NHTSA vehicle safety data

2006 Toyota Tacoma Recalls, Ratings & Complaints

The 2006 Toyota Tacoma has 11 NHTSA recall campaigns and 782 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2006 Toyota Tacoma, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Toyota Tacoma owner complaints

Owners have filed 782 complaints with NHTSA about the 2006 Toyota Tacoma, describing incidents dated April 1, 2005 to February 20, 2026.

Most-cited components

Structure 242 complaints
Suspension 154 complaints
Vehicle Speed Control 147 complaints
Air Bags 76 complaints
Power Train 56 complaints
Service Brakes 48 complaints

Of the 782 complaints on file, 66 report a crash and 7 a fire; across all 782 complaints, owners report 31 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11732953 · Filed April 22, 2026
I received a Toyota recall notification in Dec 2015 for a frame rust inspection, RO Number 307016. I have since noticed fairly major frame rust, with a long 2-inch by 7-inch opening on the inside of the frame below the driver-side seat. I took the vehicle to Toyota on 20 APR 2026 for a leaf spring…
ODI #11719698 · Filed February 22, 2026
Voss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.
ODI #11701881 · Filed November 28, 2025
I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till…

Read all 782 complaints

Owner-reported

2006 Toyota Tacoma mileage at failure

589 of the 782 complaints on file for the 2006 Toyota Tacoma give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 95,000 miles	Middle half 60,000–130,000 miles	Based on 195 complaints
Suspension	Median 95,000 miles	Middle half 65,000–130,000 miles	Based on 81 complaints
Vehicle Speed Control	Median 35,000 miles	Middle half 15,000–75,000 miles	Based on 120 complaints
Air Bags	Median 85,000 miles	Middle half 60,000–105,000 miles	Based on 68 complaints
Power Train	Median 30,000 miles	Middle half 11,000–75,000 miles	Based on 41 complaints
Service Brakes	Median 50,000 miles	Middle half 18,000–80,000 miles	Based on 41 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Most complaints NHTSA received since May 17, 2021 give no mileage. So that they aren't undercounted, each one received since then that gives a mileage also stands in for those that gave none, which can put a component's median above most of the mileages it is based on.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Toyota Tacoma in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP08-001: SUDDEN AND UNCONTROLLED ACCELERATION
Closed August 27, 2008

Open and recently closed NHTSA defect investigations

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2005 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Leaf Spring may Fracture and Puncture Tank

NHTSA #14V604000 · Suspension — Rear — Springs — Leaf Spring Assembly — Leaf · NHTSA notice

Reported September 29, 2014 · Toyota Motor Engineering & Manufacturing

Potentially affected: 710,711 vehicles

Repair completion: 47.6% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2016 · Vehicles built September 14, 2009 – December 6, 2010 (per NHTSA)

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.

Safety consequence

If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.

Manufacturer remedy

Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Belt Screws May Loosen

NHTSA #13V337000 · Seat Belts · NHTSA notice

Reported August 7, 2013 · Toyota Motor Engineering & Manufacturing

Potentially affected: 342,451 vehicles

Repair completion: 49.74% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified February 24, 2014 · Vehicles built September 14, 2004 – March 29, 2010 (per NHTSA)

Defect description

Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.

Safety consequence

If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.

Manufacturer remedy

Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

AIRBAG CLOCKSPRING SPIRAL CABLES

NHTSA #12V092000 · Air Bags — Frontal · NHTSA notice

Reported March 7, 2012 · Toyota Motor Engineering & Manufacturing

Potentially affected: 495,470 vehicles

Owners notified August 3, 2012 · Vehicles built September 14, 2004 – August 29, 2008 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.

Safety consequence

IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE.THE SAFETY RECALL IS EXPECTED TO BEGIN IN EARLY APRIL 2012.OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

PEDAL ENTRAPMENT

NHTSA #09V388000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported October 5, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 4,445,056 vehicles

Toyota campaign 90L(TOYOTA)/90LG(LEX · Owners notified December 31, 2009

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Notes

TOYOTA RECALL NO. 90L/90LG.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INCORRECT GVWR LABELS

NHTSA #09V223000 · Equipment — Other — Labels · NHTSA notice

Reported June 15, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 27,080 vehicles

Owners notified September 18, 2009 · Vehicles built September 1, 2005 – May 4, 2009 (per NHTSA)

Defect description

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Safety consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Notes

AIR BAG INFLATOR

NHTSA #06V096000 · Air Bags · NHTSA notice

Reported April 3, 2006 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 133 vehicles

Toyota campaign 60B 6LB · Owners notified April 6, 2006 · Vehicles built April 20, 2005 – November 29, 2005 (per NHTSA)

Defect description

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Safety consequence

THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Notes

TOYOTA RECALL NO. 60B AND LEXUS RECALL NO. 6LB.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

IMPROPER TIRE ASSEMBLY

NHTSA #06V061000 · Tires — Bead · NHTSA notice

Reported March 2, 2006 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 12,020 vehicles

Toyota campaign 60A · Owners notified March 27, 2006 · Vehicles built August 23, 2005 – December 13, 2005 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.

Safety consequence

IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. SSC 60A.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Toyota Tacoma Regular Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: Not Rated

Side Pole

Not Rated

Rollover

19% rollover risk

Safety Technology

1 investigation

2006 Toyota Tacoma 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

19% rollover risk

Safety Technology

1 investigation

2006 Toyota Tacoma Extended Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: Not Rated

Side Pole

Not Rated

Rollover

19% rollover risk

Safety Technology

1 investigation

782 owner complaints have been filed with NHTSA for the 2006 Toyota Tacoma.

Structure

ODI #11732953

Incident: December 8, 2015 · Filed: April 22, 2026

I received a Toyota recall notification in Dec 2015 for a frame rust inspection, RO Number 307016. I have since noticed fairly major frame rust, with a long 2-inch by 7-inch opening on the inside of the frame below the driver-side seat. I took the vehicle to Toyota on 20 APR 2026 for a leaf spring recall #302870. I asked them to take a look and was told the recall 307016 had expired. The original recall inspection for rust either failed to identify it or the inspector was inadequate at identifying it.

Suspension

ODI #11719698

Incident: February 20, 2026 · Filed: February 22, 2026

Voss Toyota would not perform the recall of new leaf springs that has not been completed on my truck. The frame is rusty and they will not touch my truck. There should be an existing recall or customer satisfaction program on the frame of this truck that needs done as well.

Suspension; Structure

ODI #11701881

Incident: December 17, 2024 · Filed: November 28, 2025

I took my 2006 Toyota Tacoma ext cab 4x4 v6 to have diagnostic run on it . "EXACT PERFORMANCE " Johnson drive . KCK The differential was shot . However , that was not the final . They did not do full diagnostic . They informed me that my frame was rotted and rusted through and would not last till spring and was a safety hazard. That was Dec. 2024 . The truck has been parked since . Ive had no transportation and can not run right out and buy another truck . I am also not willing to give up the truck either . I have put a lot of hard earned money into this truck believing it to last forever . The motor and train are sound . I do not want to junk the truck . Please , tell me what I can do . Yes . My vehicle is available for inspection upon request.

Steering; Suspension; Structure

ODI #11660044

Incident: May 9, 2025 · Filed: May 9, 2025

The frame of my 2006 Toyota Tacoma (VIN: [XXX] ) is severely corroded and compromised. I recently acquired the vehicle and discovered that it was part of a past Toyota recall/program for frame corrosion inspection and replacement. However, it appears the previous owner did not take the vehicle in for the service. The frame now shows advanced rust and structural weakness, which puts my safety and the safety of others at risk. I am concerned that the recall program was not adequately communicated or tracked, and I am requesting that the NHTSA review this issue for potential reopening or expansion of coverage for affected vehicles like mine. The vehicle is available for inspection if needed. Thanks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Structure

ODI #11654146

Incident: April 11, 2025 · Filed: April 11, 2025

The contact owns a 2006 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the contact heard a loud noise coming from the rear of the vehicle with no warning light illuminated. The contact stated that while the vehicle was parked, the contact noticed that the rear subframe of the vehicle was fractured. The vehicle was towed to an independent mechanic, where it was diagnosed that the rear subframe of the vehicle failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 230,000.

Air Bags

ODI #11649601

Incident: March 20, 2025 · Filed: March 20, 2025

The contact owns a 2006 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 12V092000 (Air Bags), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 220,000.

Structure

ODI #11640578

Incident: January 16, 2025 · Filed: February 4, 2025

The contact owns a 2006 Toyota Tacoma. The contact stated that the vehicle failed the State Inspection because there was a hole approximately 3 inches wide on the driver's side of the vehicle near the catalytic converter. The vehicle was taken to the dealer, who confirmed that the hole was caused by extensive rust and needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was a recall issued twice; however, the recall had expired. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 130,000.

Suspension; Unknown or Other

ODI #11639471

Incident: January 19, 2025 · Filed: January 29, 2025

The truck's frame has severely rusted. The frame has deteriorated. It is unsafe to drive as the frame is breaking in half. According to Toyota, this was a huge problem with the 2006 Tacoma. They will not fix the frame or offer any solution. My son can not safely drive this vehicle.

Structure

ODI #11638619

Incident: January 2, 2024 · Filed: January 26, 2025

I went in to get my truck worked on & was told it was not safe. The frame is rusted and cracked. I did not receive a recall notification. Now, I have a broken truck and cannot afford to buy another vehicle or pay to repair this one. This is a safety hazard for the other people on the road and a death trap for the owners with vehicles that Toyota will not stand behind.

Structure

ODI #11611136

Incident: February 7, 2024 · Filed: August 27, 2024

Toyota Tacoma 2006 TRD, This vehicle was recalled for rust to the frame on 10/03/2018. The frame was replaced by Sheehy Toyota of Fredericksburg, Virginia. The work was done and completed con 02/07/2019. The vehicle supposedly was thoroughly inspected for any problems by the dealership. Then released to me after the work was done. Then in November of 2019 I moved from Virginia to Nebraska. Used this truck to move with and pulled a trailer over 2,000 miles with it. Little did I know my life was in danger due to negligence by the dealers service department. Recently I replaced the rear bumper on this truck. By doing this it fully exposed the trailer hitch system on the truck. This is when I clearly seen that a part of the trailer hitch was completely rusted through. When replacing the frame on this truck the dealership had to notice this severely damaged part. Yet they did not inform me of this situation. If they had, I would have had the part replaced, due to the chance of it breaking which could have caused an accident. This is nothing short of pure negligence on the part of this dealership. People could have been severely injured or killed due to this negligence. I have pictures of this part just the way they left it.

Other Toyota Tacoma model years

Check your 2006 Toyota Tacoma VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Tacoma at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN