NHTSA vehicle safety data

2005 Ford F-350 Recalls & Complaints

The 2005 Ford F-350 has 5 NHTSA recall campaigns and 115 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

Includes campaigns NHTSA files under the spelling "F350".

NHTSA recall and complaint data for the 2005 Ford F-350. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Ford F-350 owner complaints

Owners have filed 115 complaints with NHTSA about the 2005 Ford F-350, describing incidents dated October 1, 2004 to March 18, 2025.

Most-cited components

Fuel/Propulsion System 36 complaints
Engine 35 complaints
Steering 28 complaints
Suspension 25 complaints
Electrical System 15 complaints
Power Train 5 complaints

Of the 115 complaints on file, 5 report a crash and 3 a fire; across all 115 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11652135 · Filed April 1, 2025
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up…
ODI #11594346 · Filed June 14, 2024
Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.
ODI #11574799 · Filed February 29, 2024
Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the…

Read all 115 complaints

Owner-reported

2005 Ford F-350 mileage at failure

93 of the 115 complaints on file for the 2005 Ford F-350 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 100,000 miles	Middle half 55,000–120,000 miles	Based on 32 complaints
Engine	Median 95,000 miles	Middle half 75,000–130,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Ford F-350 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA08-007: VIOLENT FRONT END OSCILLATION
Closed March 31, 2009
Preliminary Evaluation PE07-057: VIOLENT FRONT END OSCILLATION
Closed March 14, 2008

Open and recently closed NHTSA defect investigations

STEERING COLUMN MULTIFUNCTION SWITCH/FMVSS 108

NHTSA #11V352000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported July 13, 2011 · FORD MOTOR COMPANY

Potentially affected: 26,715 vehicles

Ford campaign 11C18 · Owners notified August 15, 2011

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Safety consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD'S SAFETY RECALL NO. 11C18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 403/ANTI-STOW INTERLOCK/RICON

NHTSA #09V026000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 26, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 108 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – September 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 108 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Safety consequence

A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

THRESHOLD WARNING SYSTEM/FMVSS 404/RICON

NHTSA #09V025000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 23, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 111 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – October 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 111 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Safety consequence

THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS/TOW ASSEMBLIE

NHTSA #07E066000 · Equipment — Electrical · NHTSA notice

Reported August 28, 2007 · CEQUENT ELECTRICAL PRODUCTS

Potentially affected: 175 vehicles

Owners notified September 5, 2007

Defect description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Safety consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Manufacturer remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WHEEL RIMS - BRAKE LINE WEAR

NHTSA #06E087000 · Service Brakes, Air · NHTSA notice

Reported October 17, 2006 · HARSCO TRACK TECHNOLOGIES

Potentially affected: 450 vehicles

Owners notified September 15, 2006

Defect description

CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.

Safety consequence

BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

Notes

HARSCO RECALL NO. #06-006.THIS RECALL ONLY PERTAINS TO MODIFICATION KITS MANUFACTURED BY HARSCO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F-250 AND F-350 4X4 PICKUP TRUCKS MANUFACTURED BY THE FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Ford F-350. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

115 owner complaints have been filed with NHTSA for the 2005 Ford F-350.

Air Bags

ODI #11652135

Crash 1 injury

Incident: March 18, 2025 · Filed: April 1, 2025

The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.

Electrical System

ODI #11594346

Incident: April 14, 2024 · Filed: June 14, 2024

Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

Steering; Suspension

ODI #11574799

Incident: February 29, 2024 · Filed: February 29, 2024

Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Steering; Suspension

ODI #11530347

Incident: July 4, 2023 · Filed: July 4, 2023

My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.

Steering; Suspension

ODI #11466661

Incident: April 5, 2022 · Filed: May 30, 2022

Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.

Steering; Suspension

ODI #11464386

Incident: May 12, 2010 · Filed: May 12, 2022

The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.

Electrical System; Engine; Fuel/Propulsion System

ODI #11462783

Incident: February 1, 2022 · Filed: April 29, 2022

The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

Unknown or Other

ODI #11447083

Incident: January 11, 2022 · Filed: January 11, 2022

Oil leaking from more than 4 parts of the engine and was told it’s normal for this model. Also, when driving over a bump or uneven pavement the trucks steering and suspension drives out of control.

Unknown or Other

ODI #11444537

Incident: November 5, 2020 · Filed: December 21, 2021

Once I get up to 55-60 mph it just shakes really bad, I have had ball joints replaced bought new tires and it still shakes

Electrical System; Service Brakes; Engine

ODI #11437097

Crash Fire 1 injury

Incident: December 13, 2019 · Filed: October 17, 2021

[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Other Ford F-350 model years

Check your 2005 Ford F-350 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-350 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN