NHTSA vehicle safety data

2001 Ford Expedition Recalls, Ratings & Complaints

The 2001 Ford Expedition has 10 NHTSA recall campaigns and 578 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2001 Ford Expedition, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Ford Expedition owner complaints

Owners have filed 578 complaints with NHTSA about the 2001 Ford Expedition, describing incidents dated October 5, 2000 to August 24, 2026.

Most-cited components

Engine 137 complaints
Electrical System 118 complaints
Vehicle Speed Control 101 complaints
Tires 62 complaints
Visibility/Wiper 44 complaints
Power Train 40 complaints

Of the 578 complaints on file, 38 report a crash and 95 a fire; across all 578 complaints, owners report 63 injuries and 5 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11761739 · Filed September 2, 2026
THe component was the speed control deactivation switch Manufacturer Recall Number 05S28 NHTSA Recall Number05V017000 Recall Status Recall Incomplete. It is unknown if the part is available for inspection but the vehicle is. The fire occurred while driving and left me stranded on the side of the…
ODI #11713268 · Filed January 25, 2026
Air Bags did not deploy Impact directly to drivers side of vehicle the other car was going 55 MPH caused me the driver to hit my head on the window hard. I was informed the air bags should have deployed by officer on site.
ODI #11586111 · Filed April 30, 2024
Front brake hose metal crimp completely rusted causing brake hose separation and failure. Design has rubber boot over crimp which actually retains moisture over many years. Boot may be intended to reduce stress at joint of metal to hose but actually enhanced failure mode. Drivers side came apart…

Read all 578 complaints

Owner-reported

2001 Ford Expedition mileage at failure

374 of the 578 complaints on file for the 2001 Ford Expedition give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 110,000 miles	Middle half 80,000–140,000 miles	Based on 114 complaints
Electrical System	Median 85,000 miles	Middle half 65,000–110,000 miles	Based on 92 complaints
Vehicle Speed Control	Median 100,000 miles	Middle half 60,000–135,000 miles	Based on 61 complaints
Visibility/Wiper	Median 80,000 miles	Middle half 55,000–100,000 miles	Based on 32 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Ford Expedition in 6 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA05-015: WINDSHIELD LEAK CAUSES ELECTRIC FAILURES
Closed December 6, 2006
Engineering Analysis EA05-005: ENGINE COMPARTMENT FIRES
Closed August 2, 2006
- Recall 05V-388
- Recall 06V-286
- Recall 07V-078
- Recall 07V-336
- Recall 07V-347
- Recall 07V-488
- and 1 more on the investigation page
Defect Petition DP05-005: SPARK PLUG EJECTION FROM CYLINDER HEAD
Closed January 4, 2006
Preliminary Evaluation PE05-033: ELECTRICAL SYSTEM FAILURE
Closed October 13, 2005
Engineering Analysis EA05-004: FRONT SEAT BELT BUCKLE ASSEMBLY
Closed July 6, 2005

1 more NHTSA investigation

Recall Query RQ04-011: FRONT SEAT BELT BUCKLE ASSEMBLY
Closed February 17, 2005

Open and recently closed NHTSA defect investigations

FMVSS 108/AFTERMARKET HEADLAMP ASSEMBLIES

NHTSA #06E067000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 1, 2006 · MAXZONE AUTO PARTS CORPORATION

Potentially affected: 19,413 vehicles

Owners notified July 28, 2006

Defect description

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E060000 · Exterior Lighting · NHTSA notice

Reported June 29, 2006 · AAI MOTORSPORTS USA, LLC

Potentially affected: 87,745 vehicles

Owners notified August 1, 2006

Defect description

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Manufacturer remedy

AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Notes

THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL LEAK/FIRE

NHTSA #06E056000 · Fuel System, Gasoline · NHTSA notice

Reported June 13, 2006 · UFI FILTERS USA

Potentially affected: 58,640 vehicles

Owners notified August 4, 2006

Defect description

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Safety consequence

FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Notes

THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPEED CONTROL DEACTIVATION SWITCH

NHTSA #05V388000 · Vehicle Speed Control · NHTSA notice

Reported September 7, 2005 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 05S28 · Owners notified September 12, 2005 · Vehicles built through August 20, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Safety consequence

A FIRE AT THE SWITCH COULD OCCUR.

Manufacturer remedy

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

Notes

FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SOUTHERN COMFORT/RUNNING BOARDS

NHTSA #03V094000 · Structure · NHTSA notice

Reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS

Potentially affected: 3,674 vehicles

Owners notified March 7, 2003 · Vehicles built August 1, 2000 – March 3, 2003 (per NHTSA)

Defect description

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Safety consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FORD/WINDSHIELD WIPER MOTOR COVER

NHTSA #01V258000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported August 8, 2001 · FORD MOTOR COMPANY

Potentially affected: 1,083,000 vehicles

Ford campaign 01S24 · Owners notified August 20, 2001

Defect description

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Safety consequence

LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FORD/TRW SEAT BELT BUCKLES

NHTSA #01V227001 · Seat Belts — Front — Buckle Assembly · NHTSA notice

Reported July 16, 2001 · FORD MOTOR COMPANY

Potentially affected: 1,400,000 vehicles

Ford campaign 01S21 · Owners notified July 25, 2001 · Vehicles built April 11, 2000 – May 31, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.

Safety consequence

IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.

Manufacturer remedy

DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Tires — Tread/Belt

NHTSA #01X001000 · NHTSA notice

Reported May 22, 2001 · FORD MOTOR COMPANY

Potentially affected: 13,000,000 vehicles

Ford campaign 01B77 · Owners notified June 4, 2001

Defect description

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Safety consequence

SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

Manufacturer remedy

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

FORD/AIR BAG MODULE

NHTSA #01V082000 · Air Bags — Frontal · NHTSA notice

Reported March 12, 2001 · FORD MOTOR COMPANY

Potentially affected: 268 vehicles

Ford campaign 01S10 · Owners notified March 19, 2001 · Vehicles built February 26, 2001 – February 28, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.

Manufacturer remedy

DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FORD/FMVSS 225/CHILD RESTRAINT ANCHOR

NHTSA #00V396000 · Equipment — Other — Owners/Service/Other Manual · NHTSA notice

Reported November 28, 2000 · FORD MOTOR COMPANY

Potentially affected: 495,000 vehicles

Ford campaign 00L11 · Owners notified March 6, 2001 · Vehicles built March 30, 1999 – September 21, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.

Safety consequence

IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.

Notes

OWNER NOTIFICATION BEGAN MARCH 6, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Ford Expedition 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

6 investigations

578 owner complaints have been filed with NHTSA for the 2001 Ford Expedition.

Electrical System; Vehicle Speed Control; Service Brakes

ODI #11761739

Fire

Incident: August 24, 2026 · Filed: September 2, 2026

THe component was the speed control deactivation switch Manufacturer Recall Number 05S28 NHTSA Recall Number05V017000 Recall Status Recall Incomplete. It is unknown if the part is available for inspection but the vehicle is. The fire occurred while driving and left me stranded on the side of the road with five dogs, 2 hours away from home with no way of getting back. I had to find a hotel that allowed pets which was expensive and have been in said hotel starting August 25 through today, September 2. We are paid until tomorrow and I have exhausted all funds and resources. We will be without food, shelter, or teransportation. Yes the problemhas been confirmed by Santa Monica Lincoln Ford Dealership. The mechanic liason is Art Albrandt and can be reached at [XXX]. The vehicle has not been inspected by anyone other than the mechanics at thew Ford Dealership No there was no warning prior to the incident. The vehicle was running just fine. ZThe vehicle caught fire en route to Los Angeles frim San Bernardino County. AAA came and towed the vehicle to a friend's house because it was very late, and towed to the dealership the following morning. I found the nearest pet friendly hotel because I had no way to transport my animals any distance. I waited two days before being told that a part that was needed was discontinuerd, and they would have to find it at a pick a part over the weekend. At this point I had exhaiusted all of my financial resources and had to borrow funds to keep us housed. That following monday I was toild that the problem, specifically the part, that was related to the recall had been fixed however the vehicle still did not run and because it was so old they did not have the equipment to further diagnose it and referred us to a nearby mechanic who could help us. So far we have been referred to 4 mechanics and none are willing to even look at it. I filed a complaint with Ford, case number [XXX]. I explained that the recg INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Air Bags

ODI #11713268

Crash 1 injury

Incident: December 11, 2025 · Filed: January 25, 2026

Air Bags did not deploy Impact directly to drivers side of vehicle the other car was going 55 MPH caused me the driver to hit my head on the window hard. I was informed the air bags should have deployed by officer on site.

Service Brakes

ODI #11586111

Incident: April 27, 2024 · Filed: April 30, 2024

Front brake hose metal crimp completely rusted causing brake hose separation and failure. Design has rubber boot over crimp which actually retains moisture over many years. Boot may be intended to reduce stress at joint of metal to hose but actually enhanced failure mode. Drivers side came apart after minor bump during service, have photos of passenger side still intact but clearly fragile.

Seat Belts

ODI #11582277

Incident: April 10, 2024 · Filed: April 11, 2024

Driver seatbelt- Randomly releases from buckle when driving. Happened about 3-4 times already.

Structure

ODI #11531805

Incident: June 1, 2022 · Filed: July 12, 2023

On the second row seat, passenger side door will not open using the door handle with the child safety switch in lock or unlock position. It will open from the outside handle. This is a safety concern. In case accident happen or fire in the vehicle occurs, the second and third row passengers can not get out of the vehicle fast enough for their safety. This has not work for over a year now.

Electrical System

ODI #11503217

Fire

Incident: November 20, 2022 · Filed: January 23, 2023

Vehical burst into flames seems on passenger side under the hood...Had been parked all day. No one around or injured. Vehical is a total loss.

Power Train; Vehicle Speed Control; Unknown or Other

ODI #11482139

Crash 2 injuries

Incident: August 29, 2022 · Filed: August 31, 2022

I gave a friend a ride to Wal mart in my 2001 Expedition to buy some power steering fluid, luckily I parked over by the automotive section. I turned it off and waited in vehicle till he returned, about 7 or 8 minutes. I started the engine, grabbed the brake and dropped it in reverse when engine revved sending us backwards completely out of control with both feet on the brakes, spinning rear wheels and I turned ignition key off as quick as possible but violently slammed into a truck semitrailer only, parked alongside Wal mart tire shop. Completely totalled out the entire rear passenger liftback, taillights, tailgate, rear hatch window, left rear luever window, left tailpipe, tow hitch package and rear bumper. With only min. coverage, I'm now w/o a vehicle after completely replacing entire front and rear suspension, steering and tires plus alignment less than 6 months prior, with 275000 miles. Thank you very much Ford Motor Co. This was NOT an issue of driver error !.. I WILL find a way to legally hold you responsible for my loss, making FORD liable for repairing or replacing my vehicle ! This happened on Aug 29th, 2022 approx. 4pm at Wal mart property, in Ukiah, CA. 95482

Electrical System

ODI #11366759

Fire

Incident: October 24, 2020 · Filed: October 27, 2020

VEHICLE CAUGHT ON FIRE DUE TO AN INCORRECTLY INSTALLED HEAD LIGHT DUE TO A CRACKED PLUG ASSEMBLY. VEHICLE WAS IN A FAST-FOOD DRIVE THROUGH WHEN THE SMOKE AND SUBSEQUENT FLAMES WERE SEEN. DUE TO AGE OF THE VEHICLE THE TASK OF CHANGING THE LIGHT BULB WAS FARMED OUT TO LOCAL OIL CHANGE SHOP. WHILE CHANGING THE PLACING THE NEW BULB INTO THE PLUG ASSEMBLY THE THIN PLASTIC BROKE KEEPING THE BULB FROM SEATING PROPERLY. TESTED OKAY ON REASSEMBLY BUT ONCE NIGHT CAME THE LIGHT WAS ON FOR ONLY 15 MINUTES AND IGNITED THE INNER HEAD LAMP ASSEMBLY AND SUBSEQUENTLY MORE OF THE ENGINE COMPARTMENT. FORTUNATELY, THE FAST-FOOD RESTAURANT CAME OUT WITH AN EXTINGUISHER AND PUT OUT THE FIRE. THANKFULLY, NO ONE WAS HURT HOWEVER, HAD THE FIRE OCCURRED ON THE HIGHWAY, IN A PARKING LOT UNATTENDED, OR IN THE HOMES GARAGE, THE OUTCOME WOULD HAVE BEEN FAR WORSE.

Seat Belts; Vehicle Speed Control; Fuel/Propulsion System

ODI #11349753

Incident: August 16, 2020 · Filed: August 17, 2020

MY VEHICLE YEAR,MAKE,AND MODEL HAS MULTIPLE MANUFACTURER RECALLS PERTAINING TO MY SPECIFIC VEHICLES VIN NUMBER. I HAVE 0 UNREPAIRED RECALLS THAT HAVE NOT BEEN ASSESSED AND HAS HAD ZERO COMPONENTS REPLACED UNDER RECALLS FOR SPECIFIC COMPONENTS. EACH AND EVERY RECALLED COMPONENTS ASSOCIATED WITH MY VEHICLES YEAR, MAKE, AND MODEL PERTAINING TO MY VEHICLES VIN NUMBER ARE A SAFETY RISK AT FAULT AND ANY PROBLEMS CREATE UNSAFE CONDITIONS FOR OPERATION OF VEHICLE ON THE ROAD. MY ASSESSMENT OF MY VEHICLES SAFETY RISK IS HIGH DUE TO THE 0 UNREPAIRED RECALLS MY VEHICLE HAS NOT BEEN REPLACED WITH NEW COMPONENTS TO AVOID THESE SAFETY RISKS FROM COMPONENT FAILURE.

Engine

ODI #11337782

Incident: June 27, 2020 · Filed: July 6, 2020

GOING TO MICHIGAN FROM TENNESSEE, DRIVING ON THE EXPRESSWAY WHAT'S MY FORD EXPEDITION TRIDENT MOTOR V8 HEARD A POPPING SOUND AND ALMOST GOT IN AN ACCIDENT AND FOUND OUT ONCE AGAIN THE SPARKPLUG BLEW OUT OF THE MOTOR AGAIN WITH MY FAMILY IN THE VEHICLEE IT'S A 2001 AND I THINK YOUR COMPANY SHOULD PAY FOR THE REPAIRS.

Other Ford Expedition model years

Check your 2001 Ford Expedition VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford Expedition at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN