2017 Ford Explorer Recalls, Ratings & Complaints

Incident: June 7, 2024 · Filed: October 24, 2026

About 3 years and 3 months after a Power Control Module reflash was done in March 2021 under the Customer Satisfaction Program (CSP) 20B27, vehicle was brought to Ford dealership on 06/07/2024 with mileage at 79,730 for multi point inspection due to vehicle runs rough and hard time accelerating. Diagnostic code was P0316. Service tech recommendation was to replace engine for $14,000.00 including parts and labor (declined recommendation). Brought vehicle to another dealership but found no codes. Instead replaced engine motor mounts, sparkplugs, and air filter due to noticeable vibrations. Dealership service tech inspected engine but found no abnormal findings. Went to another Ford dealership on 10/08/2026 to check Code P0299 that appeared on OBD test and for further inspection due to sluggish acceleration from full stop and slows down going uphill. Ford's guidance stated that torque converter failing due to mileage, acceleration/power loss from dead stop. Recommended fix was to replace the transmission for $8,461.03 (declined recommended service). On 10/23/2026, I picked up my vehicle from the dealership. During my return journey from the dealership, I encountered the same sluggish acceleration. A safety hazard that is attributed to a malfunctioning torque converter, a know problem for Ford. Consequently, Ford dispatched CSP 20B27 to assist in safeguarding the transmission converter from overheating. Regrettably, this intervention proved ineffective in mitigating the problem. Ford issued CSP 20N07 to extend warranty coverage of the automatic transmission torque converter for 12 months from RO date which in my case, RO date on CSP 20B27 was 03/19/2021. Despite the 12-month eligibility period not being met, my vehicle should have remained covered. Initially, Ford was aware of a transmission torque issue and was attempting to resolve it through CSP 20B27 and CSP 20N07. Currently, mileage is at 85K miles but I'm hesitant to drive due to safety concerns.

Incident: October 17, 2026 · Filed: October 18, 2026

Vehicle losses power randomly during acceleration, may not stay in park without parking brake on. Shudders badly and shifts harshly decelerates without warning. Nearly has caused collision when merging onto roadways due to lack of control of acceleration, have had to slow onto shoulder multiple times.

Incident: January 19, 2024 · Filed: October 16, 2026

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure) however, the parts to complete the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.

Incident: May 14, 2026 · Filed: October 14, 2026

B-Pillar trim on drivers side detached/broke in half and flew off in traffic. Since then, electrical panel on the driver door messed with the locks. locks no longer work, back tailgate ajar warning is on (even though the tailgate is closed) unable to open to open the tailgate (stuck in lock)

Incident: October 6, 2026 · Filed: October 14, 2026

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, the passenger-side rear tire was low on air pressure. Upon inspecting the vehicle, the contact observed wires exposed on the inner tread of the tire. Additionally, the contact inspected the driver-side rear tire and observed exposed wires sticking out from the inner sidewall. The contact stated that NHTSA Campaign Number: 21V537000 (Suspension) was completed in October 2025. The contact associated the tire failure with the recall. The dealer was notified of the failure by phone. The manufacturer was notified of the failure. The failure mileage was approximately 165,400.

Incident: August 10, 2026 · Filed: October 11, 2026

This is a second complaint for the same vehicle. Complaint number 11770400, filed today, understated the failure history, and I am filing this one so the complete record is in the database. Vehicle: 2017 Ford Explorer Platinum, 3.5L EcoBoost V6, VIN [XXX]. The first turbocharger failure occurred in 2023, at under 110,000 miles, and was repaired at a cost of approximately $2,900. A turbocharger was replaced again in August 2025 at a cost of $2,895. The catalytic converter was replaced in March 2026 at a cost of $1,700. The internal water pump, which sits inside the engine and is driven by the timing chain, was replaced in April 2026 at a cost of $2,350. On [XXX], at about 138,000 miles, the turbochargers failed again, with loss of power and thick white smoke from burning oil, and the vehicle is now undrivable with both turbochargers in question. Major repairs total roughly $9,800 since 2023, with $6,945 of that in the last thirteen months alone. This is a repeating failure of the same components, and it matches the turbocharger oil supply tube defect described in recall 16V925000 for this same engine. Ford limited that recall to 1,352 vehicles, and my VIN falls outside it. Other owners of 2016 and 2017 Explorers report the identical failure outside the recall window, repeat failures after replacement, and turbo failures damaging their catalytic converters. I ask the agency to consider this complete history, and the pattern of identical complaints, in deciding whether to open an investigation, expand the recall, and compensate the affected customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 10, 2026 · Filed: October 11, 2026

Both turbochargers on my 2017 Ford Explorer Platinum with the 3.5L EcoBoost V6 have failed. The first turbocharger failed and was replaced in 2025. On August 10, 2026, at about 138,000 miles, the second turbocharger failed: the vehicle lost power and poured thick white smoke from the exhaust as engine oil burned off, making it undrivable. Sudden power loss and heavy smoke while driving are serious safety hazards. This failure is consistent with the turbocharger oil supply tube defect in NHTSA recall 16V925000 for this same 3.5L EcoBoost engine, but my VIN falls outside that recall's range. I ask NHTSA to investigate turbocharger failures on 2016-2017 Ford Explorer Sport and Platinum models with the 3.5L EcoBoost and consider expanding the recall, and I ask Ford to provide reimbursement or support for these repeated failures.

Incident: October 2, 2026 · Filed: October 5, 2026

Sudden catastrophic engine failure due to coolant mixing. This resulted in a safety issue due to time and location of the event. From online consumer reports this event happens just after 100,000 miles to the 2017 Ford Explorer SUV's and is a KNOWN event that Ford has NOT disclosed. Regular maintenance can NOT prevent this event and stopping the use of the vehicle only helps if it is immediate and the problem known. That Ford hasn't disclosed this possibility of failure nor suggested preventative measures is a safety concern.

Incident: October 2, 2026 · Filed: October 4, 2026

Engine hesitated, kept hesitating/slowing down until 2017 Ford Explorer just stopped. Towed SUV to Koons Ford Service Center. Charged $200 for diagnostic assessment. Informed that oil/coolant mix due to water pump failure. Diagnose: replace Engine Long Block and Hardware and thermostat. Costing $11,195.04 for job. Never mentioned what happened to cause this. At another dealership, mechanic told us of the NHTSA Recall 25V685000 regarding this malfunction. Note: Koons Ford has had a "history" with this SUV, only working on recalls when we push the issue. Also, requiring a $200 diagnostic charge each time the vehicle is seen. This location is where we bought the vehicle.

Incident: June 1, 2026 · Filed: October 3, 2026

1. Rubber is falling off the windshield and hood. This is a ford issue and they refuse to repair this. It appears to be heat related and the car was sold in an area with high summer temperatures. It is cracked and peeling at the bottom of the windshield causing rain and leaves to seep into the engine area. This could start a fire hazard if it's not repaired. Quoted me 12k to fix (more than the cost of getting another car that is less dangerous). 2. Inside auto same issue is happening with the ford installed dashcover. It is peeling back and in order to repair, they must take EVERYTHING out of the inside to repair and yes $$$$ close to 20k. Again this is a ford issue not a user issue. The dash cover is black and underneath it is white. Driver is unable to fix on own. Both of these are Ford defects that Ford should step up and repair.