2008 Ford F-350 SD Recalls & Complaints

Incident: March 26, 2021 · Filed: April 5, 2021

TL* THE CONTACT OWNS A 2019 FORD F-350 SD, EQUIPPED WITH MICHELIN TIRES, TIRE LINE: LTX MS/2, TIRE SIZE: 245/75/R17, DOT NUMBER: B74345 (PARTIAL). THE CONTACT STATED WHILE DRIVING 75 MPH, THE FRONT DRIVER'S SIDE TIRE WENT FLAT AND THE STEERING CEASED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND PULLED OVER TO THE SIDE OF THE ROADWAY. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE CONTACT STATED THAT IT WAS THE SECOND TIME THE FAILURE OCCURRED. THE FIRST TIME, THE FRONT PASSENGER SIDE TIRE WENT FLAT WHILE THE CONTACT WAS DRIVING AT AN UNDISCLOSED SPEED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THERE WAS NO RECALL AND THAT THE TIRE WAS OVER THE WARRANTY COVERAGE PERIOD. THE FAILURE MILEAGE WAS 54,000. THE VIN WAS UNAVAILABLE.

Incident: January 11, 2018 · Filed: February 11, 2019

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 12 MPH, THE STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DETACHED FROM THE STEERING BOX. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. BOB BELL FORD WAS CONTACTED BY PHONE AT 410-766-3600 (LOCATED AT 7125 RITCHIE HWY, GLEN BURNIE, MD 21061). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

Incident: July 24, 2018 · Filed: July 25, 2018

THE 2008, AS WELL AS OTHER YEARS OF THE FORD F-350 ARE KNOWN TO HAVE A PROBLEM WITH A FRONT-END SHIMMY OR "DEATH WOBBLE". I HAVE HAD SEVERAL THOUSAND DOLLARS OF WORK DONE TO MY F-350 IN ORDER TO RESOLVE THE DEATH WOBBLE PROBLEM. THE REPAIRS WORK FOR A TIME AND THEN, WITHOUT WARNING, THE DEATH WOBBLE RETURNS. THE FACT THAT THIS CAN OCCUR WITHOUT WARNING, AT HIGH SPEEDS, BY DRIVING OVER A VERY SMALL BUMP IN THE ROAD, MAKES THIS AN EXTRAORDINARILY DANGEROUS PROBLEM. I DON'T THINK I CAN ADEQUATELY DESCRIBE THE EXTREME NATURE OF THE DEATH WOBBLE. THE FRONT-END OF THE TRUCK IS BOUNCING LEFT AND RIGHT, THE ENTIRE VEHICLE IS TWISTING AND ROLLING, THE STEERING WHEEL IS BARELY CONTROLLABLE, ANYTHING LOOSE IN THE PASSENGER COMPARTMENT GOES FLYING AND KEEPING THE VEHICLE IN ITS LANE IS NOT ALWAYS POSSIBLE. REDUCING SPEED AS QUICKLY AS POSSIBLE IS THE ONLY RECOURSE AND THIS POSES A DANGER PARTICULARLY WHEN ON A HEAVILY TRAFFICKED HIGHWAY. THIS PROBLEM HAS BEEN KNOWN ABOUT FOR A LONG TIME AND FORD WILL NOT TAKE ANY RESPONSIBILITY. EVEN AFTER SPENDING THOUSANDS OF DOLLARS ON COMPLETE FRONT-END REBUILDS, AND IMPECCABLE MAINTENANCE, THE PROBLEM WILL SUDDENLY REOCCUR. THE DESIGN OF THIS FRONT-END IS FAULTY AND VEHICLE OWNERS SHOULD NOT CONTINUE TO BE RESPONSIBLE FOR THE COSTS OF MAINTAINING THIS FAULTY DESIGN AND BEING EXPOSED TO GREAT RISK.

Incident: January 4, 2018 · Filed: January 24, 2018

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT HEARD AN ABNORMAL NOISE FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE VEHICLE WENT INTO LIMP MODE. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 212,425. THE VIN WAS NOT AVAILABLE.

Incident: November 1, 2017 · Filed: November 30, 2017

ENGINE DID NOT KICK OUT OF REGIN CAUSEING OVER HEAT

Incident: May 13, 2017 · Filed: May 13, 2017

STEERING GEARBOX FAILED. STEERING FELT VERY LOOSE, PULLED INTO PARKING LOT. STEERING WOULD TURN RIGHT BUT WOULD NOT TURN TO THE LEFT.COULD HEAR A CRUNCHING OR POPPING NOISE WHEN ATTEMPTING TOP TURN LEFT. HAD VEHICLE TOWED TO LOCAL REPAIR SHOP THAT FOUND THE STEERING GEARBOX FAILED INTERNALLY.

Incident: March 7, 2017 · Filed: March 29, 2017

NITTO DURA GRAPPLER 245/75R/17 FRONT LEFT TIRE BLEW CAUSING VEHICLE TO CRASH INTO GUARD RAILING ON INTERSTATE. THE VEHICLE WAS DRIVING ON I-75 SB NEAR MM 181 APPROXIMATELY 72 MPH. I WAS NOT MADE AWARE OF THE RECALL. ON MARCH 6,2015 I HAD ANOTHER TIRE BLOW AND I FILED A NITTO CLAIM NUMBER 804190 (THROUGH THE TIRE DEALERSHIP). I RECEIVED FROM NITTO THE SAME TIRE IN EXCHANGE. EVEN THOUGHT THIS TYPE OF TIRE WAS RECALLED ON SAFERCAR.GOV ON NOVEMBER 4, 2015. WHY WAS IT REPLACED BY NITTO WITH ANOTHER DEFECTIVE TIRE??? NOW MY VEHICLE IS TOTALED!

Incident: December 19, 2016 · Filed: March 9, 2017

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A RANDOM DEATH WOBBLE ASSOCIATED WITH THE STEERING AND SUSPENSION. A DEALER PERFORMED EXTENSIVE REPAIRS, BUT THE CONDITION CONTINUED. THE DEALER AND THE MANUFACTURER FAILED TO PROVIDE A REMEDY. THE VEHICLE WAS UNABLE TO BE SAFELY DRIVEN DUE TO A STRONG VIBRATION FROM THE STEERING, WHICH ALSO CAUSED THE SUSPENSION TO BE UNSTABLE. THE VEHICLE WAS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Incident: November 14, 2016 · Filed: November 26, 2016

I NOTICED A PLUM OF WHITE SMOKE OUT THE TAIL PIPE. THAT INDICATED STEAM, WATER IN THE SYSTEM TO ME. ALL THE GAUGES WERE NORMAL AND I STOPPED THE VEHICLE AND CHECKED THE FLUID LEVELS. NO OBVIOUS PROBLEM. I CALLED MY LOCAL FORD DEALERSHIP AND THEY COULD NOT GET IT IN FOR 36 HOURS. I DROVE IT .4 MILES HOME AND PARKED IT. AT THE APPOINTED TIME I DROVE TO NORTH COUNTRY FORD. IT TOOK THEM ANOTHER DAY TO FIND THE DIESEL MECHANIC WHO COULD WORK ON THE VEHICLE. 24 HOURS LATER I AM TOLD THE ENGINE IS BLOWN; FLUID GOT INTO THE MANIFOLD AND WAS SUCKED INTO THE # 3 CYLINDER. DEPENDING ON THE AMOUNT OF PARTS THAT COULD BE SALVAGED THE COST OF REPLACEMENT COULD EXCEED $ 12,000. THIS VEHICLE HAS 95,000 MILES ON IT. IT HAS HAD TOW OTHER INCIDENTS WITH THE ENGINE AND DRIVE TRAIN: IN DECEMBER OF LAST YEAR, IN PREPARATION FOR A TRIP TO ARIZONA I HAD THE TRANSMISSION SERVICED. ABOUT 1400 MILES LATER THE TRANSMISSION BEGAN TO SLIP WHEN WE ENCOUNTERED ANY HILLS OR MOUNTAINS. I PARKED THE TRAILER AND TOOK THE TUCK TO CASSA FORD. THEY HAD THE TRUCK FOR 4 DAYS AND $ 1600.00 WORTH OF REPAIRS. I ASKED IF ANYTHING DONE AT THE TIME IT WAS SERVICE OR THE DRIVING FROM THE FIRST SIGN OF TROUBLE HAD CAUSED OR EXACERBATED THE PROBLEM. THEY SAID NO, IT WAS A PUMP PROBLEM. IN 2011, IT BEGAN TO BLOW BLACK SMOKE OUT THE TAILPIPE; THE DASH SCREEN INDICATED IT WAS CLEANING THE EXHAUST. WITHIN 5 MINUTES THE ENGINE SPUTTERED AND DIED. I CALLED FORD I WAS TOLD TO WAIT AN HOUR AND TRY TO RESTART THE VEHICLE; GIVE THE ENGINE AN OPPORTUNITY TO 'RE-SET' ITSELF. THAT DIDN'T WORK! A TOW WAS SENT AND THE VEHICLE TOWED TO NELSON FORD DEALER IN FERGUS FALLS, MINNESOTA. IT WAS A FAILED EGR VALVE. THE REPAIR WAS COVERED UNDER WARRANTY.

Incident: September 10, 2016 · Filed: September 12, 2016

TL* THE CONTACT OWNS A 2008 FORD F-350 SD EQUIPPED WITH BF GOODRICH RUGGED TERRAIN T/A TIRES, SIZE: 275/70R18. WHILE DRIVING APPROXIMATELY 50 MPH, THE TIRE TREAD DETACHED FROM THE FRONT DRIVER SIDE TIRE. VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE TREAD SEPARATED FROM THE TIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 91,335 AND THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 3,000.