try.vin
Log in

NHTSA vehicle safety data

2003 Chevrolet Suburban Recalls, Ratings & Complaints

The 2003 Chevrolet Suburban has 7 NHTSA recall campaigns and 306 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2003 Chevrolet Suburban, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Chevrolet Suburban owner complaints

Owners have filed 306 complaints with NHTSA about the 2003 Chevrolet Suburban, describing incidents dated February 4, 2002 to May 21, 2026.

Most-cited components

  • Service Brakes 91 complaints
  • Electrical System 82 complaints
  • Steering 22 complaints
  • Power Train 21 complaints
  • Air Bags 19 complaints
  • Vehicle Speed Control 15 complaints

Of the 306 complaints on file, 23 report a crash and 5 a fire; across all 306 complaints, owners report 30 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11739251 · Filed

    Odometer Fraud. The contact purchased a 2003 Chevrolet Suburban. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 291,000 and at the time of inspection, it was discovered that the odometer was tampered with, and…

  • ODI #11687853 · Filed

    The contact owns a 2003 Chevrolet Suburban. The contact stated that while driving at 40 MPH, the contact noticed the trailer attached was moving from left to right independently, and the trailer detached from his vehicle. The contact mentioned that he lost control of the vehicle into a parallel…

  • ODI #11603498 · Filed

    The cluster of the speedometer

Read all 306 complaints

Owner-reported

2003 Chevrolet Suburban mileage at failure

237 of the 306 complaints on file for the 2003 Chevrolet Suburban give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Service BrakesMedian 105,000 milesMiddle half 75,000–145,000 milesBased on 85 complaints
Electrical SystemMedian 80,000 milesMiddle half 50,000–100,000 milesBased on 57 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Chevrolet Suburban in 6 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

1 more NHTSA investigation
Open and recently closed NHTSA defect investigations

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SEAT BELT ROUTING

NHTSA #05V163000 · Seat Belts — Rear/Other · NHTSA notice

Reported April 22, 2005 · GENERAL MOTORS CORP.

Potentially affected: 1,359,824 vehicles

Manufacturer campaign 05037 · Owners notified July 21, 2005 · Vehicles built April 3, 2002 – July 31, 2003 (per NHTSA)

Defect description

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.

Safety consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Manufacturer remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.

Notes

GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 135/BRAKE VALVE

NHTSA #04V045000 · Service Brakes, Hydraulic · NHTSA notice

Reported February 4, 2004 · GENERAL MOTORS CORP.

Potentially affected: 68,875 vehicles

Manufacturer campaign 04004 · Owners notified June 18, 2004 · Vehicles built May 1, 2003 – July 31, 2003 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Safety consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Manufacturer remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Notes

GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

SOUTHERN COMFORT/RUNNING BOARDS

NHTSA #03V094000 · Structure · NHTSA notice

Reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS

Potentially affected: 3,674 vehicles

Owners notified March 7, 2003 · Vehicles built August 1, 2000 – March 3, 2003 (per NHTSA)

Defect description

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Safety consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 214/REAR DOOR UPPER HINGE WELDS

NHTSA #03V037000 · Structure — Body — Door — Hinge and Attachments · NHTSA notice

Reported February 6, 2003 · GENERAL MOTORS CORP.

Potentially affected: 107 vehicles

Manufacturer campaign 03004 · Owners notified February 17, 2003 · Vehicles built October 1, 2002 – October 31, 2002 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.

Safety consequence

AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.

Notes

GM RECALL NO. 03004. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/CROSS MEMBER FRACTURE/FUEL TANK PUNCTURE

NHTSA #03V019000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported January 27, 2003 · GENERAL MOTORS CORP.

Potentially affected: 5,734 vehicles

Manufacturer campaign 03002 · Owners notified February 20, 2003 · Vehicles built April 1, 2002 – January 31, 2003 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.

Safety consequence

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Notes

GM RECALL NO. 03002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Chevrolet Suburban model years

Check your 2003 Chevrolet Suburban VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Suburban at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN