NHTSA vehicle safety data

2009 Chevrolet Suburban Recalls, Ratings & Complaints

The 2009 Chevrolet Suburban has 5 NHTSA recall campaigns and 106 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2009 Chevrolet Suburban, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2009 Chevrolet Suburban owner complaints

Owners have filed 106 complaints with NHTSA about the 2009 Chevrolet Suburban, describing incidents dated November 18, 2009 to January 5, 2025.

Most-cited components

Air Bags 38 complaints
Unknown or Other 23 complaints
Electrical System 16 complaints
Engine 12 complaints
Structure 11 complaints
Latches/Locks/Linkages 8 complaints

Of the 106 complaints on file, 1 reports a crash; across all 106 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11635537 · Filed January 12, 2025
Unknown
ODI #11604465 · Filed July 25, 2024
Fuel pump modulator, which has a recall for other vehicles for same part, malfunctioned which caused the vehicle to cut off while my son was driving on the highway without notice, where he had to avoid being hit while trying to make it to the shoulder for safety. The fuel pump module was tested by a…
ODI #11532139 · Filed July 13, 2023
Cooper Discoverer 275-55r20 had a stranger point out a very large bulge on the inner sidewall of my passenger side rear tire. This is the 3rd tire from a set of 4 that has developed the same issue within 3 months. Cooper Tires is not wanting to help resolve this issue. They want the tire dissected…

Read all 106 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2009 Chevrolet Suburban in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V052000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 557,023 vehicles

Repair completion: 54.81% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328780 · Owners notified September 20, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V053000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 692,526 vehicles

Repair completion: 56.96% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328790 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V050000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 2,641,272 vehicles

Repair completion: 44.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328760 · Owners notified March 1, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HEATED WINDSHIELD WASHER MODULE SHORT CIRCUIT

NHTSA #10V240000 · Electrical System · NHTSA notice

Reported June 4, 2010 · GENERAL MOTORS CORP.

Potentially affected: 1,365,070 vehicles

Owners notified June 11, 2010

Defect description

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Safety consequence

IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Manufacturer remedy

DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FUEL SYSTEM CONTROL MODULE

NHTSA #09V154000 · Fuel System, Gasoline · NHTSA notice

Reported May 6, 2009 · GENERAL MOTORS CORP.

Potentially affected: 27,188 vehicles

Manufacturer campaign 08411 · Owners notified May 18, 2009 · Vehicles built June 1, 2008 – September 30, 2008 (per NHTSA)

Defect description

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

Safety consequence

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

Notes

GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

2009 Chevrolet Suburban 1500 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

24% rollover risk

Safety Technology

Electronic Stability Control

1 investigation

2009 Chevrolet Suburban 2500 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

Electronic Stability Control

1 investigation

106 owner complaints have been filed with NHTSA for the 2009 Chevrolet Suburban.

Air Bags

ODI #11635537

Incident: January 5, 2025 · Filed: January 12, 2025

Unknown

Fuel/Propulsion System

ODI #11604465

Incident: July 23, 2024 · Filed: July 25, 2024

Fuel pump modulator, which has a recall for other vehicles for same part, malfunctioned which caused the vehicle to cut off while my son was driving on the highway without notice, where he had to avoid being hit while trying to make it to the shoulder for safety. The fuel pump module was tested by a service mechanic and was found to have corroded due to moisture. Prior to vehicle cutting off, there were no warning signals/signs, it just cut the vehicle off while driving on the highway.

Tires

ODI #11532139

Incident: June 24, 2023 · Filed: July 13, 2023

Cooper Discoverer 275-55r20 had a stranger point out a very large bulge on the inner sidewall of my passenger side rear tire. This is the 3rd tire from a set of 4 that has developed the same issue within 3 months. Cooper Tires is not wanting to help resolve this issue. They want the tire dissected and returned before doing anything.

Tires

ODI #11532137

Incident: May 19, 2023 · Filed: July 13, 2023

On 05/19/2023 driver's side front wheel removed for brake replacement. Noticed large bulge on inner sidewall of Cooper Discoverer 275-55r20 tire. This was the 2nd tire of a set of 4 that has developed the same issue. Now a third has a bulge. I will submit a 3rd report for it.

Tires

ODI #11532133

Incident: March 8, 2023 · Filed: July 13, 2023

Cooper Discoverer 275-55r20 developed bulge in inner sidewall. I was unaware of issue until a stranger pointed it out. That was on 03/08/2023. Since then, 2 more tires have developed the same issue!! The last 2 have been looked at by tire installation professionals and determined to be manufacturer defects.

Fuel System, Gasoline

ODI #11496068

Incident: November 14, 2022 · Filed: December 5, 2022

The contact owns a 2009 Chevrolet Suburban. The contact stated that the vehicle intermittently failed to start after multiple attempts without warning. The contact replaced the ignition switch and the fuel pump; however, the failure persisted. The contact then used a code reader that determined that the Engine Control Module (ECM) was not giving a signal to the fuel pump. The contact made additional repairs to the vehicle, but the failure persisted. The vehicle was taken to the dealer, and he was given an estimate for the repair. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 09V154000 (Fuel System, Gasoline). The manufacturer was notified of the failure and informed him that his vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 200,000.

Electrical System

ODI #11478346

Incident: August 4, 2022 · Filed: August 9, 2022

The contact owns a 2009 Chevrolet Suburban. The contact stated that while her son was seated in the driver's side front seat with the door opened, the key was not in the ignition, the doors inadvertently locked and unlocked. The contact's son noticed that there was smoke coming from the dash and exited the vehicle. Upon inspection, the contact and her son detected a burning odor and noticed that there was smoke coming from underneath the hood; however, there were no flames. The contact's son opened the hood and disconnected the battery. The fire department arrived and inspected the vehicle. The fireman informed the contact that the alternator and battery connectors were extremely hot. The fire department assisted in moving the vehicle away from the residence. A fire department report was filed. The vehicle was towed to the dealer; however, the vehicle was diagnosed but still hasn't been repaired. The contact related the failure to a faulty electrical system. The vehicle was not yet deemed totaled by the insurance company. The manufacturer was made aware of the failure. The failure mileage was approximately 133,000.

Structure

ODI #11448706

Incident: January 24, 2022 · Filed: January 24, 2022

Dashboard cracked around the corner of the passenger side air bag and manufacturer did not recall. It appears there are many vehicles with this problem and could be a potential safety issue if the airbag malfunctioned and caused parts of dash to break and rupture air bag or fly into passengers of vehicle in the event of a crash.

Air Bags

ODI #11432342

Incident: February 2, 2021 · Filed: September 9, 2021

I am STILL waiting for this recall to be fixed. Why is this taking so long? Every time I drive this vehicle, it is a danger for my passenger due to the defective airbag. It almost seems to me that maybe this is a stall tactic so there will be less of a cost for the repairs due to the less vehicles still on the road. Just my opinion. I would like to know what is taking so long to fix. It is already late 2021 and this vehicle is a 2009. Wow. I guess the safety of the customers is second to the cost of repairs.

Engine

ODI #11406454

Incident: March 1, 2021 · Filed: April 5, 2021

TL* THE CONTACT OWNS A 2009 CHEVROLET SUBURBAN. THE CONTACT STATED WHILE DRIVING 45 MPH, THE VEHICLE STARTED TO SPUTTER AND SHAKE WITH A LOUD KNOCKING SOUND COMING FROM THE ENGINE. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE SHIFTED INTO LIMP MODE AND DECELERATED. THE VEHICLE WAS DRIVEN BACK TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE WAS LOW ON OIL. ADDITIONALLY, THE NUMBER 6 LIFTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.*DT

Other Chevrolet Suburban model years

Check your 2009 Chevrolet Suburban VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Suburban at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN