2019 Jeep Wrangler Recalls & Complaints

Incident: October 19, 2026 · Filed: October 27, 2026

voltage regulator chip failure can cause the engine to stall or fail to start completely. Interior dashboard lights and dome lights along w/ windshield wipers going off without prompted happen after vehicle shutoff. Had to jump it to begin to start at times. Similar to recall U87.

Incident: September 3, 2026 · Filed: October 16, 2026

Cluster panel failed. Dashboard is completely dark (ie. no speedometer, fuel guage. etc)

Incident: October 3, 2026 · Filed: October 15, 2026

On [XXX], my 2019 Jeep Wrangler Unlimited Rubicon (2.0L turbo) caught fire in the engine compartment while driving, at approximately 101,437 miles. The fire started near the turbocharger and heat shield area. There were no injuries, but the vehicle was moving on a public road with four occupants, including two young children in car seats in the rear, when the fire started. The vehicle had been returned to me four days earlier, after approximately 2.5 months at Preferred Chrysler Dodge Jeep of Muskegon, MI for a timing chain replacement. After the fire, I found that the coolant reservoir hose had come off its fitting, and the hose barb appears to have been broken and the hose pushed back on. Several under-hood trim fasteners were also missing. My best assessment is that coolant sprayed onto the hot turbo/exhaust components and ignited. The vehicle has not been altered since the fire and is available for inspection at Watson's in Ludington, MI. I reported the fire to the manufacturer. They directed me to take it to the local dealer, then instructed the dealer not to inspect or work on it. The case was escalated internally, but as of 10/15/2026 no manufacturer inspection has occurred and no one has contacted me. The cause has not been confirmed by a dealer or independent shop. The fire occurred within the vehicle's Certified Pre-Owned warranty period. As of this filing, the manufacturer has not provided towing, rental, or any other assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 24, 2026 · Filed: October 13, 2026

The contact owns a 2019 Jeep Wrangler. The contact stated that while driving approximately 40 MPH, the instrument panel cluster suddenly went black. The contact pulled to the side of the road and waited for a family member to follow closely behind to ensure a safe drive, as essential driving information was no longer visible. The vehicle was taken to the dealer, where it was diagnosed that the instrument panel cluster had failed and required a complete assembly replacement. The vehicle was pending repair. The contact learned of NHTSA Campaign Number: 24V652000 (Electrical System); however, the vehicle was not covered under the recall because the VIN was not included. The manufacturer was notified and confirmed that the VIN was not included in the recall. The failure mileage was approximately 81,000.

Incident: October 1, 2026 · Filed: October 12, 2026

FCA US sent me a written warranty extension (15 years/150,000 miles) for the instrument panel cluster on my vehicle, covering a blank EVIC display with no digital speedometer, fuel level, temperature, odometer, or PRNDL. My vehicle has this condition intermittently. As I was traveling approximately 55 mph my power steering, antilock brakes, speedometer, fuel gauge, traction control, all-wheel drive, and emergency brake warning lights came on/off. I actually lost power steering and was unable to turn the vehicle off. I reached out to Jeep and advised them of this and that I received the letter for the instrument panel cluster XZ1 and I thought this was related. I read the letter to them word for word, and they had the dealership perform the recall on my clutch. I didn't know until all of the same things happened again and I checked the receipt to confirm the work performed. I reached out to Jeep the same day and that was more than a week ago. I now have a new service transmission light. My vehicle is not safe to drive and they still don't even know why I called. My case number with Jeep is 98166358.

Incident: September 27, 2026 · Filed: September 28, 2026

The contact owns a 2019 Jeep Wrangler. The contact stated that while driving approximately 45-50 MPH northbound on the Hutchinson River Parkway, the steering wheel failed to operate as needed. The vehicle was uncontrollable and started drifting towards the left before crashing into the highway barrier. The message “Electronic Driver Assist” was displayed. The vehicle was towed to the body shop. The manufacturer was contacted by phone, and the contact spoke with a customer representative, and a case was opened. The contact was informed that the investigating team would reach out in 2 to 4 days. An inspector had been assigned by Geico Insurance Company. The approximate failure mileage was 59,000.

Incident: August 26, 2026 · Filed: September 24, 2026

The 48-Volt Lithium-Ion eTorque Hybrid Battery Pack (Mopar Power Pack Unit/PPU) on my 2019 Jeep Wrangler Sahara Unlimited (~55K miles) failed. The failed component may be available on video by the dealership. Check engine light first appeared early XXX. Earliest dealership appointment was late August 2026. At that visit, dealer diagnosed DTCs P0A94 (recurring, including P0A94-03) and U0412, and performed a software update flashing the BPCM (Battery Pack Control Module) firmware from 05057870AN to 05057870AV per a Technical Service Bulletin. This was covered under warranty at no charge; vehicle was returned to me. Days later, the check engine light returned along with a battery warning light and additional indicators, including ABS among others I could not fully identify. The vehicle then lost power and stopped running while in the roadway, disabled in an active lane of travel — a safety hazard to myself and surrounding traffic. Vehicle was towed to the dealership XXX. On this second visit, the dealership attributed the failure to moisture exposure and corrosion at the PPU connector/harness, denied warranty coverage, and charged me $4,561.90. I received the repaired vehicle XXX. I opened a case with Stellantis Customer Care (Case #XXX) with case manager [XXX] to request a technical review of the failure and the warranty denial. [XXX] stated he contacted the dealership five times seeking information or resolution and received no response. He offered rental car reimbursement up to $50/day during the repair. Dealership diagnosed and repaired the vehicle on both occasions. No known inspection by manufacturer, police, or insurance beyond the review requested under Stellantis case #XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 21, 2026 · Filed: September 23, 2026

My 2019 Jeep Wrangler has experienced a failure of the Blind Spot Monitoring system. The vehicle repeatedly displays a “Blind Spot Alert Temporarily Unavailable” warning, causing the blind spot detection system to become unavailable while driving. The vehicle was inspected and diagnosed by an authorized Jeep dealership. Diagnostic trouble codes were present, and I was advised that Stellantis has issued a service bulletin addressing this condition and that the diagnostic codes indicate replacement of the mirror glass/components associated with the blind spot monitoring system. This concerns me because the system is an important safety feature designed to alert the driver to vehicles located in areas that may not be visible in the mirrors. When the system fails, those warnings are unavailable. Despite this being a documented issue addressed by a manufacturer service bulletin, I was informed that there is currently no recall and that the necessary mirror replacement is not covered under my extended warranty. I am filing this complaint because I believe a recurring failure involving a vehicle safety system should be documented and investigated to determine whether other Jeep Wrangler owners are experiencing the same problem and whether further manufacturer action is warranted.

Incident: September 17, 2026 · Filed: September 17, 2026

The contact owns a 2019 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, one of the brake calipers locked up, causing the vehicle to veer from side to side during acceleration. The vehicle was driven to an independent mechanic, where a technician diagnosed it with a seized brake caliper. Due to the constant dragging, the brake pads wore excessively and failed to slow the vehicle properly, extending the stopping distance. The brake parts were replaced, and the vehicle was repaired.

Incident: September 3, 2026 · Filed: September 17, 2026

The left front brake line has failed and needed replacement on 2 occasions. The brake line gets a restriction that causes the vehicle to veer to the right under braking. It also is causing uneven rotor and caliper ware resulting in a high pitched squeal under load.