try.vin
Log in

NHTSA vehicle safety data

2012 Chevrolet Silverado 3500 Recalls & Complaints

The 2012 Chevrolet Silverado 3500 has 4 NHTSA recall campaigns and 23 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2012 Chevrolet Silverado 3500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2012 Chevrolet Silverado 3500 owner complaints

Owners have filed 23 complaints with NHTSA about the 2012 Chevrolet Silverado 3500, describing incidents dated October 17, 2012 to August 7, 2025.

Most-cited components

  • Fuel/Propulsion System 6 complaints
  • Tires 6 complaints
  • Air Bags 4 complaints
  • Engine 4 complaints
  • Steering 3 complaints
  • Electrical System 2 complaints

Of the 23 complaints on file, 1 reports a crash; across all 23 complaints, owners report 1 death (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11704782 · Filed

    Tire - 265/70 r18 Cooper Could have been a very bad accident. Tire blew out. The tire was inspected by Goodyear PCA-Visual only -recvd below response after several requests. All Internal Goodyear visual Inspection procedures & methodologies are confidential and/or proprietary information of The…

  • ODI #11691934 · Filed

    TIRE - 265/70 R18 Failure: Tire caused vehicle damage - Tire is at Goodyear Tire - Akron, Ohio Pulled off the road to change tire - was helped by someone that saw incident and lived close by. Yes - Filed a claim with insurance -see attached-and Property Damage Claim Team - Goodyear Tire- PDCT re…

  • ODI #11612575 · Filed

    The contact owns a 2012 Chevrolet Silverado 3500. The contact stated that the vehicle would be low or completely out of fuel quicker than expected. The contact stated that while attempting to refuel, the contact was unable to fill the rear tank due to the tank being full of fuel. The vehicle had…

Read all 23 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2012 Chevrolet Silverado 3500 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V054000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 1,778,128 vehicles

Repair completion: 63.26% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328800 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V051000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 284,645 vehicles

Repair completion: 54.46% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328770 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328770.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #18V267000 · Equipment · NHTSA notice

Reported April 26, 2018 · General Motors LLC

Potentially affected: 6,154 vehicles

Repair completion: 14.23% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 18146 · Owners notified June 11, 2018 · Vehicles built October 13, 2008 – November 6, 2013 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Front Fuel Tank May Overfill and Cause Fuel Leak

NHTSA #17V664000 · Fuel System, Gasoline — Storage — Auxillary Tank · NHTSA notice

Reported October 19, 2017 · General Motors LLC

Potentially affected: 35,292 vehicles

Repair completion: 54.69% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 17399 · Owners notified December 11, 2017 · Vehicles built May 24, 2010 – September 30, 2015 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain 2011-2015 Chevrolet Silverado 3500 and GMC Sierra 3500 trucks equipped with dual fuel tanks. The low fuel level sensor for the front tank may stick causing the rear tank to overfill the front tank.

Safety consequence

If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

Manufacturer remedy

GM has notified owners, and dealers will replace the rear tank fuel pump or update the fuel-level sensor software, as well as inspect the front tank, replacing it as necessary, free of charge. The recall began December 11, 2017. Owners may contact GM customer service for Chevrolet 1-800-222-1020 or for GMC customer service at 1-800-462-8782. GM's number for this recall is 17399.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Other Chevrolet Silverado 3500 model years

Check your 2012 Chevrolet Silverado 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Silverado 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN