2004 Ford F-350 Recalls & Complaints

Incident: March 18, 2025 · Filed: April 18, 2025

The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact was able to regain control of the vehicle and pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The contact stated that as an independent mechanic, he used a code reader to retrieve diagnostic trouble codes for the fuel control module wiring harness failure. The contact related to the failure to NHTSA Campaign Number: 05V270000 (Electrical System). The contact stated that the fuel control module wiring harness failure had caused warning lights to fail to illuminate as needed. The dealer was notified of the failure and informed the contact that the vehicle had previously been repaired under the recall. The manufacturer was notified of the failure and informed the contact that an elbow vacuum tubing connector was previously replaced under the recall; however, the contact advised the manufacturer that the recall involved replacing the entire fuel control module wiring harness. The manufacturer informed the contact that the recall was already marked completed and no further repairs could be covered. The contact stated that the dealer and the manufacturer had failed to honor the recall repair. The vehicle was not repaired. The failure mileage was 190,019.

Incident: April 14, 2022 · Filed: April 28, 2022

While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several accidents with this truck. Once it is stalled it can take numerous times to restart the vehicle. This issue seems to occur more on slopes going up hill. This does not seem to occur as often going downhill or on areas with no incline. Currently vehicle has 126,931.8 miles on it. Regularly serviced and otherwise running fine.

Incident: September 24, 2021 · Filed: September 24, 2021

The contact owns a 2004 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT3, Tire size: 265/75/R16, DOT Number: UPWM1M11718M16L. The contact stated that while driving 65 MPH, the rear driver’s side tire had a sidewall blowout. The contact stated that all four tires had sidewall blowouts months apart. The tire blowouts had damaged the rims. The contact replaced the front driver’s, passenger’s, and rear driver’s side tire with the spare after each blowout. The dealer was made aware of the failure and replaced the rear passenger’s side tire. The manufacturer was made aware of the failure and the rear driver’s side rim, rear driver’s and front passenger’s side tire were sent to the manufacturer. The failure mileage was not available.

Incident: September 18, 2020 · Filed: October 20, 2020

MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR

Incident: September 13, 2020 · Filed: September 14, 2020

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE HOWEVER, THE FAILURE RECURRED. UPON INSPECTION, THE CONTACT DISCOVERED THE FUEL FILTER WAS COVERED WITH SILVER DEBRIS. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS CONTACTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 332,000.

Incident: June 11, 2019 · Filed: July 16, 2020

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND MADE MULTIPLE ATTEMPTS TO RESTART THE VEHICLE HOWEVER, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THE VEHICLE WITH A DEFECTIVE FUEL INJECTION CONTROL MODULE. CASA FORD (5815 MONTANA AVE, EL PASO, TX 79925) AND THE MANUFACTURER WERE CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000.

Incident: March 1, 2019 · Filed: April 24, 2019

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. ALSO, WHILE IDLING, THE ENGINE RPMS REMAINED VERY HIGH AND THE VEHICLE WOULD ATTEMPT TO SURGE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE ICP SENSOR AND INJECTOR CONTROL SENSOR, BUT THE FAILURES CONTINUED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 200,000.

Incident: February 14, 2019 · Filed: March 19, 2019

TAKATA INFLATORS; MY VEHICLE STARTED ALL TYPES OF PROBLEMS INTERMITTENT ONES THAT COST ME SEVERAL THOUSAND DOLLARS NEVER FIXING THE PROBLEM THIS IS WERE IT ALL BEGAN,,.MY VEHICLE DIED GOING UP FAIRLY STEEP HILL TO GRAVE YARD, IT IMMEDIATELY ROLLED BACK SHOVING A FAMILY MEMBERS VEHICLE DOWN HILL A WAYS UNTIL THEY TURNED AWAY FROM THE CLIFF EDGE LEAVING ME ALL ALONE.UNTIL GOING THROUGH A RUN OFF DITCH STOPPING OVER IT INTO 2 TREES. I HAD NO STEERING NO BRAKES AND THANK GOD THE TREES WERE THERE TO STOP MY TRUCK IF NOT THEIR WAS A 100 FOOT CLIFF NEXT.. I KNOW NOTHING ABOUT RECALLS OR SUCH I JUST TRIED TO FIX MY TRUCK PROBLEM BY PROBLEM AS SYMPTOMS CAME ON I HAVE ALL TYPES OF RECENT RECEIPTS THAT ALL CAME FROM SILVERISH DARK MAYBE EVEN GRAY MATTER STUFF IN THE TANK. WHEN I GET MY BANK STATEMENT I WILL ITEMIZE ALL AND SUBMIT THEM WHEN FINAL COST IS OVER.

Incident: October 13, 2010 · Filed: October 3, 2017

TL* THE CONTACT OWNS A 2004 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE GEAR SHIFTER INTO NEUTRAL AND WAS ABLE TO RESTART THE VEHICLE. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. WHILE DRIVING VARIOUS SPEEDS, THE BATTERY, OIL PRESSURE AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY DID NOT HAVE A RECORD OF THE VEHICLE BEING SERVICED. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Incident: August 31, 2017 · Filed: September 7, 2017

TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT THE FUEL TANK STRAP WAS SEVERELY CORRODED AND THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THIS WAS THE SECOND TIME THE FAILURE OCCURRED. AN UNKNOWN FORD DEALER WAS CONTACTED AND REFERRED THE CONTACT TO FORD USA. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS NO RECALL AND HE WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000. UPDATED 11/02/17*LJ *TT