NHTSA vehicle safety data

2006 Ford F-350 Recalls & Complaints

The 2006 Ford F-350 has 6 NHTSA recall campaigns and 145 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

Includes campaigns NHTSA files under the spelling "F350".

NHTSA recall and complaint data for the 2006 Ford F-350. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Ford F-350 owner complaints

Owners have filed 145 complaints with NHTSA about the 2006 Ford F-350, describing incidents dated February 28, 2005 to July 2, 2025.

Most-cited components

Steering 51 complaints
Suspension 50 complaints
Engine 33 complaints
Fuel/Propulsion System 22 complaints
Service Brakes 8 complaints
Air Bags 7 complaints

Of the 145 complaints on file, 11 report a crash and 4 a fire; across all 145 complaints, owners report 10 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11700311 · Filed November 19, 2025
2006F-350 super duty 5.4engine,,had to be replaced two and a half years ago the Ford dealer at cirroca of York,,told me that the new motor was improved that the new motors valve train was improved,,why wasn't it a recall,, if it would affect emissions and overall performance and reliability
ODI #11675113 · Filed July 21, 2025
The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower…
ODI #11588481 · Filed May 13, 2024
The contact owns a 2006 Ford F-350. The contact stated that while the vehicle was parked, the contact noticed that fuel was leaking underneath the front driver's side of the vehicle. The vehicle was taken to an independent mechanic, who replaced the fuel pump block-off plate and plug. The…

Read all 145 complaints

Owner-reported

2006 Ford F-350 mileage at failure

129 of the 145 complaints on file for the 2006 Ford F-350 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 55,000 miles	Middle half 25,000–80,000 miles	Based on 46 complaints
Suspension	Median 55,000 miles	Middle half 20,000–90,000 miles	Based on 43 complaints
Engine	Median 65,000 miles	Middle half 25,000–110,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Ford F-350 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA08-007: VIOLENT FRONT END OSCILLATION
Closed March 31, 2009
Preliminary Evaluation PE07-057: VIOLENT FRONT END OSCILLATION
Closed March 14, 2008

Open and recently closed NHTSA defect investigations

STEERING COLUMN MULTIFUNCTION SWITCH/FMVSS 108

NHTSA #11V352000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported July 13, 2011 · FORD MOTOR COMPANY

Potentially affected: 26,715 vehicles

Ford campaign 11C18 · Owners notified August 15, 2011

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Safety consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD'S SAFETY RECALL NO. 11C18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 403/ANTI-STOW INTERLOCK/RICON

NHTSA #09V026000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 26, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 108 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – September 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 108 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Safety consequence

A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

THRESHOLD WARNING SYSTEM/FMVSS 404/RICON

NHTSA #09V025000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 23, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 111 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – October 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 111 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Safety consequence

THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS/TOW ASSEMBLIE

NHTSA #07E066000 · Equipment — Electrical · NHTSA notice

Reported August 28, 2007 · CEQUENT ELECTRICAL PRODUCTS

Potentially affected: 175 vehicles

Owners notified September 5, 2007

Defect description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Safety consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Manufacturer remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WHEEL RIMS - BRAKE LINE WEAR

NHTSA #06E087000 · Service Brakes, Air · NHTSA notice

Reported October 17, 2006 · HARSCO TRACK TECHNOLOGIES

Potentially affected: 450 vehicles

Owners notified September 15, 2006

Defect description

CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.

Safety consequence

BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

Notes

HARSCO RECALL NO. #06-006.THIS RECALL ONLY PERTAINS TO MODIFICATION KITS MANUFACTURED BY HARSCO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F-250 AND F-350 4X4 PICKUP TRUCKS MANUFACTURED BY THE FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 119/PREMATURE TIRE WEAR

NHTSA #05T022000 · Tires — Tread/Belt · NHTSA notice

Reported November 21, 2005 · CONTINENTAL TIRE NORTH AMERICA, INC.

Potentially affected: 34,396 vehicles

Owners notified December 7, 2005

Defect description

CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.

Safety consequence

AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.

Manufacturer remedy

CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Ford F-350. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

145 owner complaints have been filed with NHTSA for the 2006 Ford F-350.

Engine

ODI #11700311

Incident: February 28, 2023 · Filed: November 19, 2025

2006F-350 super duty 5.4engine,,had to be replaced two and a half years ago the Ford dealer at cirroca of York,,told me that the new motor was improved that the new motors valve train was improved,,why wasn't it a recall,, if it would affect emissions and overall performance and reliability

Steering; Suspension

ODI #11675113

Incident: July 2, 2025 · Filed: July 21, 2025

The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.

Fuel System, Diesel

ODI #11588481

Incident: April 13, 2024 · Filed: May 13, 2024

The contact owns a 2006 Ford F-350. The contact stated that while the vehicle was parked, the contact noticed that fuel was leaking underneath the front driver's side of the vehicle. The vehicle was taken to an independent mechanic, who replaced the fuel pump block-off plate and plug. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 190,000.

Air Bags

ODI #11581799

Incident: April 8, 2024 · Filed: April 8, 2024

The contact owns a 2006 Ford F-350. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. A dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

Suspension; Engine

ODI #11562586

Incident: December 15, 2023 · Filed: December 29, 2023

The contact owns a 2006 Ford F-350. The contact stated that while driving 35 MPH, the front of the vehicle started to wobble. While driving over a pothole, the vehicle wobbled violently. The contact was unable to control the vehicle while driving over 35 MPH. While driving at an undisclosed speed, the contact detected smoke coming from the vehicle. The engine warning light was illuminated. The contact called the local dealer, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 99,856.

Equipment

ODI #11539396

1 injury

Incident: August 6, 2023 · Filed: August 18, 2023

While performing a lift of a 520-pound load in a boom position rated for 575 pounds, the crane abruptly failed due to a faulty weld and dropped the load approximately 18 inches, causing minor injuries to the crane operator. There was no sign of trouble before the failure. The failed weld was a circumferential weld between the support pillar and the bearing mount. This was concealed inside the base of the boom assembly and this part arrived already assembled. The skirt that extends from the boom assembly over the bearing mount caught on the pillar and stopped the boom from falling off the pillar entirely. The weld had a full bead but no penetration around most of its circumference. After painting this would have been hard to inspect visually even with the appropriate portion disassembled. Other reviews posted on Amazon.com, where the crane was purchased, show the same kind of deficient welding. The problem was reported to Amazon through a customer service representative and through their safety issue reporting system but they have made no acknowledgement of the issue and have not asked for more details. The broken component has since been repaired and returned to service but photographs of the failure are available.

Service Brakes, Air; Air Bags

ODI #11524001

Crash

Incident: January 30, 2022 · Filed: May 26, 2023

The contact owns a 2006 Ford F-350. The contact stated that while driving at approximately 35 MPH, the brake pedal was depressed, and the brake pedal remained on the floorboard. The vehicle crashed into another vehicle. The contact stated that the air bags failed to deploy. The vehicle was restarted but the failure persisted. A police report was filed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the ABS needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 184,000.

Suspension; Steering

ODI #11462633

Incident: April 26, 2022 · Filed: April 28, 2022

Vehicle has experienced "death wobble," a common and well documented occurrence in Ford F250 and F350 model trucks. This has occurred on multiple occasions since 2006, and most recently on 4/26/2022. The incident occurred while traveling approximately 45 MPH, and hitting a small bump in the road. When the "death wobble" occurs, the vehicle shakes violently and is difficult to control. This creates a hazardous situation for the occupants of the vehicle and other vehicles/pedestrians in the vicinity of the vehicle. Prior and current attempts to contact Ford service departments, typically involves Ford stating there is not a recall and any repair outside of warranty are the responsibility of owner. The vehicle is available for inspection upon request. There is no warning prior to the "death wobble," and occurs when the vehicle is travelling at speed more than 45 MPH.

Suspension

ODI #11452299

Incident: February 1, 2022 · Filed: February 16, 2022

8 years ago was crossing RR tracks and vehicle started violently shaking had to slow to 10mph for it to stop. Checked found nothing wrong finished drive home. Took to Ford dealership and they said some tricks shake when tire pressure is wrong and didn't find anything wrong with vehicle. Truck did this once more and after that when I approach RR tracks I slow to 5- 10 mph to keep it from happening. Took it back to Ford 1 time and again they spoke about tire pressure but tire pressure was fine. In the last 2 weeks anytime I hit a bump the truck violently shakes I took to a mechanic shop and they said something was wrong with front end but not sure what. I called Ford and they said to bring it in. We will see what happens because this truck has done this off and on for the last 8 years, but now it does it all the time. It has been shaking so violently I wouldn't be surprised if other damages have happened from it.

Unknown or Other

ODI #11435542

Incident: October 2, 2021 · Filed: October 5, 2021

At highway speeds hitting a bump or small pothole the steering wheel vibrates to the point of almost losing control. If I didn't have two hands on the wheel I possibly could have lost control of my vehicle and crashed

Other Ford F-350 model years

Check your 2006 Ford F-350 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-350 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN