NHTSA vehicle safety data

2006 Freightliner Business Class M2 Recalls & Complaints

The 2006 Freightliner Business Class M2 has 13 NHTSA recall campaigns and 8 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.

NHTSA recall and complaint data for the 2006 Freightliner Business Class M2. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Freightliner Business Class M2 owner complaints

Owners have filed 8 complaints with NHTSA about the 2006 Freightliner Business Class M2, describing incidents dated March 4, 2006 to May 1, 2021.

Most-cited components

Service Brakes 3 complaints
Engine 1 complaint
Equipment 1 complaint
Fuel/Propulsion System 1 complaint
Power Train 1 complaint
Seats 1 complaint

Of the 8 complaints on file, 1 reports a fire; across all 8 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11432993 · Filed September 14, 2021
Not sure if it is a malfunction or not. Can not verify. Seller mentioned: “Allison Automatic Transmission will not shift from Neutral to Drive or Reverse unless you hit the brake”. It does shift w/o braking. This seems like it would be a safety issue but Freightliner Techs can not verify. Vehicle is…
ODI #11035792 · Filed October 23, 2017
I HAVE HAD 4 BRAKE FAILURES DUE TO STUCK CALIPERS AND SEVERE OVERHEATING AND LOSS OF BRAKES DUE TO BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. ALL 4 WHEELS HAVE BEEN AFFECTED AT DIFFERENT TIMES. TWO WERE WHILE DRIVING ON THE INTERSTATE AND TWO WHILE DRIVING ON SECONDARY ROADS. TWO OF THE FAILURES…
ODI #10461961 · Filed June 16, 2012
REAR BRAKES STARTED DRAGGING WHILE DRIVING ALONG. I STOPPED TO CHECK THEM AND THE RIGHT REAR BRAKE WAS VERY HOT AND SMELLING OF OVERHEATED BRAKES. I TURNED AROUND TO TRY AND MAKE IT HOME BUT THE NEXT TIME I APPLIED THE BRAKES, THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD TO USE THE EMERGENCY BRAKE TO…

Read all 8 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Freightliner Business Class M2 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE10-007: Stop Lamps Intermittent
Closed May 23, 2010
Recall Query RQ07-003: FRONT WHEEL SEPARATION
Closed March 26, 2008
- Recall 08V-137

Open and recently closed NHTSA defect investigations

Reflective Tape May be Partially Covered/FMVSS 108

NHTSA #20V214000 · Exterior Lighting · NHTSA notice

Reported April 14, 2020 · Daimler Trucks North America LLC

Potentially affected: 63,175 vehicles

Repair completion: 55.7% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL848 · Owners notified May 29, 2020

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Safety consequence

The vehicle's rearward visibility may be reduced, increasing the risk of a crash.

Manufacturer remedy

DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HIGH PRESSURE FUEL LINE

NHTSA #12V074000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported February 28, 2012 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 103,437 vehicles

Manufacturer campaign 12C-2 · Owners notified April 27, 2012

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

Safety consequence

A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS 12C-2.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DIESEL FUEL LEAK/DETROIT DIESEL

NHTSA #11V478000 · Fuel System, Diesel · NHTSA notice

Reported September 16, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 73,500 vehicles

Manufacturer campaign 11C-2 · Owners notified February 21, 2012 · Vehicles built starting July 11, 2003 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.

Safety consequence

THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

DAIMLER TRUCKS' CAMPAIGN NUMBER IS 11C-2.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

HYDRAULIC BRAKE SWITCHES

NHTSA #10V178000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported April 30, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 8,971 vehicles

Manufacturer campaign FL-577 · Owners notified May 27, 2011 · Vehicles built January 19, 2005 – April 16, 2010 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 FREIGHTLINER BUSINESS CLASS C2, FCCC B2 CHASSIS, S2 CHASSIS, AND MC CHASSIS MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

Safety consequence

THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-577.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRACTURED FUEL LINES OR TRANSFER TUBES/FIRE

NHTSA #08V668000 · Fuel System, Other — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported December 17, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 24,650 vehicles

Manufacturer campaign FL-542 · Owners notified March 9, 2009 · Vehicles built March 9, 2004 – August 18, 2006 (per NHTSA)

Defect description

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.

Safety consequence

A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.

Notes

DTNA'S RECALL NO. FL-452.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

POWER DISTRIBUTION MODULE/TAIL LAMP

NHTSA #08V154000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported April 3, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 724 vehicles

Manufacturer campaign FL-529 · Owners notified September 10, 2008 · Vehicles built June 15, 2005 – January 2, 2007 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 724 MY 2006-2007 BUSINESS CLASS M2 TRUCKS. THE OPTIONAL HIGH CURRENT TAIL LAMP POWER DISTRIBUTION MODULE (PDM) WAS INSTALLED IN A LOCATION HIGHLY SUSCEPTIBLE TO WATER INTRUSION. THIS MAY LEAD TO A LOSS OF REAR LIGHTING.

Safety consequence

A LOSS OF SOME OR ALL REAR LIGHTING ON THE VEHICLE UNDER CERTAIN CONDITIONS MAY IMPAIR VISIBILITY OF THE TRUCK INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL RELOCATE THE PDM TO INSIDE THE CAB BEHIND THE DRIVER'S SEAT FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 10, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

DAIMLER TRUCKS RECALL NO. FL-529. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

8K THIN SPINDLE-NUT/ARVINMERITOR/AXLE ALLIANCE

NHTSA #08V137000 · Power Train — Axle Assembly · NHTSA notice

Reported March 25, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 28,764 vehicles

Manufacturer campaign FL-527 · Owners notified January 8, 2009 · Vehicles built January 26, 2000 – March 24, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.

Safety consequence

CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

DAIMLER TRUCKS RECALL NO. FL-527.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

HIGH PRESSURE FUEL LINES

NHTSA #08V113000 · Fuel System, Diesel · NHTSA notice

Reported March 11, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 62,000 vehicles

Manufacturer campaign FL-526 · Owners notified July 9, 2008 · Vehicles built April 1, 2004 – April 30, 2007 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 62,000 MY 2005-2007 FREIGHTLINER BUSINESS CLASS, CENTURY CLASS, COLUMBIA, CORONADO, FLD, CLASSIC, STERLING A-LINE, L-LINE, AND WESTERN STAR 4900 TRUCKS. A FRACTURED FUEL LINE COULD LEAK DIESEL FUEL.

Safety consequence

IF A LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS, FUEL MAY IGNITE AT A HOT ENGINE SURFACE AND/OR FUEL MAY BE SPILLED ON THE ROAD SURFACE.

Manufacturer remedy

HIGH PRESSURE FUEL LINES AND TRANSFER TUBES WILL BE INSPECTED AND REPLACED FREE OF CHARGED. THE RECALL BEGAN ON JULY 9, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

DAIMLER TRUCK RECALL NO. FL-526.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FIFTH WHEEL LEVER PIVOT BOLTS/HOLLAND SIMPLEX

NHTSA #07V530000 · Trailer Hitches — Fifth Wheel Assembly · NHTSA notice

Reported November 13, 2007 · FREIGHTLINER LLC

Potentially affected: 38,000 vehicles

Freightliner campaign FL-514 · Owners notified January 3, 2008 · Vehicles built January 1, 2006 – May 31, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND AND PREVENT THE FIFTH WHEEL JAW FROM LATCHING SECURELY AROUND THE TRAILER KING PIN.

Safety consequence

THERE IS A POSSIBILITY THAT THE FIFTH WHEEL MAY FAIL TO LATCH WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THE OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER. THE RECALL BEGAN ON JANUARY 3, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-514.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SR-7 SPRING BRAKE VALVE ASSEMBLY/BENDIX/PARKER

NHTSA #07V302000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice

Reported July 16, 2007 · FREIGHTLINER LLC

Potentially affected: 75,000 vehicles

Freightliner campaign FL-504 · Owners notified January 11, 2008 · Vehicles built July 1, 2002 – July 3, 2007 (per NHTSA)

Defect description

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.

Safety consequence

THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Manufacturer remedy

FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPINDLE NUT ADJUSTMENT/ARVINMERITOR

NHTSA #07V169000 · Suspension — Front — Hub · NHTSA notice

Reported April 12, 2007 · FREIGHTLINER LLC

Potentially affected: 219 vehicles

Freightliner campaign FL-494 · Owners notified June 28, 2007 · Vehicles built June 1, 2005 – December 31, 2006 (per NHTSA)

Defect description

ON CERTAIN TRUCKS BUILT WITH FRONT AXLES ASSEMBLED BY ARVINMERITOR, THE FRONT SPINDLE NUT MAY BE OVER-TIGHTENED CAUSING PRELOAD ON THE FRONT WHEEL BEARINGS WHICH COULD LEAD TO PREMATURE BEARING WEAR.

Safety consequence

IF RAPID BEARING WEAR IS ALLOWED TO PROGRESS, THE FRONT WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE FRONT HUB INSTALLATION FOR CORRECT BEARING ADJUSTMENT. IF THE BEARING ADJUSTMENT IS INCORRECT, THE FRONT WHEEL BEARINGS WILL BE REPLACED. THE RECALL BEGAN ON JUNE 28, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-385-4357.

Notes

FREIGHTLINER RECALL NO. FL-494.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT AXLE I-BEAM

NHTSA #05V551000 · Power Train — Axle Assembly · NHTSA notice

Reported December 6, 2005 · FREIGHTLINER LLC

Potentially affected: 500 vehicles

Freightliner campaign FL-467 · Owners notified March 15, 2006 · Vehicles built September 6, 2005 – October 20, 2005 (per NHTSA)

Defect description

ON CERTAIN TRUCKS AND MOTOR HOME CHASSIS, THE TOP FLANGE OF THE FRONT AXLE I-BEAM MAY FATIGUE AND FRACTURE.

Safety consequence

DRIVER MAY EXPERIENCE LOSS CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE FRONT AXLE ASSEMBLY. THE RECALL BEGAN ON MARCH 15, 2006, FOR PHASE I. PHASE 2 WILL BEGIN DURING AUGUST 2006. THIS RECALL IS BEING CONDUCTED IN TWO PHASES. PHASE I WILL REPLACE THE COMPLETE AXLE ASSEMBLY; AND PHASE II WILL REPLACE THE AXLE BEAM AND STEERING KNUCKLES. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-467.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

LOWER STEERING SHAFT

NHTSA #05V541000 · Steering · NHTSA notice

Reported November 22, 2005 · FREIGHTLINER LLC

Potentially affected: 198 vehicles

Freightliner campaign FL-464 · Owners notified February 17, 2006 · Vehicles built August 1, 2004 – October 31, 2005 (per NHTSA)

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH FONTAINE MODIFICATION RIGHT HAND STEERING CONTROL AND EQUIPPED WITH SIT DOWN DUAL DRIVE CONVERSIONS, THE PINCH BOLT THAT SECURES THE LOWER STEERING SHAFT CONNECTION TO THE LH MITER BOX MAY HAVE BEEN IMPROPERLY TORQUED CAUSING THE BOLTS TO FALL OUT.

Safety consequence

THIS MAY CAUSE A LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE LOWER STEERING SHAFT PINCH BOLT AT THE CONNECTION AND BOLTS ON THE STEERING CROSS SHAFT WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-464.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Freightliner Business Class M2. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

8 owner complaints have been filed with NHTSA for the 2006 Freightliner Business Class M2.

Power Train; Service Brakes

ODI #11432993

Incident: May 1, 2021 · Filed: September 14, 2021

Not sure if it is a malfunction or not. Can not verify. Seller mentioned: “Allison Automatic Transmission will not shift from Neutral to Drive or Reverse unless you hit the brake”. It does shift w/o braking. This seems like it would be a safety issue but Freightliner Techs can not verify. Vehicle is new to me and has not been inspected yet although I did consult Freigthliner tech via phone. No warning lights related. Operates fine otherwise.

Service Brakes

ODI #11035792

Incident: September 8, 2017 · Filed: October 23, 2017

I HAVE HAD 4 BRAKE FAILURES DUE TO STUCK CALIPERS AND SEVERE OVERHEATING AND LOSS OF BRAKES DUE TO BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. ALL 4 WHEELS HAVE BEEN AFFECTED AT DIFFERENT TIMES. TWO WERE WHILE DRIVING ON THE INTERSTATE AND TWO WHILE DRIVING ON SECONDARY ROADS. TWO OF THE FAILURES REQUIRED TOWING TO THE REPAIR FACILITY. THE BRAKES ARE BOSCH DISC BRAKES WITH 66MM DUAL PISTONS, THE TIMELINE ON THE STUCK CALIPERS IS AS FOLLOWS; JUNE 20, 2012, 50,908 MILES, RIGHT REAR CALIPER STUCK AND LOST BRAKES, TOWED TO FREIGHTLINER SERVICE CENTER, MAY 20, 2016, 74,326 MILES, LEFT REAR CALIPER STUCK, LOST BRAKES, JULY 14, 2017, 80837 MILES LEFT FRONT CALIPER STUCK LOST BRAKES AND WAS TOWED, SEPT. 8, 2017, 84,000 MILES, RIGHT FRONT CALIPER STUCK AND GOT VERY HOT, I STOPPED AND LET THE BRAKE COOL AND MADE IT HOME AND THEN REPLACED CALIPER. THE BRAKES HAVE GOTTEN SO HOT THAT THE CALIPER, ROTOR AND PADS AND ABS SENSORS ALSO NEEDED TO BE REPLACED EVERY TIME. AS FAR AS I AM AWARE, BOSCH HAS NOT ISSUED ANY RECALL OR SAFETY NOTICE ON WHY THIS HAPPENS OR HOW TO PREVENT IT FROM HAPPENING. A SCAN ON THE INTERNET REVEALS THAT THIS HAPPENS A LOT WITH THIS BRAKING SYSTEM. DUE TO THE EXTREME DANGER THAT THIS CONDITION CAUSES, BOSCH SHOULD BE REQUIRED TO ADDRESS THE ISSUE.

Service Brakes

ODI #10461961

Incident: June 9, 2012 · Filed: June 16, 2012

REAR BRAKES STARTED DRAGGING WHILE DRIVING ALONG. I STOPPED TO CHECK THEM AND THE RIGHT REAR BRAKE WAS VERY HOT AND SMELLING OF OVERHEATED BRAKES. I TURNED AROUND TO TRY AND MAKE IT HOME BUT THE NEXT TIME I APPLIED THE BRAKES, THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD TO USE THE EMERGENCY BRAKE TO GET STOPPED. I WAS TOWED TO A FREIGHTLINER SERVICE CENTER WHERE THEY TOLD ME I HAD A STUCK CALIPER. THIS VEHICLE IS A MOTORHOME CONVERSION BY DYNAMAX AND HAS HYDRAULIC, ABS BRAKES. *JB

Suspension

ODI #10350251

Fire

Incident: April 1, 2009 · Filed: August 18, 2010

TL* THE CONTACT OWNS A 2006 FREIGHTLINER BUSINESS CLASS M2. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED THERE WAS SMOKE COMING FROM THE FRONT PASSENGER SIDE WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE BOTH FRONT WHEEL BEARINGS WERE REPLACED UNDER WARRANTY. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN BACK TO THE AUTHORIZED DEALER ON BOTH OCCASIONS WHERE THE FRONT WHEEL BEARINGS AND SPINDLES WERE REPLACED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 37,446.

Visibility

ODI #10207609

Incident: October 30, 2007 · Filed: November 1, 2007

PASSENGER SIDE WINDOW CONTINUES TO COME OFF TRACK WHEN DOOR IS SHUT. VEHICLE HAS BEEN TAKEN TO FREIGHTLINER REPAIR FACILITY NUMEROUS TIMES AND THIS PROBLEM CONTINUES TO EXIST. FACTORY REPS STATE THAT THIS IS A DEFECT BUT IT IS NOT A RECALL. WHEN THE DOOR IS SHUT, THE METAL FLEXES AND CAUSES THE WINDOW TO FALL OFF ITS TRACK. *TR

Steering; Fuel System, Gasoline; Structure; Equipment

ODI #10165708

Incident: June 21, 2006 · Filed: August 24, 2006

FIRST BAPTIST CHURCH OF TRUSSVILLE PURCHASED A NEW BUS FROM ILLINOIS BUS SALES (IBS), 1216 RAND ROAD, DES PLAINES, IL 60016, THE BUS HAS SEATING CAPACITY FOR 36 INDIVIDUALS. THE CHURCH PAID CASH FOR THE BUS. IT WAS PURCHASED NEW FROM IBS ON MAY 23, 2006. THE VEHICLE IDENTIFICATION NUMBER IS 1FVACWCS17XXXXXXX - 2006 FREIGHTLINER F160/M2 - AMERITRANS BODY - AT TIME OF PURCHASE IT HAD 197 MILES. ON THE FIRST OCCASION TO USE THE BUS WITH PASSENGERS, IT VEERED OFF THE ROAD AND WOULD NOT STAY ON THE ROAD. IT HAS A STEERING DEFECT AS WELL. IN ADDITION, IT HAD A FUEL LINE LEAK. IT HAS BEEN IN THE SHOP AT FREIGHTLINER IN BIRMNGHAM, SINCE LATE JUNE 2006, WHERE IT REMAINS. ACCORDING TO THE SERVICE MANAGER (RAYMOND) AT FREIGHTLINER IN BIRMINGHAM, IT IS A DESIGN PROBLEM, AND THE BUS IS IRREPARABLE AND SHOULD BE TAKEN OFF THE ROAD. WE BELIEVE DOT SHOULD REVISIT ITS CERTIFICATION OF THIS PARTICULAR CONVERSION BUS, AS IT IS IRREPARABLE AND POSES A REAL AND PRESENT DANGER TO THE PUBLIC. PLEASE FEEL FREE TO CALL UPON MY OFFICES FOR ANY ASSISTANCE YOU MAY NEED. ALSO, THE ADMINISTRATOR OF FIRST BAPTIST CHURCH OF TRUSSVILLE, ALABAMA - MAY PROVIDE MORE DETAILED INFORMATION - HIS CONTACT INFORMATION IS - FIRST BAPTIST CHURCH OF TRUSSVILLE, ALABAMA - 128 NORTH CHALKVILLE ROAD, TRUSSVILLE, ALABAMA 35173 - 205.655.XXXX. *NM *NM

Engine and Engine Cooling

ODI #10165180

Incident: August 10, 2006 · Filed: August 10, 2006

DT*: THE CONTACT STATED WHILE TRAVELING 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE COASTED TO THE SIDE OF THE ROAD AND THE DEALER WAS CONTACTED WHO SUGGESTED THE FUEL FILTER BE REPLACED. THE VEHICLE STARTED AND WAS DRIVEN TO A PARKING LOT WHERE THE FUEL FILTER WAS CHANGED. THREE DAYS LATER, VEHICLE BEGAN TO RUN ROUGH AND WAS TAKEN TO A LOCAL DEALERSHIP WHO REPLACED AN INJECTOR. THE VEHICLE STALLED AGAIN AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A DEALERSHIP, AND THE OIL PUMP, INJECTORS, TURBO, AND RADIATOR FILTERS WERE REPLACED BUT THE PROBLEM PERSISTED. THE VEHICLE EMITTED BLACK SMOKE AND OPERATED NO FASTER THAN 35 MPH. THE VEHICLE WAS TAKEN TO A DEALERSHIP AND THE PROBLEM COULD NOT BE DETERMINED BUT THE TURBO WAS REPLACED. THE MANUFACTURER WAS CONTACTED.

Seats

ODI #10152097

1 injury

Incident: March 4, 2006 · Filed: March 7, 2006

ON 3-4-06 I WAS DRIVING AN M2 FREIGHTLINER OVER THE ROAD ON I-80 IN PA WHEN HIT A POT HOLE AND THE TRUCK LIFTED ME OUT OF THE SEAT . WHEN I CAME BACK DOWN ON THE SEAT I INJURED MY BACK . THE INJURY PUT ME IN THE HOSPITAL WITH A BACK STRAIN. *NM

Other Freightliner Business Class M2 model years

Check your 2006 Freightliner Business Class M2 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner Business Class M2 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Freightliner VIN