2009 Hyundai Santa FE Recalls, Ratings & Complaints

Incident: October 2, 2026 · Filed: October 21, 2026

I am reporting a serious vehicle safety concern involving a 2009 Hyundai Santa Fe with approximately 56,000 miles. On [XXX], the vehicle was inspected at West Herr Hyundai in Williamsville, New York, in connection with Hyundai’s underbody corrosion Service Campaign 947. During the inspection, the dealership discovered severe and extensive corrosion affecting the vehicle’s underbody, structural components, and frame-related areas. The corrosion was so significant that the dealership determined the vehicle was unsafe to drive. This is not a cosmetic rust issue. The deterioration involves critical structural areas of the vehicle and raises serious concerns about structural integrity, suspension mounting points, and the potential for component failure or loss of vehicle control. The vehicle’s condition presents a significant safety hazard to its occupants and other motorists. What makes this particularly concerning is that the vehicle has only approximately 56,000 miles and was otherwise in good condition. Despite its relatively low mileage, the structural corrosion has rendered the vehicle unsafe for continued operation. The vehicle remains at West Herr Hyundai and is available for further inspection. On [XXX], the dealership documented the corrosion, took photographs, and submitted the findings to Hyundai Corporate for review. We are currently awaiting Hyundai’s determination regarding the appropriate remedy. I am requesting that NHTSA investigate this serious structural corrosion issue, including the effectiveness of Hyundai’s Campaign 947 in addressing the underlying safety concern. I am also seeking an appropriate remedy from Hyundai, as the vehicle has been deemed unsafe to drive due to extensive structural deterioration. This condition presents an unacceptable safety risk, particularly in a vehicle with such low mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 23, 2026 · Filed: August 23, 2026

Brake Lights Stay, On ESC OFF Light Illuminated, Cruise Control Won't Engage, Unable to Shift Out of Park. Fuse had to be pulled because the battery was going dead due to lights not turning off. Its doing the same thing that is outlined in this recall (NHTSA Campaign ID: 13V113000)

Incident: May 4, 2026 · Filed: May 29, 2026

2 unrepaired recalls. Frame rusted and unsafe to lift to repair the other recall which is an oil leak onto the alternator. Car won't run now. Corporate asked if I had a lawyer. They have declared my car not fixable or drivable. Neither corporate nor dealer will return my calls. No info from them at all. No offer of a buyback. No anything.

Incident: May 7, 2026 · Filed: May 20, 2026

*The mechanic diagnosed internal engine failure (May 14, 2026). The vehicle is at the second mechanic's shop. *The car stalled twice. The first time, over 20 miles, the air conditioning stopped, followed by the radio, and then acceleration. I pulled over and the acceleration returned but only for a minute. The second time, a clacking noise got louder and faster, and three miles later the engine stopped. I coasted and pulled over but had to shift to neutral and use the parking brake to stop. *The first time was a two-lane road (55 MPH). As I lost acceleration, cars slowed behind me. It took so long to turn off on a side road, the car behind me almost hit me as they speeded up to pass. The second time was a busy two-lane road (45 MPH), but the engine stopped so quickly, the person behind me almost rear ended me. Without the steering, the car crossed the middle lane, and I had to haul the steering wheel so I could pull off to a side street. *The first repair shop said the oil was low and suggested the place that changed the oil did not know what it was doing and perhaps didn't put the cap on right. The oil was dripping over the engine and to the bottom of the housing. After driving it, the mechanic said the Hyundai service center should do a diagnostic, but it was safe to drive. The second repair shop did an oil change to see what was happening with the oil flow. He found metal filings as well as other problems and said it this was an internal engine failure. *The Hyundai service center said the vehicle needed to be towed, at my own expense, to the its center for a $185.00 out-of-pocket diagnostic. *In October 2025, the Hyundai dealership serviced the car for a cylinder head oil leak recall/problem. *There were no warning lights either time--no engine or oil lights came on. There were no symptoms or indications of a problem before the first incident (May 7, 2026).

Incident: December 30, 2025 · Filed: January 16, 2026

Vehicle will suddenly shutdown in the middle of the road. This could easily have caused a crash at any time. Several batteries have been replaced due to alternator not charging the battery. Then the battery has to be jumped for emergencies. I have taken the car in for repairs of the recall twice. I was told that the front end would come off and parts would have to be replaced because of the age of my vehicle they would not fit again. I need a solution to this problem.

Incident: July 29, 2025 · Filed: July 29, 2025

[XXX] We took out Stanta Fe to the Hyundia Dealership in Columbia, TN 38401. The installed a new rover cover gasket left and service kit. The purpose was to stop oil from leaking into the alternator. I would like to point out we did not see any visible signs of the gasket was leaking. We had our regular scheduled oil change in Feb of 2025 and no report of an oil leak. We had a service event at the end of June 2025 and were told there was a visible leak was present and appeared to be about 3 months old. We took it back to the dealership and reported the recall issue was occurring. This was 7/25 and just outside of a year. The stated it would not be covered under warranty/recall now. I called and complain to Hyundia corporate. Waited 2 weeks to say it would be taken care of by the dealership. Called them today to arrange for bring the car in but they had no record of what I was told by Hyundia corporate. I believe this breaking faith w the whole recall process with the NTSB. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 22, 2020 · Filed: July 22, 2025

The contact owns a 2009 Hyundai Santa Fe. The contact stated while driving at various speeds, the vehicle stalled. The contact stated that the failure occurred mostly while decelerating from highway speeds. The vehicle was taken to several independent mechanics to be diagnosed, but the failure could not be duplicated. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 85,000.

Incident: May 30, 2025 · Filed: May 31, 2025

I am writing to document a troubling interaction at one of the Hyundai service locations regarding a known recall on my 2009 Hyundai Santa Fe (166,000 miles). This vehicle is affected by Recall Campaign Number 103 (valve cover gasket may leak and cause alternator failure and electrical fire risk). The issue is publicly documented by NHTSA and Hyundai, and my vehicle has experienced exactly the problems outlined — two alternator failures and two batteries killed. When my vehicle was brought to Hyundai of Metairie, located at 5969 Veterans Memorial Boulevard, Metairie, Louisiana, the service receptionist stated before even inspecting the car that it “may not be covered” because the alternator is aftermarket. This was said immediately upon drop-off, which I believe is inappropriate and concerning. We dropped it off Friday evening before the Saturday, May 31, 2025 morning scheduled inspection. As you are aware, federal law requires manufacturers to complete recall repairs at no cost, regardless of vehicle ownership history or whether a part has been replaced with an aftermarket component — especially when the replacement occurred due to a known safety defect. The alternator was not modified; it was replaced after multiple failures that align precisely with the recall’s described risk. I respectfully request that: The vehicle be inspected promptly and fairly. The recall be honored and completed at no charge, as required. Hyundai ensure that dealership employees are not preemptively discouraging customers from rightful recall services with misinformation or dismissive attitudes. I have already filed a complaint with Hyundai Corporate office this morning and intend to follow up with a phone call when offices resume usual business hours. Thank you in advance for your time. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: April 3, 2025 · Filed: May 18, 2025

Leak coolant and oil

Incident: January 6, 2025 · Filed: January 21, 2025

On January 16,2025 I was driving my Hyundai Santa Fe on the freeway with my three children when the automatic brake system suddenly failed, causing me to lose control of the vehicle. As a result, we spun off the road, and the vehicle flipped four times, causing us multiple injuries. Additionally, due to a known recall involving the failure of the airbag deployment system, the airbags did not deploy during the crash. These combined defects caused me and my children to suffer significant injuries, including broken cervical spine. Broken thoracic spine and Broken Sternum. My daughter has a fractured spine and sternum. And both my sons have serious bruising and head trauma. Both the automatic brake system and the airbag system on this vehicle are part of existing recalls issued by Hyundai Motors. These failures directly contributed to the severity of our accident and the injuries we sustained