2016 Chevrolet Silverado 3500 Recalls & Complaints

Incident: September 2, 2026 · Filed: September 3, 2026

Leak is causing black mold, creating an unsafe environment inside the vehicle where child is expected and required by law to be buckled right above a black mold infected carpet and behind headrest

Incident: July 8, 2025 · Filed: February 20, 2026

As I was driving I heard a loud slam under my hood and when I checked the clutch for my AC compressor was gone. The AC no longer works and I have no idea where the parts went. When I looked this up it appears to be a common issue.

Incident: January 26, 2026 · Filed: February 20, 2026

I have now been in 2 serious accidents that resulted in all other vehicles deploying airbags and being totalled, but mine have never deployed and it has been suggested there may be a recall for this

Incident: June 25, 2025 · Filed: June 28, 2025

Power steering intermittently goes out. Mostly when it's hot out, slow speeds, and cornering.

Incident: January 18, 2025 · Filed: March 17, 2025

While connected to a RV which has onboard batteries, the truck's brake controller disables the braking system if the batteries on the RV fluctuate in voltage. The truck will give an alert advising "Trailer Brakes Disabled." This has occurred multiple times while pulling my RV which weighs 16,000 pounds, making it unsafe and hard to stop using only the truck's brakes. It happened while traveling through Atlanta, GA and once in Nashville, TN. Chevrolet has at least one TSB on this for similar 2022-2024 2500 and 3500 trucks. This has been a widely reported problem on several RV forums. The truck brake controller will work again if the engine is shut off and turned back on or the trailer is unplugged and re-plugged in the truck. This problem occurred approximately 10 times on my trip from Missouri to Florida in January and about the same number of times when returning to Missouri at the end of February.

Incident: June 9, 2024 · Filed: January 7, 2025

On [XXX] while traveling down [XXX] in VA I experienced a catastrophic Bosch CP4 Fuel Pump Failure. Vehicle was towed to Marion Auto Group in Marion, VA and kept for 5 weeks to repair fuel system. We paid $6,500 once we were told the repairs were complete and picked the vehicle up. Within 50 miles of driving, the fuel system error lights/codes began again and the service engine light came on. We called Marion Auto Group, they told us it was warranted for 24 months for parts and labor. We could take it to any Chevy dealer and have it looked at. We made an appt with our local Chevy dealer, Joe Bowman Chevrolet in Harrisonburg, VA. They kept the vehicle for approximately 5-6 weeks. Told us daily about the faulty repairs that Marion Auto Group had made, corrected the faulty repairs, with pictures, videos and even a coffee cup full of bad bolts and weld pieces that they replaced. Marion Auto Group agreed to pay Joe Bowman Chevrolet $5,500 in reimbursement for the work they performed to correct Marion Auto Groups work. When I got in the truck to bring it home and started it, the service engine light came on. They pulled it back in the shop, ran a diagnostic and said we needed some type of sensor ($900) so we scheduled an appt to have that done. Then we took the truck to Tennessee, fuel system failure lights and codes immediately came on. When I stopped to eat, it wouldn't start back. Took the truck to Tarr Chevrolet in Jefferson City TN, they diagnosed it as needing a new fuel line (from prev faulty fuel system) changed it ($1,700) and we headed back home with all the fuel system warning lights flashing again. Took it back to Joe Bowman Chevrolet in Harrisonburg where it's been sitting for over 7 weeks while GM decides if they should cover the entire new fuel system that it needs again ($19,000) because it's never been properly repaired since the initial catastrophic failure. Almost 7 months and $14,,600 in previous repairs.......Please HELP US! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 25, 2024 · Filed: November 7, 2024

I was driving the truck and the dashboard said fuel filter at 0 % entering low power mode. The truck did not accelerate at all and stopped running within 5 minutes . The repair cost almost 9000.00 for a 100.00 fuel filter.

Incident: May 11, 2024 · Filed: May 11, 2024

The steering is very loose. There are multiple complaints about this. I owned a 2017 GMC 2500 before this and had the same issue. I have not brought this into a shop because I’m not looking forward to the diagnosis & cost. This has been an ongoing issue for years. GM needs to recall something in the steering box. Source: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 11, 2023 · Filed: October 11, 2023

Probable High Pressure Fuel Pump (CP4) failure resulting in the vehicle stalling without warning. This event has not yet occurred, however due to the high number of vehicles involved in the Stellantis recall which are using the same CP4 pumps which are known to fail, I am scared to drive my truck as the CP4 pump may fail at any time. I have spoken to MANY other GM truck owners who have experienced this failure and it has cost them tens of thousands of dollars. Please open a recall for the CP4 High Pressure Fuel Pump for 2011-2016 GM trucks using this HPFP. Thank you,

Incident: June 27, 2023 · Filed: July 25, 2023

On June 27 2023 we we driving on a two lane highway pulling our travel trailer. We had driven 5 hrs the previous day parked unhooked and drove around the area with no issues. The following morning we left an were just entering the highway speed zone when the truck abruptly crossed the centreline. I managed to correct and stop n the shoulder and noticed 6-8” of play in the steering wheel. I dropped the trailer and slowly drove back to the town to try and see what the issue was. The vehicle continued to move left and right with no input from me. It was determined that the steering box was leaking and when steering was input a thumping could be felt in the tires but not in the steering wheel. The shop determined the box sector shaft adjustment shaft was nearly backed out completely. I contacted the dealership that services my truck about what should be done and they stated “replace the steering box” which we did. Had there been on coming traffic this would have been a fatal or serious collision and it is doubtful this defect would have surfaced as a causal factor.