NHTSA vehicle safety data

2005 Toyota Prius Recalls, Ratings & Complaints

The 2005 Toyota Prius has 6 NHTSA recall campaigns and 1,051 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2005 Toyota Prius, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Toyota Prius owner complaints

Owners have filed 1,051 complaints with NHTSA about the 2005 Toyota Prius, describing incidents dated September 3, 2004 to February 14, 2026.

Most-cited components

Exterior Lighting 346 complaints
Service Brakes 280 complaints
Electrical System 178 complaints
Vehicle Speed Control 109 complaints
Engine 79 complaints
Air Bags 44 complaints

Of the 1,051 complaints on file, 102 report a crash and 4 a fire; across all 1,051 complaints, owners report 66 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11718280 · Filed February 16, 2026
Eingen faliur acording to dealership Toyota of Anthioc the veicle is on there lot for now but there diagnostic was engine faliure
ODI #11710245 · Filed January 11, 2026
ABS actuator failed and had little to no braking action while merging on the freeway. Had to swerve to avoid collision on interstate
ODI #11698556 · Filed November 10, 2025
The contact owns a 2005 Toyota Prius. The contact stated that while driving at an undisclosed speed, the left turn signal was activated, however, the left turn signal failed to function as intended. In addition, the contact stated that the four-way flashers failed to function as intended. The…

Read all 1,051 complaints

Owner-reported

2005 Toyota Prius mileage at failure

854 of the 1,051 complaints on file for the 2005 Toyota Prius give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Exterior Lighting	Median 100,000 miles	Middle half 70,000–140,000 miles	Based on 297 complaints
Service Brakes	Median 65,000 miles	Middle half 30,000–120,000 miles	Based on 217 complaints
Electrical System	Median 100,000 miles	Middle half 35,000–150,000 miles	Based on 151 complaints
Vehicle Speed Control	Median 50,000 miles	Middle half 20,000–75,000 miles	Based on 85 complaints
Engine	Median 35,000 miles	Middle half 7,000–105,000 miles	Based on 67 complaints
Air Bags	Median 65,000 miles	Middle half 50,000–110,000 miles	Based on 36 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Most complaints NHTSA received since May 17, 2021 give no mileage. So that they aren't undercounted, each one received since then that gives a mileage also stands in for those that gave none, which can put a component's median above most of the mileages it is based on.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Toyota Prius in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP22-005: Pedestrian alert sounds
Closed August 7, 2023
- Recall 22V-063
Defect Petition DP13-001: Intermediate Steering Shaft Separation
Closed April 8, 2020
Preliminary Evaluation PE05-029: ENGINE STALLING
Closed October 12, 2005

Open and recently closed NHTSA defect investigations

Steering Intermediate Extension Shaft may Fail

NHTSA #12V537000 · Steering · NHTSA notice

Reported November 14, 2012 · Toyota Motor Engineering & Manufacturing

Potentially affected: 669,705 vehicles

Owners notified December 20, 2012 · Vehicles built August 5, 2003 – March 30, 2009 (per NHTSA)

Defect description

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Safety consequence

Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Manufacturer remedy

Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Water Pump may Fail Causing a Vehicle Stall

NHTSA #12V536000 · Engine and Engine Cooling · NHTSA notice

Reported November 14, 2012 · Toyota Motor Engineering & Manufacturing

Potentially affected: 350,662 vehicles

Owners notified January 17, 2013 · Vehicles built August 6, 2003 – March 30, 2009 (per NHTSA)

Defect description

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Safety consequence

The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Manufacturer remedy

Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

PEDAL ENTRAPMENT

NHTSA #09V388000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported October 5, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 4,445,056 vehicles

Toyota campaign 90L(TOYOTA)/90LG(LEX · Owners notified December 31, 2009

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Notes

TOYOTA RECALL NO. 90L/90LG.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STEERING SHAFT FAILURE

NHTSA #06V188000 · Steering — Electric Power Assist System · NHTSA notice

Reported May 31, 2006 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 170,856 vehicles

Toyota campaign 60C · Owners notified June 9, 2006 · Vehicles built August 5, 2003 – November 10, 2005 (per NHTSA)

Defect description

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Safety consequence

THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Manufacturer remedy

TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 60C.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIR BAG INFLATOR

NHTSA #06V096000 · Air Bags · NHTSA notice

Reported April 3, 2006 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 133 vehicles

Toyota campaign 60B 6LB · Owners notified April 6, 2006 · Vehicles built September 23, 2003 – December 1, 2005 (per NHTSA)

Defect description

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

Safety consequence

THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Notes

TOYOTA RECALL NO. 60B AND LEXUS RECALL NO. 6LB.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Toyota Prius 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

1,051 owner complaints have been filed with NHTSA for the 2005 Toyota Prius.

Power Train; Unknown or Other; Engine

ODI #11718280

Incident: February 14, 2026 · Filed: February 16, 2026

Eingen faliur acording to dealership Toyota of Anthioc the veicle is on there lot for now but there diagnostic was engine faliure

Service Brakes

ODI #11710245

Incident: January 11, 2026 · Filed: January 11, 2026

ABS actuator failed and had little to no braking action while merging on the freeway. Had to swerve to avoid collision on interstate

Electrical System; Exterior Lighting

ODI #11698556

Incident: September 10, 2025 · Filed: November 10, 2025

The contact owns a 2005 Toyota Prius. The contact stated that while driving at an undisclosed speed, the left turn signal was activated, however, the left turn signal failed to function as intended. In addition, the contact stated that the four-way flashers failed to function as intended. The vehicle was taken to the dealer where it was diagnosed with a computer failure. The contact was informed that an unknown part needed to be replaced, or an unknown software update was needed. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar failure description; however, the VIN was not under recall. The failure mileage was approximately 143,500.

Exterior Lighting

ODI #11698502

Incident: October 15, 2025 · Filed: November 10, 2025

The contact owns a 2005 Toyota Prius. The contact stated that while replacing the instrument cluster, the contact discovered that the turn signals were inoperable. The vehicle was taken to the dealer, who determined that an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 143,500.

Air Bags

ODI #11658429

Crash 1 injury

Incident: April 27, 2025 · Filed: May 2, 2025

Vehicle: 2005 Toyota Prius VIN: [XXX] Date of Incident: April 2024 Location: Citrus Heights, California Incident Summary: In April 2024, I was involved in a front-end collision while driving my 2005 Toyota Prius. I rear-ended another vehicle at moderate to high speed. Despite the severity of the impact, the driver-side airbag failed to deploy. As a result, I was thrown forward and hit my head on the windshield, suffering lacerations and head trauma. After being evaluated by emergency responders and undergoing a hospital visit (MRI included), I was told I had not sustained any life-threatening injuries. However, since the crash, I have experienced severe cognitive symptoms, including confusion, chronic fatigue, sudden drowsiness, memory loss, and extreme mood swings. These symptoms are ongoing and have made daily life extremely difficult. I had brought the vehicle to Roseville Toyota in Roseville, CA, for a full pre-purchase inspection prior to the crash. They provided a CARFAX vehicle history report, but they did not inform me that the airbag had failed to deploy in a previous incident listed in the report. I was unaware the airbag system might be defective, and if I had known, I would not have driven or purchased the vehicle. To this day, there has been no recall issued for airbags on this vehicle, and I believe this is a dangerous and potentially fatal defect that must be investigated by NHTSA. I am asking for an investigation into why the airbag system failed, and whether other Toyota Prius models from these years have similar undisclosed issues. Supporting Info: •The vehicle had dealership service history. •Toyota has documentation showing the vehicle was inspected and that I received the CARFAX, but they failed to alert me to the airbag defect. •I was paid out for the vehicle’s value and partial medical expenses through insurance, but no accountability has been taken for the **failed airbag INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Service Brakes

ODI #11648968

Incident: February 25, 2025 · Filed: March 18, 2025

i had brake warning lights pop up on my dash..my brake actuator fail on my 05 prius.. this is a known issue with toyota prius. the brake actuator is a very important part of the braking system and vehicle is deemed unsafe with a failed actuator/module.. the dealer quoted over 3000 in repairs.. they were covering them for a while and now they are not.. the cost of the repair exceeds the value of vehicle due to the brake actuator being very expensive.. this is something that should have been recalled..

Service Brakes

ODI #11608878

Incident: August 10, 2024 · Filed: August 16, 2024

Brake actuator going bad. Safety is put at risk as brakes are slow to work and sometimes don't work at all for a couple of seconds, making sudden stops impossible. Has not been confirmed by dealer. Has not been inspected. ABS and TPMS light would briefly pop up for a couple of seconds on car startup before shutting off.

Service Brakes; Electrical System

ODI #11596913

Incident: June 26, 2024 · Filed: June 26, 2024

The contact owns a 2005 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brakes seized. In addition, the contact heard a squealing sound and the ABS warning light illuminated. The contact used the parking brake to stop the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The contact stated that the odometer was inoperable and failed to display the correct mileage. The contact stated that the odometer was stuck on 299,999.

Service Brakes

ODI #11593182

Incident: May 30, 2024 · Filed: June 8, 2024

This has been an on going issue with all of toyota hybrids, the abs actuator which control the brakes isn't safe to drive around when not functioning right. Dealership will not replace im suprise that this has no been a recall as its a safety hazard on the road not only for the driver but putting others in danger. My brakes sometimes is floored to the ground with minimal stoppage.

Service Brakes

ODI #11582441

Incident: March 8, 2024 · Filed: April 11, 2024

Prius have a LONG known problem w/ braking systems (over 15 years) defaulting to SOFT brake pedal that (will) kill any driver. Toyota decided to avoid a recall by paying off a few repair jobs, during warranty. They have created a new part to resolve the issue. $4000 to replace a brake pump. Most fail at 150k miles. . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Other Toyota Prius model years

Check your 2005 Toyota Prius VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Prius at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN