NHTSA vehicle safety data

2007 Chevrolet Silverado 3500 Recalls & Complaints

The 2007 Chevrolet Silverado 3500 has 5 NHTSA recall campaigns and 39 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2007 Chevrolet Silverado 3500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Chevrolet Silverado 3500 owner complaints

Owners have filed 39 complaints with NHTSA about the 2007 Chevrolet Silverado 3500, describing incidents dated July 14, 2007 to June 2, 2026.

Most-cited components

Air Bags 12 complaints
Engine 8 complaints
Fuel/Propulsion System 5 complaints
Service Brakes 4 complaints
Steering 4 complaints
Power Train 3 complaints

Of the 39 complaints on file, 1 reports a crash and 2 a fire; across all 39 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11741817 · Filed June 3, 2026
The contact owned a 2007 Chevrolet Silverado. The contact stated that while driving at 65 MPH, the contact noticed smoking coming from the under the front vehicle. The contact mention he pulled over the right side of the road, turned the vehicle off and then exited the vehicle and opened the hood of…
ODI #11631074 · Filed December 16, 2024
I purchased my new 2007 Chevy duramax diesel with an already installed fabtech lift kit. My pitman arm has snapped 3 times since I purchased my truck leaving me with complete steering loss. I have had to replace all steering components several times. My truck is unsafe due to a fabtech lift kit that…
ODI #11539906 · Filed August 21, 2023
Rattling noise in intermediate shaft of steering column and key tumbler is sticky

Read all 39 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2007 Chevrolet Silverado 3500 in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA08-010: NON-CRASH ENGINE COMPARTMENT FIRES
Closed September 8, 2008
- Recall 08V-441
Preliminary Evaluation PE08-010: NON-CRASH ENGINE COMPARTMENT FIRES
Closed June 12, 2008

Open and recently closed NHTSA defect investigations

Passenger Air Bag Inflators May Explode

NHTSA #20V011000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 10, 2020 · General Motors LLC

Potentially affected: 699 vehicles

Repair completion: 48.14% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N192290990 · Owners notified February 11, 2020 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors LLC (GM) is recalling certain 2007-2008 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the front passenger or other occupants resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflators, free of charge. The recall began February 11, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-866-522-9559. GM's number for this recall is N192290990.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Side Front Air Bag Inflator may Rupture

NHTSA #15V324000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · General Motors LLC

Potentially affected: 330,198 vehicles

Repair completion: 75.6% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 15438 and 15817 · Owners notified July 27, 2015 · Vehicles built November 28, 2006 – July 31, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors LLC (GM) is recalling certain model year 2007-2008 Chevrolet Silverado 2500HD and 3500HD trucks manufactured November 28, 2006, to August 29, 2008, and 2007-2008 GMC Sierra 2500HD and 3500HD trucks manufactured November 27, 2006, to August 29, 2008. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.

Safety consequence

In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on July 27, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's numbers for this recall are 15438 and 15817.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Melted Fusible Link may Result in Fire

NHTSA #14V407000 · Electrical System · NHTSA notice

Reported July 2, 2014 · General Motors LLC

Potentially affected: 9,371 vehicles

Repair completion: 32.95% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14260 · Owners notified August 29, 2014 · Vehicles built January 22, 2007 – June 20, 2007 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2007-2011 Chevrolet Silverado HD 2500/3500 trucks manufactured January 18, 2007, to June 22, 2011, and GMC Sierra HD 2500/3500 trucks manufactured January 22, 2007, to June 21, 2011, and equipped with an auxiliary battery. Owners may unknowingly draw too much current through the vehicle's trailer harness resulting in the melting of fusible link for the auxiliary battery.

Safety consequence

If the fusible link melts it may come into contact with adjacent components, damage the electrical center cover, the nearby wiring harness conduit and other vehicle components, increasing the risk of a fire.

Manufacturer remedy

GM will notify owners and dealers will replace the jumper harness with one that includes a 40 amp inline fuse, and provide the owner with supplemental Owner Manual information, free of charge. The recall began on August 29, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14260.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HEATED WINDSHIELD WASHER MODULE SHORT CIRCUIT

NHTSA #10V240000 · Electrical System · NHTSA notice

Reported June 4, 2010 · GENERAL MOTORS CORP.

Potentially affected: 1,365,070 vehicles

Owners notified June 11, 2010

Defect description

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Safety consequence

IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Manufacturer remedy

DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AIR CONDITIONER

NHTSA #09V456000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported November 19, 2009 · CUES, INC.

Potentially affected: 269 vehicles

Owners notified January 5, 2010

Defect description

CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Safety consequence

THIS DEFECT COULD RESULT IN A FIRE.

Manufacturer remedy

CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.

Notes

try.vin has no NCAP crash-test rating on file for the 2007 Chevrolet Silverado 3500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

39 owner complaints have been filed with NHTSA for the 2007 Chevrolet Silverado 3500.

Engine

ODI #11741817

Fire

Incident: June 2, 2026 · Filed: June 3, 2026

The contact owned a 2007 Chevrolet Silverado. The contact stated that while driving at 65 MPH, the contact noticed smoking coming from the under the front vehicle. The contact mention he pulled over the right side of the road, turned the vehicle off and then exited the vehicle and opened the hood of the vehicle and noticed flames coming from the back of the engine. No injuries were sustained. No medical attention. The contact dialed 911 and there no police report filed. The fire department extinguished the fire. The vehicle was not destroyed. The vehicle was towed to a local tow lot. The vehicle was not repaired. The manufacturer was not notified. The approximate failure mileage was 377,000.

Steering

ODI #11631074

Incident: June 1, 2010 · Filed: December 16, 2024

I purchased my new 2007 Chevy duramax diesel with an already installed fabtech lift kit. My pitman arm has snapped 3 times since I purchased my truck leaving me with complete steering loss. I have had to replace all steering components several times. My truck is unsafe due to a fabtech lift kit that the dealer installed before I purchased it. Led Schwab was the installer. I have several complaints with nhtsa and vsh.

Steering

ODI #11539906

Incident: August 14, 2023 · Filed: August 21, 2023

Rattling noise in intermediate shaft of steering column and key tumbler is sticky

Fuel System, Diesel

ODI #11349178

Incident: August 1, 2017 · Filed: August 14, 2020

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE REFUELING, DIESEL FUEL SPRAYED BACK OUT OF THE FILLER NECK. THE CONTACT WAS CONCERNED THAT THE DESIGN OF THE FILLER NECK TO THE FUEL TANK WAS DEFECTIVE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT WAS UNABLE TO REACH THE MANUFACTURER. THE FAILURE MILEAGE WAS 285,064.

Service Brakes

ODI #11254791

Incident: July 8, 2019 · Filed: September 11, 2019

WHILE DRIVING AT ABOUT 35 MPH, I HAD TO STOP FOR A GARBAGE TRUCK DOING A TRASH PICKUP. WHEN I APPLIED THE BRAKES ON MY PICKUP, THE BRAKES TOTALLY FAILED AND I NEARLY DROVE ANOTHER CAR INTO THE BACK OF THE GARBAGE TRUCK. THAT AVERTED CRASH WOULD CERTAINLY HAVE KILLED THE CAR'S DRIVER. I AVOIDED A CRASH BY A RAPID TURN INTO THE ONCOMING LANE JUST AS A CAR COMING TOWARD ME CLEARED THE OPPOSING LANE. MY TRUCK HAS BEEN MAINTAINED PROFESSIONALLY AND THE BRAKE FAILURE WAS A GREAT SHOCK TO ME. MY TRUCK IS A 2007 CHEVY SILVERADO 3500 DUALLY.

Steering

ODI #11194479

Incident: May 13, 2017 · Filed: April 7, 2019

WHILE DRIVING AT ANY SPEED, STEERING WHEEL SHAKES, SLIGHTLY, YET NOTICEABLY. ANY SPEED. THE SHAKE IS CONSISTENT, FEELS WORSE WHEN TURNING OR(DRIFTING) RIGHT I ON FREEWAY. HAVE HAD STEERING GEAR BOX, PITMAN ARM, AND ROAD FORCE BALANCING PERFORMED, TO NO RELIEF. UPON SELF INSPECTION, LEFT WHEEL SEEMS (TIGHTER) AND NOT AS LOOSE TO HAND MANIPULATION, RIGHT WHEEL IS NOTICEABLY LOOSE WITH SLIGHT NOISE INDICATIVE TO A LOOSE OR WORN TIE ROD. VEHICLE WAS PURCHASED NEW. IT HAS BEEN TO 5 GM DEALERSHIPS TO ATTEMPT A FIX OF THIS PROBLEM. A LAWSUIT WAS FINALIZED APRIL 2019. GM WAS FORCED TO COMPENSATE OWNER YET NO FIX WAS PERFORMED.

Unknown or Other

ODI #11091186

Incident: June 14, 2015 · Filed: May 1, 2018

TAKATA RECALL MY DASHBOARD HAS CRACKED IN THREE DIFFERENT SPOTS 2 AROUND PASSENGERS AIR BAG ONE OVER GAGE CLUSTER. NOT SURE IF CAR WAS IN MOTION OR SITTING WHEN IT HAPPEN.

Air Bags

ODI #10955042

Incident: July 1, 2015 · Filed: February 16, 2017

"TAKATA RECALL" - I RECEIVED MY LETTER REGARDING THE PASSENGER SIDE AIRBAG RECALL DATED JULY 2015. I CONTACTED CORPORATE HEADQUARTERS AND THEY WERE NO HELP AND KEPT TELLING ME THE VEHICLE WAS "SAFE" TO DRIVE EVEN THOUGH THE LETTER SAYS DISCHARGE OF THE AIRBAG COULD CAUSE "INJURY OR DEATH TO OCCUPANTS." ON 2/15/17 I TOOK THE VEHICLE IN TO BLADE CHEVROLET AND ASKED THEM TO FIX THE RECALL. THEY JUST DOCUMENTED THAT THE PART IS NOT AVAILABLE. IT IS GOING ON TWO YEARS NOW - THIS IS UNREASONABLE. I CAN'T USE THE TRUCK FOR INTENDED USE - EXTENDED CAMPING TRIPS - OR EVEN SELL IT FOR TOP DOLLAR WITH A SAFETY RECALL THAT IS NOT BEING FIXED.

Air Bags

ODI #10948729

Incident: May 28, 2015 · Filed: January 31, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Air Bags

ODI #10927423

Incident: November 22, 2016 · Filed: November 22, 2016

Other Chevrolet Silverado 3500 model years

Check your 2007 Chevrolet Silverado 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Silverado 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN