2010 Hyundai Santa FE Recalls, Ratings & Complaints

Incident: October 16, 2026 · Filed: October 16, 2026

The vehicle is a 2010 Hyundai Santa Fe with about 157,000 miles. Hyundai issued Service Campaign 947 (TSB 17-01-005) for underbody corrosion on 2007–2010 Santa Fe models, but the campaign was never performed on this vehicle. When the vehicle was taken to an authorized Hyundai dealer, the dealer inspected it and found the frame rusted out in multiple places, with extensive holes. The dealer also told me that some of the main parts listed in the campaign bulletin need to be replaced. A separate independent inspection found a hole in the unibody and noted it would fail a state safety inspection. I am concerned that corrosion this severe in the frame and unibody could compromise the vehicle’s structural integrity and the safety of its occupants and others on the road. I do not know whether other vehicles are similarly affected, but the campaign covers a large population of this model. The problem has been confirmed by an authorized dealer and by an independent shop, and both have photos. The vehicle is at the dealer now and is available for inspection. The dealer is submitting its findings to Hyundai Motor America for review, and I have a case open with Hyundai Customer Care. I received no warning lights or messages before this was found. The rust was found during inspection.

Incident: September 25, 2026 · Filed: September 25, 2026

The Radiator fan remains on when the vehicle is turned off and requires the fan to be unplugged to disengage. If it is not unplugged it will continue to run until the battery is dead. If not caught at the time exiting the vehicle then I am left stranded until I can get the vehicle jumped but even with a dead battery if you plug up the fan again will continue running nonstop. The vehicle does not run hot. There are no known issues that present before this happens and no error codes when hooked up to diagnostics.

Incident: March 13, 2026 · Filed: August 15, 2026

The vehicle’s transmission slips while driving on the highway at approximately 65–75 mph. The slipping occurs at highway speeds and appears to affect the vehicle’s ability to maintain consistent power and acceleration. Problem The vehicle’s transmission slips while driving on the highway at approximately 65–75 mph. The slipping occurs at highway speeds and appears to affect the vehicle’s ability to maintain consistent power and acceleration. Safety Concerns This creates a safety concern because unexpected transmission slipping at highway speeds could result in a sudden loss or interruption of power. This may make it difficult to maintain speed, merge, pass, or respond safely to changing traffic conditions. The issue could increase the risk of an accident, particularly in heavy or fast-moving traffic.

Incident: June 28, 2026 · Filed: August 1, 2026

On XXX I was waiting at a light and the check engine light was blinking. When I started up, the car was very sluggish. It continued to be sluggish on my trip home - 5 miles. I brought it to Meineke [XXX] [XXX]. They ascertained that the engine was shot. They flushed out the oil in the engine and there was lots of metal in the oil. They instructed me to go to Hyundai immediately. There was a engine recall and their research showed that I was included under the recall warrenty. I've included their assessment. Both the drives to the Meineke from my house and to Hyundai from Meineke were scary. I didn't feel safe in the car. I went directly to [XXX], manager of Larry Miller Hyundai at [XXX], Phone [XXX]. He said that he needed to clear the recall with Hyundai. He called me back in a few days and told me that all the test diagnostics were made and that a censor malfunction was the cause of the problem and the front breaks needed work. I gave him the go-head. The cost was $1,319. I wasn't convince that was the primary problem. I use my car for short trips. I was driving to the gym on XXX - having driven less than 50 mile since the recent repair - once again I stopped at a light and the check engine light lit up permanently - not flashing. The engine started to shake when it was idle and there was an unusual sound coming from it. I finished my drive to the gym although the drive just didn't feel normal or safe. Right now (XXX) I am having my car towed to Hyundai. It is not safe to drive. My belief is that corporate Hyundai refused to fix the engine repair part of a class action lawsuit which includes replacing the engine. They had to see that my recall warrenty ends in September and they figured they'd stall until the warrenty was no longer valid. This is just a guess, but a very educated guess. They had to know that the engine was no longer safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: February 14, 2026 · Filed: April 1, 2026

Engine fire

Incident: March 11, 2026 · Filed: March 25, 2026

The contact owns a 2010 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle failed to immediately start, but started after several attempts. The vehicle was taken to an independent mechanic, who replaced the starter, oil filter, and engine filter, and changed the oil. On a hot day, there was a loud sound coming from the vehicle, and it was noticed that the unoccupied vehicle was attempting to start independently. The contact unlocked the vehicle and opened the vehicle door, put the keys in the ignition, and continued to crank for approximately four minutes. The accelerator pedal was pumped, and the vehicle stopped. There was smoke coming from the vehicle, and the vehicle eventually stopped. There were flames coming from the vehicle. The contact called 911, an independent mechanic, her father, and the fire department. The Fire Department was able to extinguish the fire and disconnect the battery. The mechanic determined that the engine cover was burned. There were no reported injuries. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact indicated that the failure was related to NHTSA Campaign Number: 11E040000 (Equipment). The insurance company referred the contact to the NHTSA Hotline for assistance. The manufacturer was not contacted. The failure mileage was approximately 145,000.

Incident: December 26, 2025 · Filed: February 2, 2026

I hadn't used the car in a few weeks (rarely leave the house because I work from home). I went to visit a friend on December 26th or 27th (don't remember exact date). On the way there the engine started having a knocking noise. On the way home after eating a meal with the friend, the knocking got louder, and the car was losing power. As I drove up a hill, the engine was providing almost no power, and then I heard a very loud bang, and a blue-ish, white smoke cloud came out from under the car, and it died completely. As a secondary issue, since this was right after Christmas, I couldn't find an open shop to have it towed to, so it was left on the side of the road overnight. The next day when I drove back to meet a tow-truck driver at the car, we found it had been broken into overnight, and my wife's childhood Christmas decorations were stolen. Nothing else of value was taken. I did have police come out and make a report at the time. I only just discovered that the engine was under a recall for "Campaign 966" for this exact issue.

Incident: January 22, 2026 · Filed: January 23, 2026

Odometer Fraud. The contact purchased a 2010 Hyundai Santa Fe. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 142,000. It was later discovered, during a VIN check, that the mileage was 223,000. The mileage was last recorded in June 2025. The local Police Department was notified of the fraud. However, due to insufficient information about the seller, no report was filed.

Incident: May 22, 2025 · Filed: May 23, 2025

Driving approximately 70-75mph on highway with cruise control set. Car starts to make rattling sound & engine warning light goes on, car struggles to accelerate and hovers around 60mph. Upon inspection of engine oil in car, fresh oil has been burned up quickly! Added 1 quart. Drove 45mins at 70-75mph. Notice Engine light on again. Check engine oil. Had quickly burned through 1qt! Add new quart of oil. Let car rest overnight. Driving 70mph without use of cruise control. Then use cruise control. After a bit car engine sounds of rattling & struggling to accelerate. RPM gauge seen going up & down. Through rear view mirror I see lots of bluish smoke. Pull over to let engine rest. Check oil = still 3/4. Use engine dectection device. Indicates that cylinders 3 &4 misfiring. Reset car warning indicator with my detection device. Finish drive going 60mph to arrive at destination without car engine warning going back on.

Incident: February 10, 2025 · Filed: February 16, 2025

Brakes locked