NHTSA vehicle safety data

2006 Ford Expedition Recalls, Ratings & Complaints

The 2006 Ford Expedition has 6 NHTSA recall campaigns and 299 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2006 Ford Expedition, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Ford Expedition owner complaints

Owners have filed 299 complaints with NHTSA about the 2006 Ford Expedition, describing incidents dated October 24, 2005 to January 8, 2024.

Most-cited components

Engine 162 complaints
Electrical System 32 complaints
Vehicle Speed Control 29 complaints
Fuel/Propulsion System 24 complaints
Power Train 22 complaints
Structure 19 complaints

Of the 299 complaints on file, 19 report a crash and 6 a fire; across all 299 complaints, owners report 24 injuries and 3 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11564296 · Filed January 8, 2024
the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the…
ODI #11539771 · Filed August 21, 2023
The contact owns a 2006 Ford Expedition. The contact stated that while driving 35 MPH, the contact stated that there were exhaust fumes inside the vehicle. The engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic and confirmed the failure was a defective…
ODI #11518263 · Filed April 21, 2023
The contact owns a 2006 Ford Expedition. The contact stated that while driving at a low rate of speed, the vehicle would independently accelerate upon depression of the accelerator pedal without warning. During a recent failure, the contact crashed into a fence as part of the fence had become wedged…

Read all 299 complaints

Owner-reported

2006 Ford Expedition mileage at failure

262 of the 299 complaints on file for the 2006 Ford Expedition give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 85,000 miles	Middle half 65,000–115,000 miles	Based on 147 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Ford Expedition in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE08-070: STEEL WHEEL FRACTURE
Closed April 15, 2009

Open and recently closed NHTSA defect investigations

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E064000 · Exterior Lighting · NHTSA notice

Reported July 17, 2006 · TRADESONIC

Potentially affected: 4,029 vehicles

Defect description

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL LEAK/FIRE

NHTSA #06E056000 · Fuel System, Gasoline · NHTSA notice

Reported June 13, 2006 · UFI FILTERS USA

Potentially affected: 58,640 vehicles

Owners notified August 4, 2006

Defect description

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Safety consequence

FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Notes

THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/HEADLAMP/AMBER SIDE REFLEX REFLECTOR

NHTSA #06E023000 · Exterior Lighting — Headlights · NHTSA notice

Reported March 13, 2006 · ANZO USA, INC.

Potentially affected: 292,000 vehicles

Owners notified May 9, 2006

Defect description

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WIPER MOTOR GREASE

NHTSA #05V520000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported November 9, 2005 · FORD MOTOR COMPANY

Potentially affected: 199,942 vehicles

Ford campaign 05S40 · Owners notified November 22, 2005 · Vehicles built September 12, 2005 – October 17, 2005 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Safety consequence

AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Manufacturer remedy

DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Notes

FORD RECALL NO. 05S40. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

TIRES

NHTSA #05V310000 · Tires — Tread/Belt · NHTSA notice

Reported July 6, 2005 · FORD MOTOR COMPANY

Potentially affected: 10,061 vehicles

Ford campaign 05S35 · Owners notified July 13, 2005 · Vehicles built May 2, 2005 – May 23, 2005 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER'S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION.

Safety consequence

OVER TIME, THE DAMAGE MAY BE SUFFICIENT TO ALLOW BELT CORROSION ULTIMATELY LEADING TO A TREAD SEPARATION, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT ALL FOUR TIRES (TO ENSURE INSPECTION OF THE LEFT HAND SIDE TIRES THAT MAY HAVE BEEN ROTATED TO THE OTHER SIDE OF THE VEHICLE) FOR TIRE TREAD DAMAGE AND, IF NECESSARY, REPLACE THE DAMAGED TIRE. THE RECALL BEGAN ON JULY 13, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 05S35.PLEASE NOTE THAT THIS PROGRAM WILL EXPIRE ON DECEMBER 31, 2005.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Ford Expedition 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

1 investigation

299 owner complaints have been filed with NHTSA for the 2006 Ford Expedition.

Suspension; Engine; Fuel/Propulsion System

ODI #11564296

Incident: January 8, 2024 · Filed: January 8, 2024

the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power on the driver side and throws the timing belt off which causes the loud rattle coming from the engine. when reaching the speed of 40-45 mph the truck begins to shake. recently in november 2023, when fueling up with gas , the truck began to shake and not respond. when accelerating, the truck takes off very slowly and the gears dont kick in on time. when the gas light comes on , the truck begins to function well. but as soon as i put gas again. it feels like the truck is going to fall apart. the driver door gets stuck when trying to open from the inside. the back door on the left does not open from the outside. the gear handle can be moved up and down while the truck is not turned on. please help!!

Fuel System, Gasoline

ODI #11539771

Incident: October 9, 2022 · Filed: August 21, 2023

The contact owns a 2006 Ford Expedition. The contact stated that while driving 35 MPH, the contact stated that there were exhaust fumes inside the vehicle. The engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic and confirmed the failure was a defective charcoal canister for the evac system. The vehicle had not been repaired. The manufacturer was made aware of the failure however, the part was not available. The failure mileage was approximately 70,000.

Power Train; Electrical System; Air Bags

ODI #11518263

Crash 1 injury

Incident: April 20, 2023 · Filed: April 21, 2023

The contact owns a 2006 Ford Expedition. The contact stated that while driving at a low rate of speed, the vehicle would independently accelerate upon depression of the accelerator pedal without warning. During a recent failure, the contact crashed into a fence as part of the fence had become wedged underneath the vehicle. After placing the vehicle into park and exiting the vehicle, the wheels continued to move. The air bags did not deploy upon impact. Despite minor soreness to his neck, no medial attention was required. A police report was not filed. Despite the failure, the contact managed to restart the vehicle and safely to his destination. The fence sustained severe damage as a result of the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 220,000.

Engine

ODI #11490173

Incident: February 1, 2020 · Filed: October 20, 2022

The contact owns a 2006 Ford Expedition. The contact stated while driving 55 MPH, the vehicle was driving sluggishly. The contact stated that the check engine warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the ignition coil, the throttle body sensor (TBS) sensor, and the timing chain needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired at the dealer. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated on another occasion the vehicle failed to start. The vehicle was not drivable. The failure mileage was approximately 130,000.

Seat Belts

ODI #11443423

Fire 1 injury

Incident: December 10, 2021 · Filed: December 11, 2021

While driving yesterday i heard a pop. The 4th coil pack literally blew out from its spot. I have now had 3 coil packs blow out at random causing the holes that the bolt straps the coil pack to the spark plug to strip out. I have a transmission leak that will not stop and I've taken it in multiple times for repairs and it still is leaking. Since getting this vehicle i noticed at the electrical issue where everything including my headlights will shut off and then pop back on while I'm driving. My seat belt will not open so i can buckle and I'm now getting frustrated because I've spent a lot of money on this only to realize has had the same issue with previous owners and they for some reason were too embarrassed to report it but I'm not and I'm sick of dumping money into this damb thing!

Engine

ODI #11300564

Incident: October 1, 2019 · Filed: January 20, 2020

UPON RECEIVING TUNE UP THE SPARK PLUGS BROKE APART.AFTER GETTING THEM OUT CYL#1 WOULD NOT HOLD SPARK PLUG,CAUSED ME TO SPEND MORE MONEY TO GET PROBLEM FIXED.BUT THE SHOPS WILL NOT GUARANTEE THE WORK THAT IS NEEDED.THEY ALL SAID IT WAS A FACTORY ISSUE.THE TRUCK WAS STATIONARY AS WELL.

Electrical System; Engine

ODI #11232007

Incident: July 1, 2019 · Filed: July 15, 2019

TL* THE CONTACT CALLED ON BEHALF OF THE OWNER OF A 2006 FORD EXPEDITION. WHEN THE VEHICLE WAS STARTED, THERE WAS AN ODOR OF ANTIFREEZE IN THE VEHICLE. ADDITIONALLY, THE TEMPERATURE GAUGE AND CYLINDER HEAD TEMPERATURE SWITCH BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INTAKE MANIFOLD AND CYLINDER HEAD TEMPERATURE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

Service Brakes

ODI #11207898

Crash 1 injury

Incident: May 14, 2019 · Filed: May 15, 2019

TRAVELING ON OLD ADOBE RD IN PETALUMA, CA AT APPROX. 25-30 MPH, WENT OVER INCLINE AND SAW TRAFFIC WAS STOPPED. PRESSED HARD ON BRAKE PEDAL AND VEHICLE SLOWED BUT DID NOT STOP. RESULTED IN A 3 CAR ACCIDENT

Visibility/Wiper

ODI #11203186

Incident: April 22, 2019 · Filed: April 23, 2019

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE FRONT PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO INJURIES. THE CONTACT STATED THAT THE WINDOW WAS NOT STRUCK BY DEBRIS OR A FOREIGN OBJECT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

Unknown or Other

ODI #11153128

Fire

Incident: November 20, 2018 · Filed: November 21, 2018

THE VEHICLE EXPLODED IN OUR DRIVEWAY. IT HAD NOT BEEN DRIVEN OR TURNED ON IN ALMOST 2 WEEKS. IT WAS LOCKED. THIS CAUGHT ONE OTHER CAR ON FIRE AND TO EXPLODED AND ANOTHER TO GET BODY MELT DOWN ON ONE SIDE.

Other Ford Expedition model years

Check your 2006 Ford Expedition VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford Expedition at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN