  All they will tell me is that the recall is closed and there is nothing they can do.   Very disappointed in the fact that this was handled when it should have been.  Now I am stuck trying to figure out how to pay for this myself.  I have taken very good care of my truck for over 21 years and there is no reason for me to have to pay out of pocket for something that they should have taken care of during the recall.  I don't have a lift to check the underneath of my truck, I trust when there is a recall that the dealership will do its job and fix everything safely and not put an unsafe vehicle back on the road and wait until a vehicle rusts completely through.  Bobby Rahal was also inspecting the truck at this time so they knew the rear differential was rusted.  My current mechanic said the Rear differential has been rusted since the time they replaced the frame and and has been for many years.   It is irresponsible for Bobby Rahal Toyota to have not replaced the Rear differential axel knowing it was rusted and unsafe. 

Incident: September 1, 2025 · Filed: September 18, 2025

The frame broke

Incident: April 18, 2025 · Filed: June 18, 2025

The contact owns a 2004 Toyota Tacoma equipped with Toyo Tires, Tire Line: Open Country HT, Tire Size: 265/70/R16, DOT Number: CXLJA881918. The contact stated while driving at various speeds, the steering wheel was shuddering significantly. The vehicle was taken to Walmart for the tires to be balanced and the wheels rotated. The mechanic informed the contact that the service could not be performed because the front tires were out of round, the tires belts were separated, and the tire beads were fractured. The tires were not replaced. The tires were replacement tires. The manufacturer was notified of the failure and informed the contact that the tire warranties were not transferable from the previous owner. The vehicle failure mileage was approximately 144,549. The tires failure mileage was approximately 20,000. The VIN was not available.

Incident: December 21, 2022 · Filed: April 22, 2025

I am writing to report a safety related issue with a 2004 Toyota Tacoma that I purchased from an auction on 12/21/2022. The vehicle has an expired recall that I believe has not been properly addressed, potentially affecting the safety of the vehicle. I have attempted to resolve this issue through Toyota's customer service and local dealership, but I have been informed that the recall is no longer active and will not be addressed. It has a Virginia rebuilt title. It failed inspection due to rust on the frame.

Incident: December 13, 2024 · Filed: December 16, 2024

The vehicle has an open recall (NHTSA Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. The problem has been confirmed by the Toyota dealership during inspection, and the rust damage makes the vehicle structurally unsound. The unresolved recall, combined with the excessive frame rust, has created a double safety hazard that needs urgent resolution

Incident: September 4, 2024 · Filed: November 9, 2024

Bringing to your urgent attention a significant safety concern regarding a 2004 Toyota Tacoma owned by my brother, [XXX] , bought in 2004, which has severe frame rust affecting the vehicle’s structural integrity and safety. Despite multiple attempts to resolve this matter directly with Toyota, we have been unable to obtain assistance, as Toyota states the Customer Support Notice for this issue has expired. Given the potential risk this poses to both the driver and other motorists, we are seeking your intervention to address this pressing matter. In September 2024, while retrieving an item from under the truck, my brother discovered extensive rust damage on the vehicle’s frame. We promptly took the truck to Antwerpen Toyota on September 4, 2024, where a technician confirmed the severe rust corrosion and deemed the truck unsafe to drive. The dealership informed us that Toyota had previously issued a Customer Support Notice addressing rust issues on this model but explained that the program had expired. They recommended we contact Toyota directly for potential support or compensation to help acquire a safe vehicle. We reported the case to Toyota (Case No. [XXX]) on September 4, 2024, and have since been in regular contact, yet have only been met with repeated delays and dismissals. Toyota representatives acknowledged that a notice had been issued for this problem, but despite knowing the serious nature of the rust and its impact on the vehicle’s safety, they have not provided us with any solution. We have requested escalation to senior management, but those requests have not been honored. Toyota’s refusal to address this safety defect, even with our willingness to discuss options, has left us with no alternative but to turn to your agency for help. We understand that the notice has expired and that my brother was not the vehicle’s original owner. However, this issue goes beyond a typical warranty claim, as it concerns the fundamental safety and road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 29, 2024 · Filed: January 30, 2024

Vehicle was taken to dealer with frame rust, crack and holes. Toyota refused to fix , repair or offer parts to repair.