NHTSA vehicle safety data

1996 Toyota Tacoma Recalls, Ratings & Complaints

The 1996 Toyota Tacoma has 6 NHTSA recall campaigns and 253 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 1996 Toyota Tacoma, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1996 Toyota Tacoma owner complaints

Owners have filed 253 complaints with NHTSA about the 1996 Toyota Tacoma, describing incidents dated January 1, 1996 to March 15, 2021.

Most-cited components

Suspension 86 complaints
Structure 62 complaints
Tires 20 complaints
Engine 18 complaints
Air Bags 16 complaints
Vehicle Speed Control 12 complaints

Of the 253 complaints on file, 21 report a crash and 1 a fire; across all 253 complaints, owners report 14 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11512855 · Filed March 20, 2023
Rear passenger frame rusted/rotted, rear passenger shock mount completely torn off frame at rust area and rear passenger leaf spring assembly cracked. Vehicle is not drivable and completely unsafe. This vehicle was recalled in May 2008 for inspection of frame rust and passed the inspection with only…
ODI #11403041 · Filed March 15, 2021
I PURCHASED TRUCK IN 2005 FROM TOYOTA OF NICHOLASVILLE KY I HEARD THERE WAS A RECALL NEVER RECEIVED RECALL NOTICE TOOK TRUCK TO HAVE BRAKES DONE MECHANIC REFUSED TO WORK ON IT BECAUSE OF DANGEROUS FRAME HOLES RUST CAN PUSH IN SIDES OF FRAME WITH FINGERS AND MAKE A HOLE MECHANIC SAID IT WAS VERY…
ODI #11385620 · Filed December 30, 2020
TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE REAR PASSENGER'S SIDE OF THE VEHICLE STARTED TO LOWER. AFTER STOPPING TO INSPECT THE VEHICLE, THE CONTACT DISCOVERED THE REAR CENTER LEAF SPRING HAD FRACTURED AND HAD ALSO PUNCTURED THE FUEL TANK CAUSING THE FUEL…

Read all 253 complaints

Owner-reported

1996 Toyota Tacoma mileage at failure

72 of the 253 complaints on file for the 1996 Toyota Tacoma give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 165,000 miles	Middle half 115,000–210,000 miles	Based on 42 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 1996 Toyota Tacoma in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA97-015: TURN SIGNAL FAILURES
Closed September 21, 1998

Open and recently closed NHTSA defect investigations

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Suspension — Front

NHTSA #96V129000 · NHTSA notice

Reported July 10, 1996 · TOYOTA MOTOR CO., LTD.

Potentially affected: 90,000 vehicles

Owners notified September 6, 1996

Defect description

UNDER CERTAIN DRIVING CONDITIONS, THE FRONT SUSPENSION SUPPORT CAN CRACK LEADING TO FAILURE OF THE SUPPORT.

Safety consequence

THIS CONDITION CAN RESULT IN LOSS OF VEHICLE CONTROL.

Manufacturer remedy

DEALERS WILL REPAIR THE SUSPENSION SUPPORT.

Notes

SYSTEM: SUSPENSION; INDEPENDENT; FRONT. VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCK. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN IN LATE AUGUST 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Vehicle Speed Control

NHTSA #96E001000 · NHTSA notice

Reported January 3, 1996 · ROSTRA PRECISION CONTROLS

Potentially affected: 5,145 vehicles

Owners notified January 2, 1996

Defect description

THESE CRUISE CONTROL SYSTEMS FAIL TO HOLD THE SPEED SET BY THE DRIVER AND CAN ACCELERATE ABOVE THE INTENDED SET SPEED.

Safety consequence

UNINTENDED ACCELERATION CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL REPLACE THESE CRUISE CONTROL ASSEMBLIES.

Notes

SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL EQUIPMENT DESCRIPTION:AFTERMARKET CRUISE CONTROL SYSTEM INSTALLED ON CERTAIN TOYOTA PASSENGER VEHICLES AND LIGHT DUTY PICKUP TRUCKS SOLD IN TOYOTA DEALERSHIPS SERVICED BY SOUTHEAST TOYOTA AND GULF STATES TOYOTA DISTRIBUTORS.THE DEALERS WOULD BE LOCATED IN THE FOLLOWING STATES: FLORIDA, ALABAMA, GEORGIA, NORTH CAROLINA, AND SOUTH CAROLINA FOR SOUTHEAST TOYOTAAND TEXAS, OKLAHOMA, MISSISSIPPI, LOUISIANA, AND ARKANSAS FOR GULF STATES TOYOTA.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER IN THESE AFFECTED STATES, ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ROSTRA AT 1-910-276-4853 OR TOYOTA AT 1-800-331-4331.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

1996 Toyota Tacoma

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 2, Passenger: 3

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1 investigation

253 owner complaints have been filed with NHTSA for the 1996 Toyota Tacoma.

Suspension; Structure

ODI #11512855

Incident: February 14, 2012 · Filed: March 20, 2023

Rear passenger frame rusted/rotted, rear passenger shock mount completely torn off frame at rust area and rear passenger leaf spring assembly cracked. Vehicle is not drivable and completely unsafe. This vehicle was recalled in May 2008 for inspection of frame rust and passed the inspection with only surface frame rust found and no rust perforation. Vehicle was recalled again in January 2012 for Limited Service Campaign for New York vehicles for Frame Rust Corrosion, which it failed with substantial corrosion and rusted through holes in the frame. This vehicle was included in this second recall, however the terms of the recall for repair or buyback only extended for 15 years from vehicle’s ‘in service date’, which in this case meant this vehicle was 5 months outside the recall window. So, Toyota included the vehicle in the recall (actually mailed the recall letter), found it had unsafe frame corrosion issues upon inspection 3 weeks after receipt of recall letter, then washed their hands and walked away indicating the ‘in service date’ was 5 months outside the recall window. Makes zero sense and terrible customer service and warranty management.

Suspension; Structure

ODI #11403041

Incident: March 15, 2021 · Filed: March 15, 2021

I PURCHASED TRUCK IN 2005 FROM TOYOTA OF NICHOLASVILLE KY I HEARD THERE WAS A RECALL NEVER RECEIVED RECALL NOTICE TOOK TRUCK TO HAVE BRAKES DONE MECHANIC REFUSED TO WORK ON IT BECAUSE OF DANGEROUS FRAME HOLES RUST CAN PUSH IN SIDES OF FRAME WITH FINGERS AND MAKE A HOLE MECHANIC SAID IT WAS VERY DANGEROUS TO DRIVE!

Suspension

ODI #11385620

Incident: October 1, 2020 · Filed: December 30, 2020

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE REAR PASSENGER'S SIDE OF THE VEHICLE STARTED TO LOWER. AFTER STOPPING TO INSPECT THE VEHICLE, THE CONTACT DISCOVERED THE REAR CENTER LEAF SPRING HAD FRACTURED AND HAD ALSO PUNCTURED THE FUEL TANK CAUSING THE FUEL TO LEAK FROM THE VEHICLE. THE CONTACT INDICATED THAT THE FRACTURED LEAF SPRING WAS SEVERE RUSTED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

Structure

ODI #11244911

Incident: August 16, 2019 · Filed: August 19, 2019

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED WITH HOLES NEAR THE REAR PASSENGER SIDE WHEEL. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER FOR THE MANUFACTURER WARRANTED FRAME REPAIR. WHEN THE CONTACT ARRIVED AT THE DEALER, THE CONTACT WAS INFORMED THAT THE FRAME WAS NOT CORRODED AND THE VEHICLE DID NOT QUALIFY FOR THE BUY BACK PROGRAM. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 115,310. *TT*JB

Structure

ODI #11104864

Incident: May 16, 2018 · Filed: June 30, 2018

THE FRAME ON THE PASSAGER SIDE OF THE TRUCK HAS RUSTED OUT? WILL NOT PASS STATE INSPECTION.

Unknown or Other

ODI #11033195

Incident: October 12, 2017 · Filed: October 13, 2017

RECALL INFO, CAN'T SELL WITHOUT PAPERWORK ON FRAME AND NEW COMPANY IN OUR CITY WON'T OR CAN'T GIVE ME PROOF THAT FRAME IS OK

Structure

ODI #11019932

Incident: August 1, 2017 · Filed: August 27, 2017

ONLY 114,000 MILES, FRAME RUSTED THROUGH. UNSAFE.

Suspension

ODI #11004095

Incident: July 3, 2017 · Filed: July 10, 2017

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE PASSENGER SIDE SUSPENSION SUPPORT WAS DAMAGED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 96V129000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FOLSOM LAKE TOYOTA DEALER WAS CONTACTED AND REFUSED TO DO THE REPAIR BECAUSE THE FAILURE ALREADY OCCURRED ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 278,000. PARTS DISTRIBUTION DISCONNECT.

Suspension; Power Train; Structure

ODI #10948686

Incident: January 29, 2017 · Filed: January 31, 2017

THE FRAME IS RUSTED, IN SOME AREAS, CLEAR THROUGH. THE BRACKETS THAT HOLD SUSPENSION HAVE RUSTED THROUGH. EVERYTHING THAT TOUCHES THE FRAME HAS AN EXCESS AMOUNT OF RUST. THE TRUCK IS PARKED BECAUSE I'M AFRAID IT WILL CAUSE GREAT BODILY HARM IF THE TRUCK FALLS APART WHILE DRIVING. *TR

Structure

ODI #10933656

Incident: December 6, 2016 · Filed: December 7, 2016

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE BY THE DEALER, THE TECHNICIAN STATED THAT THE FRAME FAILED DUE TO CORROSION. IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED AN EXTENDED WARRANTY IN 2011. AT THAT TIME THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DETERMINED THAT THE FRAME WAS FINE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000.

Other Toyota Tacoma model years

Check your 1996 Toyota Tacoma VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Tacoma at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN