2000 Ford F-350 Recalls & Complaints

Incident: September 18, 2025 · Filed: November 13, 2025

On [XXX], I rented a Class C motorhome from Cruise America at their Duluth, Georgia branch (Reservation #[XXX]). When I picked up the vehicle, the Cruise America employee pointed to a handwritten note taped over the tire pressure warning light on the dashboard that said: “ignore tire sensor.” The note was already in place before I arrived, suggesting that other renters may have used the vehicle in that same unsafe condition. Three days later, while traveling northbound on [XXX] near Memphis, Tennessee, the RV suffered a sudden tire blowout at highway speed. We narrowly avoided a collision while maneuvering to the shoulder. Thankfully, no one was injured, but the incident was extremely dangerous and could easily have resulted in fatalities. Cruise America knowingly rented out a vehicle with an active tire pressure warning covered and concealed, depriving the driver of critical safety information. The company did not repair or document the issue, instead instructing renters to “ignore” the tire warning. This conduct may violate Federal Motor Vehicle Safety Standard No. 138 (49 C.F.R. § 571.138) and 49 U.S.C. § 30122, which prohibit making safety equipment inoperative or misleading drivers about safety system status. While TPMS sensors can fail naturally, covering the warning light constitutes deliberate concealment and undermines the system’s purpose. I am concerned that Cruise America may be circulating other rental vehicles in similar unsafe condition. Please investigate whether Cruise America, Inc. is in compliance with federal vehicle-safety laws governing TPMS functionality and rental-vehicle maintenance standards. Specifically, whether any branch locations are renting vehicles with disabled, covered, or ignored tire-pressure monitoring systems or other concealed safety warnings. Reported to Cruise America Customer Relations (Case #[XXX]). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: April 5, 2025 · Filed: April 26, 2025

The first and only notification received was the April 5, 2025 email. The 2000 F350 did experience issues of stalling on the road many times. After several thousand dollars of repairs, the camshaft position sensor was replaced by a commercial diesel mechanic. No warnings of any kind were displayed. The truck stalled on the freeway ramp and other streets. These issues occurred since 2000 when the truck was purchased. The lack of notification and choice of fix caused danger and a lot of repair costs. This is unacceptable.

Incident: July 2, 2024 · Filed: July 2, 2024

On 7/2/24, I went to Robinson Brothers Ford in Baton Rouge, LA to address an unrepaired Recall item on a 1994 F350. The service advisor refused to perform the recall work. They stated that the vehicle was too old. This recall is concerning an issue with a switch that can leak break fluid and cause an engine fire.

Incident: February 12, 2024 · Filed: February 15, 2024

I scan the truck misfire keep popping up I change four coil packs and all new sparkplugs and the same thing 4cyl misfire again and its paper sucking up thru tail pipe

Incident: August 13, 2023 · Filed: September 19, 2023

I had purchesed a set of Dick Cepek Extreme Country LT315/75/R16. The tires have 9/32nd left with approximately 15,000 miles. While driving on the highway the sidewall of the tire peeled off in one strip causing the tire to no longer hold its shape and blow out. Had it been a steer tire the incident could have been much worse. Twenty minutes prior to the failure all tires were inspected and confirmed to be inflated to the proper psi and without damage.

Incident: November 18, 2019 · Filed: November 2, 2021

The contact owns a 2000 Ford F-350 equipped with Guangzhou 9007 bulbs. The contact stated that upon installing the bulbs, he noticed that the low-beam and the high-beam bulbs provided similar illumination. The contact then received an email from Amazon notifying him of NHTSA Campaign Number: 21E004000 (Exterior Lighting). The contact was instructed to fill out a form on the manufacturer's website to receive replacement bulbs; however, the contact had yet to receive the replacement bulbs. The contact also made multiple attempts to reach the manufacturer by phone, but all the attempts were unsuccessful. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The bulbs were not replaced. The failure mileage was approximately 140,000. The VIN was not available.

Incident: October 3, 2021 · Filed: October 25, 2021

The death wobble. Hitting a bump - no matter the size and without warning - may cause your entire vehicle to wobble/shake uncontrollably and loose ability to steer. You’re only recourse is to let off of the accelerator and TRY to hold the truck in the lane and pray you don’t have to brake or make a turn. It has happened multiple times but the worse was while traveling I-10 in San Antonio, Texas while pulling a horse and trailer.

Incident: September 27, 2021 · Filed: September 27, 2021

The fuel tank sender on this vehicle is defective. Every single person I know, including over 100 people in a small facebook Ford group have broken fuel tank senders. Ford never recalled it and sell a new one for $600.

Incident: August 31, 2020 · Filed: October 19, 2020

WHILE DRIVING ON THE N.Y THRUWAY. MY MICHELIN MLX TIRES TREAD SEPARATED FOR THE TIRE CAUSING A BLOW OUT AND TEARING OFF THE REAR PASSENGER DUALLY FENDER OF MY F350 . PIECES OF THE FEND AND TIRE FLEW ALL OVER THE N.Y THRUWAY

Incident: May 20, 2020 · Filed: May 20, 2020

STOPPED AND PUT IN PARK,SLIPPED OUT OF PARK AND ROLLED. HAS HAPPENED 3 TIMES. *TR