NHTSA vehicle safety data

2011 Chevrolet Suburban Recalls & Complaints

The 2011 Chevrolet Suburban has 3 NHTSA recall campaigns and 148 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2011 Chevrolet Suburban. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2011 Chevrolet Suburban owner complaints

Owners have filed 148 complaints with NHTSA about the 2011 Chevrolet Suburban, describing incidents dated November 8, 2011 to February 2, 2026.

Most-cited components

Air Bags 66 complaints
Unknown or Other 46 complaints
Structure 26 complaints
Electrical System 10 complaints
Engine 10 complaints
Fuel/Propulsion System 6 complaints

Of the 148 complaints on file, 3 report a crash; across all 148 complaints, owners report 10 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11737613 · Filed May 13, 2026
I am experiencing the symptoms listed for the ignition coil recall listed 20011 suburban, but the recall is not on my vin. I've been experiencing the symptoms for quite some time now yrs even, but didn't know about the ignition recall. I've been replacing and fixing the parts and damage to the…
ODI #11715292 · Filed February 3, 2026
Odometer Fraud. The contact purchased a 2011 Chevrolet Suburban. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 133,000. The contact stated that at the time of registration, it was discovered that the mileage was…
ODI #11645734 · Filed March 1, 2025
This is not connected with a specific crash in this vehicle. It is a defect with all vehicles with this seat. There is known common defect with the stitching on the side of the front seats covering the airbag. The stitching is designed to come apart if an airbag is deployed. The defective stitching…

Read all 148 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2011 Chevrolet Suburban in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V050000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 2,641,272 vehicles

Repair completion: 44.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328760 · Owners notified March 1, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V054000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 1,778,128 vehicles

Repair completion: 63.26% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328800 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Ignition Lock Actuator may Bind

NHTSA #14V827000 · Electrical System — Ignition · NHTSA notice

Reported December 30, 2014 · General Motors LLC

Potentially affected: 84,192 vehicles

Repair completion: 63.29% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14696 and 14912 · Owners notified February 12, 2015 · Vehicles built May 9, 2011 – March 8, 2012 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Safety consequence

If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Manufacturer remedy

GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2011 Chevrolet Suburban. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

148 owner complaints have been filed with NHTSA for the 2011 Chevrolet Suburban.

Unknown or Other

ODI #11737613

Incident: May 15, 2023 · Filed: May 13, 2026

I am experiencing the symptoms listed for the ignition coil recall listed 20011 suburban, but the recall is not on my vin. I've been experiencing the symptoms for quite some time now yrs even, but didn't know about the ignition recall. I've been replacing and fixing the parts and damage to the vehicle. Fortunately no accidents or injuries to report. I am currently experiencing my door locks cycling , brief losses of power while vehicle is in drive, on highway, My electrical components periodically work seat warmer, sensors oil, air, coil packs, cooling fans (the relays keeps burning out), Ac motor, water pump, cruise control, the main fuse, and 4 x4 engaging on its own.

Electrical System

ODI #11715292

Incident: February 2, 2026 · Filed: February 3, 2026

Odometer Fraud. The contact purchased a 2011 Chevrolet Suburban. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 133,000. The contact stated that at the time of registration, it was discovered that the mileage was 233,793.

Air Bags

ODI #11645734

Incident: February 28, 2025 · Filed: March 1, 2025

This is not connected with a specific crash in this vehicle. It is a defect with all vehicles with this seat. There is known common defect with the stitching on the side of the front seats covering the airbag. The stitching is designed to come apart if an airbag is deployed. The defective stitching deteriorates and falls apart. This exposes the airbag system in the seat. This occurs on all GM vehicles with the same leather seats. Models include Suburbans, Yukons, and pickup trucks. In this Suburban the stiching started to come apart about 6 years ago with a few loose threads. The entire side of the seat has now come apart. The rest of the seat is in relatively good repair without any holes, rips or torn stitching. GM claims this is cosmetic and not covered. The safety issues caused by this includes the potential deterioration of the airbag system interfering with deployment in a crash. Another safety issue is the potential for foreign objects to get lodged in this space and injuring someone if the airbag goes off. The third safety issue is the potential of a person, or child, to access the airbag and cause it to go off without warning.

Fuel System, Gasoline

ODI #11604440

Incident: May 15, 2024 · Filed: July 25, 2024

The contact owns a 2011 Chevrolet Suburban. The contact stated that on several occasions while driving with the cruise control feature activated, there was a clanking noise coming from under the vehicle, and the contact smelled a fuel odor. The vehicle was steered to the side of the road and inspected. The contact stated that the fuel tank was swollen. The vehicle was taken to the residence. The vehicle was then taken to an independent mechanic who could not provide a cause for the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 191,000.

Suspension

ODI #11583775

Incident: March 20, 2019 · Filed: April 18, 2024

The contact owns a 2011 Chevrolet Suburban. The contact stated that upon inspecting the vehicle, he noticed that the rear end of the vehicle was leaking. The vehicle was taken to the dealer, where it was determined that the rear end pinion yoke needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that the dealer had replaced the rear end pinion yoke several times; however, the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 11V007000 (Suspension); however, the VIN was not included. The manufacturer was notified of the failure. The failure mileage was approximately 71,333.

Fuel System, Gasoline

ODI #11529199

Incident: June 26, 2023 · Filed: June 27, 2023

The contact owns a 2011 Chevrolet Suburban. The contact stated while driving 45 MPH, he heard an abnormal sound coming from underneath the vehicle. Upon visual inspection, the contact observed that the rear fuel tank had expanded abnormally and was resting on the driveshaft. No warning lights were illuminated. The vehicle was towed to the residence and remained at the residence. After investigating the failure, the contact related the failure to NHTSA Campaign Number 17V664000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 150,000.

Seat Belts

ODI #11521791

Incident: May 5, 2023 · Filed: May 13, 2023

The ignition key is falling out of the ignition when it is in the run position similar to other vehicles that were recalled. I am concerned that we will not be able to turn off the engine in an emergency. We are also having problems with one of the seatbelts not latching.

Unknown or Other; Forward Collision Avoidance

ODI #11494786

Incident: November 24, 2022 · Filed: November 24, 2022

Dash cracked and cruise control wont turn on when button pushed.

Air Bags

ODI #11458139

Incident: March 17, 2022 · Filed: March 24, 2022

The contact owns a 2011 Chevrolet Suburban. The contact stated that the air bag warning light was illuminated on the instrument panel. The contact later received a recall notification for NHTSA Campaign Number: 21V050000 (Air Bags) which she associated to the failure. The vehicle was taken to the dealer for the recall repair; however, upon picking up the vehicle, the contact noticed that the air bag warning light remained illuminated. The vehicle was taken back to the dealer who provided the contact with a diagnostic fee. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Air Bags

ODI #11453455

Incident: February 22, 2022 · Filed: February 22, 2022

Takata Recall. The contact owns a 2011 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 21V054000 (Air Bags) however, the dealer informed the contact that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Other Chevrolet Suburban model years

Check your 2011 Chevrolet Suburban VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Suburban at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN