NHTSA vehicle safety data

2009 Freightliner Business Class M2 Recalls & Complaints

The 2009 Freightliner Business Class M2 has 8 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.

NHTSA recall and complaint data for the 2009 Freightliner Business Class M2. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2009 Freightliner Business Class M2 owner complaints

Owners have filed 2 complaints with NHTSA about the 2009 Freightliner Business Class M2, describing incidents dated November 21, 2011 to December 26, 2011.

Most-cited components

Fuel/Propulsion System 1 complaint
Service Brakes 1 complaint

Newest complaints

ODI #10487522 · Filed December 6, 2012
WE HAVE HAD ISSUES WITH THE FUEL FILTER HOUSINGS STARTING TO SEEP FUEL THROUGH THE HOUSING ASSEMBLIES IN THE MBE ENGINES. WE HAVE HAD TWO OTHER UNITS WITH THE SAME ISSUE THAT WE HAD TO HAVE REPAIRED AND WE HAVE ONE OTHER VEHICLE IN THE SHOP CURRENTLY WITH THE SAME ISSUE. THESE UNITS WILL START TO…
ODI #10436895 · Filed November 23, 2011
THE SUPPORT BRACKET FOR THE RIGHT REAR BRAKE, AIR CHAMBER AND CROSS SHAFT BROKE OFF THE REAR AXLE HOUSING WHICH CAUSED THE CROSS SHAFT AND CHAMBER BRACKET TO BREAK. THIS ALLOWED THE RIGHT REAR BRAKE CHAMBER TO ROTATE UPWARD WHICH CAUSED IT TO WEDGE UNDER THE FRAME RAIL. UPON FURTHER INVESTIGATION IT…

Read all 2 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2009 Freightliner Business Class M2 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE12-018: Air Brake Reservoir Bracket Fracture
Closed September 20, 2012
- Recall 12V-405
Preliminary Evaluation PE10-007: Stop Lamps Intermittent
Closed May 23, 2010

Open and recently closed NHTSA defect investigations

Reflective Tape May be Partially Covered/FMVSS 108

NHTSA #20V214000 · Exterior Lighting · NHTSA notice

Reported April 14, 2020 · Daimler Trucks North America LLC

Potentially affected: 63,175 vehicles

Repair completion: 55.7% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL848 · Owners notified May 29, 2020

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Safety consequence

The vehicle's rearward visibility may be reduced, increasing the risk of a crash.

Manufacturer remedy

DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Hybrid Transmission Software

NHTSA #13V634000 · Power Train — Automatic Transmission · NHTSA notice

Reported December 16, 2013 · Daimler Trucks North America

Potentially affected: 255 vehicles

Manufacturer campaign FL-657 · Owners notified February 5, 2014 · Vehicles built August 27, 2008 – December 10, 2013 (per NHTSA)

Defect description

Daimler Trucks North America (DTNA) is recalling certain model year 2009-2014 model year Freightliner Business Class M2 and Freightliner Custom Chassis MT45 and MT55 chassis manufactured August 27, 2008, through December 10, 2013 and equipped with Eaton hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Safety consequence

The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Manufacturer remedy

DTNA will notify owners and dealers will update the hybrid transmission software, free of charge. The recall began on February 5, 2014. Owners may contact DTNA at 1-503-745-6910. DTNA's recall number is FL-657.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Perpendicular Air Tank Mounting Brackets

NHTSA #12V405000 · Equipment · NHTSA notice

Reported August 16, 2012 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 1,663 vehicles

Manufacturer campaign FL-631 · Owners notified December 24, 2012 · Vehicles built July 7, 2008 – December 15, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Daimler Trucks North America (DTNA) is recalling certain model year 2009-2012 Freightliner, Sterling, and Western Star vehicles manufactured from July 7, 2008, through December 15, 2011, and equipped with perpendicular air tank mounting brackets. The air tank mounting brackets may develop cracks which can lead to the air tank brackets separating from the frame rail. The air tanks may also separate from the vehicle.

Safety consequence

Air tanks that become separated from a moving vehicle may create a road debris hazard, increasing the risk of a crash.

Manufacturer remedy

DTNA will notify owners, and dealers will replace the air mounting brackets, free of charge. The recall began on December 24, 2012. Owners may contact Daimler Trucks North America toll free at 1-800-547-0712.

Notes

DTNA's recall campain number is FL-631.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HIGH PRESSURE FUEL LINE

NHTSA #12V074000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported February 28, 2012 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 103,437 vehicles

Manufacturer campaign 12C-2 · Owners notified April 27, 2012

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

Safety consequence

A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS 12C-2.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

UNEXPECTED ENGINE SHUTDOWN

NHTSA #11V173000 · Engine and Engine Cooling · NHTSA notice

Reported March 15, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 50 vehicles

Manufacturer campaign 10C-6 · Owners notified March 25, 2011 · Vehicles built August 18, 2006 – July 7, 2010 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 FREIGHTLINER BUSINESS CLASS M2 AND STERLING ACTERRA EMERGENCY VEHICLES MANUFACTURED FROM AUGUST 18, 2006, THROUGH JULY 7, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

Safety consequence

UNEXPECTED SHUTDOWN OF A VEHICLE MAY INCREASE THE RISK OF A CRASH. OVERHEATING OF THE AFTERTREATMENT DEVICE WITHOUT ENGINE SHUTDOWN MAY RESULT IN A FIRE.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DETROIT DIESEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 25, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712. THIS SAFETY RECALL CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 10V-472).

Notes

DAIMLER TRUCKS' RECALL CAMPAIGN NUMBER IS 10C-6.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

UNEXPECTED ENGINE SHUTDOWN

NHTSA #10V472000 · Engine and Engine Cooling · NHTSA notice

Reported October 8, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 58 vehicles

Manufacturer campaign 10C-6 · Owners notified December 30, 2010 · Vehicles built October 5, 2006 – May 12, 2010 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 FREIGHTLINER BUSINESS CLASS M2, CUSTOM CHASSIS MT45, S2 CHASSIS, AND STERING ACTERRA VEHICLES MANUFACTURED FROM OCTOBER 5, 2006, THROUGH MAY 24, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

Safety consequence

UNEXPECTED SHUTDOWN OF A VEHICLE MAY INCREASE THE RISK OF A CRASH. OVERHEATING OF THE AFTERTREATMENT DEVICE WITHOUT ENGINE SHUTDOWN MAY RESULT IN A FIRE.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DETROIT DIESEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

INTERMEDIATE STEERING COLUMNS

NHTSA #10V322000 · Steering — Column · NHTSA notice

Reported July 13, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,325 vehicles

Manufacturer campaign FL-582 · Owners notified December 23, 2010 · Vehicles built September 9, 2008 – April 20, 2009 (per NHTSA)

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 FREIGHTLINER BUSINESS CLASS M2, STERLING ACTERRA, A-LINE, AND L-LINE HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 8, 2008 THROUGH APRIL 20, 2009 EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)

Safety consequence

MISLOCATED WELDS MAY RESULT IN TORSIONAL AND AXIAL STRENGTH FALLING BELOW ACCEPTABLE LEVELS. THIS CONDITION COULD RESULT IN SEPARATION OF THE STEERING COLUMN, LOSS OF STEERING CONTROL AND A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-582.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

HYDRAULIC BRAKE SWITCHES

NHTSA #10V178000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported April 30, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 8,971 vehicles

Manufacturer campaign FL-577 · Owners notified May 27, 2011 · Vehicles built January 19, 2005 – April 16, 2010 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 FREIGHTLINER BUSINESS CLASS C2, FCCC B2 CHASSIS, S2 CHASSIS, AND MC CHASSIS MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

Safety consequence

THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-577.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2009 Freightliner Business Class M2. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2009 Freightliner Business Class M2.

Fuel/Propulsion System

ODI #10487522

Incident: December 26, 2011 · Filed: December 6, 2012

WE HAVE HAD ISSUES WITH THE FUEL FILTER HOUSINGS STARTING TO SEEP FUEL THROUGH THE HOUSING ASSEMBLIES IN THE MBE ENGINES. WE HAVE HAD TWO OTHER UNITS WITH THE SAME ISSUE THAT WE HAD TO HAVE REPAIRED AND WE HAVE ONE OTHER VEHICLE IN THE SHOP CURRENTLY WITH THE SAME ISSUE. THESE UNITS WILL START TO LEAK FUEL AND WILL DRAIN THE FILTER HOUSING OVERNIGHT LEAKING FUEL ON THE ENGINE AND THE GROUND, AND UNDER THE RIGHT CIRCUMSTANCES MAY BECOME A POSSIBLE FIRE HAZARD..WE THOUGHT IT MIGHT BE AN ISOLATED INCIDENT BUT AFTER FOUR INCIDENTS AND THE PART BEING BACKORDERED WE THINK THIS MAY BE A BIGGER PROBLEM. *TR

Service Brakes, Hydraulic

ODI #10436895

Incident: November 21, 2011 · Filed: November 23, 2011

THE SUPPORT BRACKET FOR THE RIGHT REAR BRAKE, AIR CHAMBER AND CROSS SHAFT BROKE OFF THE REAR AXLE HOUSING WHICH CAUSED THE CROSS SHAFT AND CHAMBER BRACKET TO BREAK. THIS ALLOWED THE RIGHT REAR BRAKE CHAMBER TO ROTATE UPWARD WHICH CAUSED IT TO WEDGE UNDER THE FRAME RAIL. UPON FURTHER INVESTIGATION IT WAS DISCOVERED THAT THE SUPPORT BRACKET WELDED ON THE LEFT REAR SIDE OF THE AXLE HOUSING WAS ALSO BROKEN AND WAS NOT SUPPORTING THE LEFT REAR BRAKE CHAMBER AND CROSS SHAFT ASSEMBLY. IN THE CONDITION IT WAS DISCOVERED THE RIGHT REAR BRAKE WAS NOT FUNCTIONAL. *TR

Other Freightliner Business Class M2 model years

Check your 2009 Freightliner Business Class M2 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner Business Class M2 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Freightliner VIN