2020 Ford F-350 SD Recalls & Complaints

Incident: October 7, 2025 · Filed: October 7, 2026

The contact owns a 2020 Ford F-350 SD. The contact stated that while driving and depressing the brake pedal, the vehicle lurched forward, and the brake pedal was depressed with more force for the vehicle to respond as intended. The contact stated that while driving at various speeds, the transmission shifted hard and downshifted with reduced power. The Forward Collision Avoidance alarm sounded after the vehicle downshifted. The contact pulled over to the side of the road before continuing to drive. Additionally, the vehicle rolled backwards while in park(P). The vehicle was taken to the dealer, where it was diagnosed and determined that the transmission needed to be replaced. The failure was associated with NHTSA Campaign Numbers: 20V365000 (Power Train) and 22V256000 (Power Train); however, the VIN was not included in the recalls. The dealer reported the failure to the manufacturer, and a case was filed. The failure mileage was approximately 140,000.

Incident: August 16, 2026 · Filed: August 26, 2026

The contact owns a 2020 Ford F-350 SD. The contact stated that while attempting to start the vehicle with the ignition key, the vehicle failed to start as intended. The check engine warning light was illuminated. In addition, the contact associated the failure with NHTSA Campaign: 24V957000 (Fuel System, Diesel); and the VIN was included. The vehicle was towed to a local dealer where it was diagnosed with the fuel pump failure. The vehicle was not repaired under NHTSA Campaign Number: 24V957000(Fuel System, Diesel); because there was no metallic debris found in the fuel system. The manufacturer was made aware of the failure, and the recall repair was denied. The failure mileage was approximately 230,000.

Incident: August 18, 2026 · Filed: August 20, 2026

VEHICLE EXTENDED CRANKING WITHOUT STARTING WHILE THE VEHICLE IS PARKED, AND ONCE STARTED IT WAS LOSS OF MOTIVE POWER WHILE DRIVING AND ALMOST WAS IN ACCIDENT BECAUSE OF THIS. SHEEHY FORD SEE ITS A RECALL AND SEE ITS EXACTLY WHAT THE RECALL IS STATING BUT REFUSING TO FIX IT AND WANT TO CHARGE ALMOST 10K TO DO SO.

Incident: July 1, 2026 · Filed: August 16, 2026

The backup camera on the tailgate fails about 50% of the time when shifting into reverse. The screen is black. When it fails, I can sometimes get it to work by opening, then slamming the tailgate. I suspect that there is an intermittent open circuit in the camera system. This presents a dangerous situation when trying to back this very large dual rear wheel vehicle. This is not related to the current recall for another issue with the camera when backing into a darkened area.

Incident: July 17, 2026 · Filed: July 28, 2026

1. High Pressure Fuel Pump 2. All safety is good 3. It has been taken to the dealership and blaming it on the water separator (water/rust in fuel) The codes thrown are towards the High Pressure Fuel Pump 4. No there were no warning lights or messages prior to the failure. 5. Dealership did not provide the inspection report

Incident: July 17, 2026 · Filed: July 28, 2026

The contact owns a 2020 Ford F-350. The contact stated that while driving 65 MPH and towing a dump trailer, the vehicle entered LIMP Mode. The contact was able to pull over to the side of the road. The vehicle was towed to the contact's storage yard, where an independent diesel mechanic performed a diagnostic scan and retrieved diagnostic trouble codes indicating a fuel system failure. The vehicle was towed to a dealer, where it was disassembled and diagnosed with a CP4 pump failure resulting from a water separator failure. The contact was informed that the CP4 pump replacement was not covered and needed to be replaced at the owner's expense. The manufacturer was notified of the failure and contacted the dealer, but no further assistance or information was available. The vehicle was not repaired. The failure mileage was approximately 180,000.

Incident: May 30, 2026 · Filed: July 1, 2026

The transmission began malfunctioning by having hard shifting issues and losing power in some gears. An indicator on the dash lit up resembling a mechanics open-end wrench. Research online showed that the vehicle should not be driven and taken immediately to a mechanic or dealership. If driven especially pulling a heavy load like the fifth wheel that I bought the truck to tow the transmission could fail causing a serious safety issue. I immediately took the vehicle to a certified Ford dealership. At the dealership they informed me that parts in the transmission had failed and that it was the same exact condition as shown in recall 20S33. The noted recall was for trucks manufactured in January and February of 2020. My truck was manufactured March of 2020. The time warranty had expired for the vehicle but the mileage warranty was for 60,000 mi and the truck failed at $29,800. The transmission failed due to a manufacturing defect but I was billed over $9,800 for the repair. I have attached photos of the work order and receipt.

Incident: November 20, 2025 · Filed: December 4, 2025

I have the 7.3 gas engine. It is now sounding like a typewriter. I've been told I could have a $8,000 to $13,000 repair or total engine replacement. My truck is just under 97,000 miles and this has been a known issue for the Job 1 engines. Ford is not taking ownership of these lifter/cam issue. I was told I could have my engine lock up on me while driving. I am autistic and have an autoimmune issue that cause me to have a disabilities. It does not seem right, that a long term, multiple Ford owner now could have their engine fail or lock up while I'm driving, not to mention I may need a complete new engine from this design error. From what I've read, the Job 2 of these engines they've enlarged oil recyclers or something to correct this issue. Can you help us that have this major saftey issue?

Incident: September 1, 2021 · Filed: September 24, 2024

My 2020 Ford F-350 has had an occasional problem with the transmission since shortly after I purchased it. It started with sticking in gear occasionally to the point where the engine RPM's would stay very high but not shift even when pushing the accelerator even more. It just would not come out of it. The dealer didn't find any issue and the issue subsided a bit, but in the last 6-8 months, it has noticeably shifted hard into drive, but not when shifting into reverse. Putting it in drive even with the brake depressed hard to the floor, it jolts forward and shakes the entire truck. When downshifting, it sometimes does it so hard that it feels like a vehicle hit the rear of the truck. There is nothing smooth about this truck with the behavior this transmission is showing. I changed the fluid and filter 6 weeks ago and it's the same. It also occasionally revs up when accelerating as you turn a corner and it "catches." I am mostly a daily driver that occasionally tows a boat or snowmobile trailer. Non-commercial user.

Incident: March 26, 2024 · Filed: June 30, 2024

Ford 10R140 Transmission Issues: Transmission has harsh engagement, clunks and slams into gear. Transmission gets stuck in between gears while in motion at all speeds while driving on city streets or on the freeway. Transmission LURCHES forward when shifting from park into drive even when applying the brake and when the parking brake is engaged. This transmission is UNSAFE and UNRELIABLE!!!!