2020 Ford F-350 Recalls & Complaints

Incident: June 1, 2026 · Filed: July 8, 2026

While towing any trailer with electric brakes it appears the integrated trailer brake controller is briefly applying trailer brakes unexpectedly. Very brief but very hard, resulting in an extreme rearward pull on the truck. It happens at exactly 60 minute intervals, at any speed, uphill, downhill and level flat road. I've had the trailer 7 way plug and wire inspected, no problem found. Next step will be to have Ford dealer inspect truck electronics.

Incident: August 22, 2025 · Filed: June 24, 2026

The contact owns a 2020 Ford F-350. The contact stated that while driving 30 MPH and driving around a curve, the steering wheel was turned; however, the vehicle failed to respond and crashed into a guardrail. The contact associated the failure with NHTSA Campaign Number: 25V626000 (Steering). There was extreme damage to the underbody of the vehicle, and several parts were separated from the vehicle. The vehicle was towed to an impound lot and was deemed a total loss by the Insurance Company. The contact sustained a concussion and neck injury and was taken to the hospital for medical assistance. The dealer was not contacted. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was unknown.

Incident: June 1, 2025 · Filed: June 9, 2026

I am the issues as the recalls for the 2023 f350 The Problem: The Integrated Trailer Module (ITRM/ITM) may lose communication with the vehicle when it starts up, resulting in a loss of trailer brake function, turn signals, and stop lamps.

Incident: June 2, 2026 · Filed: June 2, 2026

The contact owns a 2020 Ford F-350. The contact received a notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealers were contacted; however, the parts were on back order until late September. Another local dealer was contacted (Kendall Ford of Anchorage|1950 Gambell St, Anchorage, AK 99501); however, the distance was far to great in a remote area. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Incident: May 4, 2026 · Filed: May 21, 2026

The contact owns a 2020 FORD F-350. The contact stated while driving at an undisclosed speed, he had a loss of motive power and check engine warning light was illuminated when driving, almost causing an accident due to not being able to accelerate. The vehicle was taken to a dealer where it was diagnosed to have metal shavings in the combustion system. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the SSSC (Special Service Center assistance request) was declined by Ford agency (SSSC), due to the issue not having metal shavings although the dealer technician stated there were shavings. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 126,136.

Incident: April 29, 2026 · Filed: May 8, 2026

The component/system that failed or malfunctioned is the SCR (Selective Catalytic Reduction) NOx Catalyst Efficiency system, triggering DTC P20EE – SCR NOx Catalyst Efficiency Below Threshold (Bank 1). This issue began immediately after Ford Recall 24S78 (PCM software update) was performed on April 29, 2026 at Ferman Ford of Countryside. The truck had zero emissions or check-engine issues prior to the recall flash and was perfectly maintained to Ford standards with Howes diesel treatment every tank. The problem has been reproduced and confirmed multiple times by the dealer: After the May 4 PCM reprogram per TSB 21-2248 After replacement of both NOx sensors on May 5 (code returned in under 17 miles) After replacement of the DEF injector (code returned again) The dealer only performed one manual DPF regeneration instead of the two required by Ford SSM 49202 and pinpoint test RD15, and they did not complete the SCR Parameter Reset. They are now quoting an additional ~$2,000 out-of-pocket for a DPF replacement after partial goodwill assistance was approved. The vehicle has been repeatedly inspected and repaired by Ferman Ford. No independent inspection yet. Ford Customer Service has been contacted and partial goodwill was approved, but significant out-of-pocket costs remain. Warning lamps/messages (Service Engine Soon light + “exhaust emission control system is not operating as expected”) first appeared immediately after the April 29 recall PCM flash and have continued ever since. Safety risk: A loss of motive power, entry into limp mode, or reduced power while driving could result in a crash or inability to maintain highway speed. This appears to be a direct consequence of the Recall 24S78 PCM software update tightening emissions monitoring. All repair orders, photos of warnings, and supporting documents are attached for your review. There is 12. I was not able to upload the last of the documents.

Incident: October 21, 2024 · Filed: April 16, 2026

This is a supplemental complaint to ODI Number 11730675 filed on April 16 2026. I am adding the following critical information: I am filing this complaint in relation to Ford's NHTSA Consent Order regarding recall compliance. My 2020 F-350 VIN [XXX] was built at Kentucky Truck Plant in March 2020 — within the exact production window of Safety Recall 22S22. My transmission has failed with the exact defect mechanism described in 22S22. My VIN was excluded from the recall FSA list despite matching build date, plant, and identical failure mode. I am requesting this complaint be reviewed in the context of Ford's consent order obligations regarding proper recall scope. Ford Customer Care Case Number: XXX-XXX." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: April 10, 2024 · Filed: April 12, 2026

Vehicle experienced sudden, unexpected downshifting and loss of gear engagement while driving. On multiple occasions the transmission slipped out of gear without warning, including while attempting to pull into traffic, creating an immediate life-threatening safety hazard. Vehicle was unable to maintain gear selection and would unexpectedly lose drive power. These failures match the exact defect described in NHTSA recall 22V256000

Incident: February 16, 2026 · Filed: April 7, 2026

The contact owns a 2020 Ford F-350. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel), 25V626000 (Steering), and 25V686000 (Back Over Prevention); however, the parts for two of the recall repairs were not yet available. The local dealer was made aware of the recalls and confirmed that parts for two of the recalls were not yet available; however, parts for the steering column recall were available. The vehicle was taken to the dealer, where it remained for two months. The contact was then informed that parts to repair the vehicle were unavailable, and the contact was informed to retrieve the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and provided the same information as the dealer. The contact had not experienced a failure.

Incident: March 17, 2026 · Filed: April 6, 2026

The contact owns a 2020 Ford F-350. The contact stated that while parked and turned off, he observed a loud explosion noise while he was inside his residence. The contact stated that he left his residence to investigate, and he observed the front of the vehicle and the cabin of the vehicle engulfed in flames. The fire department was called, and they extinguished the fire. Medical attention was not needed. A police report was filed. The vehicle was not diagnosed, repaired, or moved. The manufacturer was notified of the failure. The failure mileage was 170,000