2019 Hyundai Santa FE Recalls, Ratings & Complaints

Incident: June 20, 2026 · Filed: October 17, 2026

After Hyundai 9C2 update the transmission bucks or searches for gear causing what seems to be up and down shifting.

Incident: October 4, 2026 · Filed: October 5, 2026

Driving at highway speed, vehicle stuttered/lurched. The check AWD, engine light, tire pressure warning lights came on. Check by mechanic resulted in error code P0741 (Torque Converter Clutch Circuit Performance or Stuck Off). Search of error code P0741 indicates that there is a Technical Service Bulletin TSB-23-AT-005H regarding this KNOWN problem. A stutter or lurch of the vehicle can cause the driver to over react, stop or swerve suddenly in traffic potentially causing an accident not to mention possible being struck on the side of the road while waiting for a tow/service truck. Vehicle/components have not been checked by manufacturer--only diagnostic code by Mechanic. Warning lights after incident included the AWD system, Check Engine Light, and Tire Pressure sensor light. Vehicle is being towed to a Hyundai Dealership as Mechanic advised it is not safe to drive.

Incident: August 14, 2026 · Filed: October 2, 2026

On August 14 2026, I drove my 2019 Hyundai Santa Fe approximately one mile from my residence to work at approximately 5:00 AM. The vehicle was operating normally and I experienced no warning lights, unusual noises, odors, smoke, or other indications of a problem. I parked the vehicle in an outdoor parking lot and the vehicle remained parked and turned off for approximately four hours. At approximately 9am, I was notified that my vehicle was smoking. A person who was walking past the vehicle observed the smoke, obtained a fire extinguisher, and extinguished the fire. The fire department subsequently responded, disconnected the vehicle battery, and opened the rear of the vehicle to ventilate it. The fire and resulting heat damage were concentrated on the driver's side rear of the vehicle, directly behind the driver's-side rear tire and in the area of the rear bumper. The plastic at the base of the bumper melted, and melted bumper material was observed dripping onto the ground. The responding fire marshal inspected the vehicle and indicated that the electrical box located in this area may be associated with the origin of the fire. Wiring from this area runs to a non-original/non-Hyundai-installed trailer/tow attachment. The exact cause and origin of the fire have not yet been conclusively determined. The vehicle had otherwise operated normally during my ownership, with little to no significant problems prior to this incident. The vehicle is currently being preserved for inspection by my insurance company and mechanic. I am reporting this incident to NHTSA because the vehicle caught fire while parked and unattended after having been driven only approximately one mile, and because the suspected area of origin includes electrical components and wiring associated with the rear of the vehicle. No collision preceded the fire. There were no injuries. I am requesting that NHTSA consider this incident as a potential vehicle/electrical safety issue and investig

Incident: March 26, 2026 · Filed: September 23, 2026

On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold. After driving for some time and the vehicle warms up, the symptoms improve, although the change in drivability remains noticeable compared with operation before the update. There have been no warning lights or warning messages associated with the problem. The issue began immediately following the ECM software update. The vehicle has not yet been returned to the dealer for diagnosis or confirmation and is available for inspection. I am concerned about the safety implications of delayed or unpredictable acceleration response, particularly when entering traffic, crossing an intersection, or merging when timely acceleration may be necessary. I am reporting this because the condition began only after Hyundai Service Campaign 9C2 was performed and I believe NHTSA should evaluate whether this ECM software update is causing similar drivability and acceleration problems in affected vehicles.

Incident: April 9, 2026 · Filed: September 21, 2026

The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously replaced the high-pressure fuel pump under warranty to address this issue, but the dangerous stalling has persisted over the last 2,000 miles. The vehicle continues to randomly shut off without throwing a permanent check engine light or diagnostic trouble code, and the manufacturer has failed to correct this critical safety defect.

Incident: April 15, 2025 · Filed: September 17, 2026

The car started having problems immediately after replacement with a new battery. The issue with the ISG (Idle Stop and GO System) started appearing. When the Auto Stop Indicator turns green, the car stalls which puts my life at risk. I have spoken to a number of mechanics and I am not getting a satisfactory answer on how to fix this problem.. One mechanic told me it was the starter which turned out not to be true. I have also spoken with a number of other mechanics and they are clueless on how this problem can be remedied. And the Hyundai dealter wanted 275 just to look at it but with no guarentee. The whole issue is putting my life and other motorists at risk.

Incident: September 8, 2026 · Filed: September 11, 2026

2019 Santa Fe with 80,000 miles showed signs of excessive oil consumption. Service was scheduled with licensed Hyundai franchise service center. Known oil consumption issues on Theta II engines for that year. Testing requires 3 steps. First step is to change the oil and document levels. Engine is tested for 1000 miles then returned to service center. After 1000 miles, service center reports 2.5 qts of oil per 1000 miles. Hyundai corporate was contacted where they approved warranty work for the vehicle. Step two requires Combustion Chamber Cleaning. During this portion of the work, service center calls about fire that took place immediately after a test drive. Dealership states engine and components destroyed.

Incident: August 28, 2026 · Filed: September 7, 2026

My vehicle had a very strong gas smell inside and outside of the car. I found a gas puddle under the car coming from the back of the vehicle. Car was hesitating when I stepped on the gas. I was afraid it may stall. I drove the vehicle to my regular service station. Vehicle has an active fuel leak and this is a fire hazard. I was very concerned whether the vehicle would stall and cause an accident. Warranty coverage was denied.

Incident: August 20, 2026 · Filed: September 2, 2026

Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ​Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ​Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ​Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ​Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ​Evidence Preservation: On August 31, 2026, the vehicle was towed to an independent facility to mitigate road hazards, conduct teardown diagnostics, and preserve the engine oil/filter for ISO-accredited spectrographic laboratory analysis. ​The manufacturer released an unsafe vehicle into traffic on August 20, 2026, and subsequently refused to investigate or remedy a documented internal engine failure that creates sudden, recurring loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 27, 2026 · Filed: August 28, 2026

My vehicle recently received the Hyundai 9c2 emissions upgrade they required and since then the vehicle has had predictable acceleration issues for the first several minutes after the vehicle. While trying to slowly accelerate the vehicle with unpredictably lurch forward. Many people have been reporting this.