2011 Toyota Highlander Recalls, Ratings & Complaints

Incident: September 14, 2025 · Filed: June 4, 2026

Odometer Fraud. The contact purchased a 2011 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale but contacted by a dealer. At the time of purchase, the vehicle mileage was 122,000, and at the time of registration, it was discovered that the mileage was 303,000.

Incident: October 8, 2025 · Filed: November 26, 2025

1. The 3.5L V6 Engine (2GR-FE) failed due to the subsequent loss of lubrication caused by the rupture of the Oil Cooler Pipe (Rubber component), a manufacturing defect known under TSB T-SB-0201-11 (ZE2 Program). The failed engine is currently available for inspection by request at the independent service center before it is disposed of. 2. The defect causes a sudden and severe loss of engine oil. This creates a high probability of the engine seizing (losing all power) while driving at highway speeds, resulting in a complete loss of propulsion and placing occupants at severe risk of collision. 3. The failure was confirmed, not reproduced. The vehicle was initially diagnosed with misfire codes (P0300, P0301). New spark plugs and ignition coils were installed in an attempt to resolve the issue. As the misfire persisted, the mechanic performed a compression test, confirming catastrophic zero compression failure in cylinders 1 and 2. Professional diagnostics then revealed critical codes: P1603 (ECM Malfunction), P1604 (Startability Malfunction), and P1605 (Rough Idling). These codes confirm a severe internal engine issue, consistent with permanent damage sustained during the oil loss event caused by the ZE2 pipe defect in July 2024. 4. No, not physically inspected by the manufacturer. The manufacturer (Toyota Executive Office Case Manager) was provided with certified documentation of the failure, including the photo of the faulty pipe, maintenance records during our ownership, and the dealership purchase statement for the replacement part. Toyota refused to authorize a physical diagnostic inspection of the failed engine at a dealership before denying goodwill assistance. 5.Yes. The initial lubrication loss event on July 4, 2024, was preceded by a message displayed on the dashboard (followed by a second failure event in October 2025 indicated by a flashing Check Engine light and the Traction Control light).

Incident: October 9, 2024 · Filed: October 11, 2024

Steering wheel air bag did not deploy in front end MVA

Incident: January 17, 2024 · Filed: June 25, 2024

Our car had a major oil leak from the engine Oil Cooler Pipe Manifold at the bottom of the engine (front). My research has concluded that this has been a known issue with various Toyota models with the 2GR-FE engine, however Toyota has not issued a recall and the local dealership has never mentioned it during services. The NHTSA has known about this issue, however it appears that little to no action has been taken with the vehicle manufacturer or public. The issue concerns a leak that is waiting to happen on all engines with the original Oil Cooler Pipe as it is designed with rubber pipes that degrade over time and even a pin hole oil leak will cause virtually all the engine oil to drain from the engine onto the pavement below and underside of the vehicle including brake components. It is not a matter of “if” but “when” it will happen, and the consequences can leave people stranded with a damaged engine and undriveable vehicle. Severe injury and deaths can and will result due to the ongoing lack of action by the NHTSA and vehicle manufacturer. As an aside, the cost to repair is in the thousands of dollars, unless the owner is fortunate like myself who was able to replace the Oil Cooler Pipe at my own time and cost with the vehicle out of service and significant clean up required. I still don’t know the long-term effects of our engine being almost drained of oil and because of this may now sell the car which was not in our plan. I have added a photo of the original inadequately designed Oil Cooler Pipe and the replacement version purchased from Toyota. Also, the dealership were not interested in doing anything for us. I demand that the NHTSA takes action which is long overdue. Please take this issue seriously

Incident: May 2, 2024 · Filed: May 25, 2024

Dear Sir/Madam, I am writing to file a formal complaint regarding persistent safety issues with my 2011 Toyota Highlander V6 AWD. Specifically, I have experienced significant problems related to the engine timing guide, timing chain, transmission system, which pose a risk to both vehicle occupants and other road users. Vehicle Information: Toyota Highlander V6 AWD, VIN: [XXX] Description of the Issue: The transmission in my Highlander has exhibited the following problems: 1) Low engine oil pressure, ticking Noise: There is low engine pressure, faulty guides timing chains, recurring ticking noise. This noise represents issues from the powertrain area and has raised concerns about potential mechanical flaws1. 2) Defective components, slipping Transmission: The transmission surges/slips affecting overall control and safety. This issue has been reported by other Highlander owners as well. Cross-Referencing Other Complaints and Recalls: 3) They did not go far back, Per the NHTSA database, there have been two documented complaints related to transmission issues in the 2011 Toyota Highlander V6 AWD, these complaints align with my experience, however they have not sent me the recall notice. In fact, Toyota has faced recalls and technical service bulletins (TSBs) related to transmission problems in various Highlander models: The 8-speed UA80E/UA80F automatic transmission used in the 2020 Highlander received a TSB for shift flare during wide-open throttle acceleration from 40 – 60 mph and during the upshift from 2nd to 3rd gear. Toyota addressed this issue under warranty1. The 6-speed U660F/U760E automatic transmission, used in earlier Highlander models, was generally reliable. However, the introduction of the 8-speed UA80E/UA80F unit caused initial problems1. Request for Action: Per NHTSA findings please ensure all the models sharing the chassis, model family, part and Toyota transmission oil are included in recall or service campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 19, 2023 · Filed: September 4, 2023

the intake VVT-i gear on 2AR-FE equipped Rav-4s and other Toyota models Has failed after 113k miles. The vehicle is at risk of causing self inflicted damage due to this common issue many toyota owners are facing 2008-2013 highlanders. The part has not been inspected but was diagnosed by a mechanic based on their past experience with these vehicles and sound. No warnings or dash lights just a terrible metallic rattle upon cold start. This started around 2k miles ago.

Incident: March 18, 2023 · Filed: March 24, 2023

As my family was driving down Interstate 85 in Atlanta going around 80 MPH a dash notification came on that said "Low Oil Pressure pull over" the notification came on then went away then came back on (car never ran hot). Thankfully we were near an exit so we pulled off and into the first parking lot we could find. There was a huge puddle of oil under the car and smoke coming from the engine. We got our Highlander towed back to our nearest Toyota dealership to our home to be inspected. It was discovered our Engine Oil Cooler Pipe had failed resulting in all of the oil in our car being released from the car. If we hadn't been able to pull over so fast most likely my engine would have seized up and caused a wreck in the middle of the interstate. After doing research on this issue I discover there was a Warranty Enhancement Program done by Toyota on this very part valid through 2021 or 150,000 miles. I have 163,000 miles on my car. I tried to explain to Toyota that like majority of people my car was not driven for 2 years due to covid so they should at the very least expand the warranty. The dealership also told me they couldn't have replaces the part until it failed which from what I can tell of the hundreds of other Toyotas experiencing this same issue there are no warning signs prior to the part failing, you discover it failed by it releasing all your oil while driving at a high rate of speed.

Incident: January 9, 2023 · Filed: January 11, 2023

Pin hole in oil line causing excessive oil leak. Loose oil very quickly. Could cause permanent damage to engine. Had old line replaced by mechanic with a metal line only inspected by my mechanic and there was mention of past recall by my mechanic but it does not show this on your sight. There was no warning lights at all. A coworker noticed excessive oil on the ground when I left work and called me immediately to check oil. Very little left in engine and I could see it coming from under car. Incident happen on 1-9-2023 Had car towed to mechanic to avoid damage to engine. My issue was there a recall at some point ? If other Toyotas are having this issue need to be addressed before cars blow there engines from no oil ! Since no warning lights came on I would have no idea I was losing oil this fast just driving down the road! I only knew because my coworker saw massive spill on concrete at work .

Incident: November 25, 2022 · Filed: December 17, 2022

Clicking in steering column light comes on dash for power steering then hard to make turn then well go back off then able to make turns with ease again

Incident: November 1, 2022 · Filed: December 13, 2022

In the last 30 days, the steering has begun to feel "loose", as if I am driving on ice. At first it was barely perceptable. There has been more "play" in the steering. During the last 2 days, the car is now making a thud when I am steering right. I have an appointment for a mechanic to look at it. The car is a 2011 Highlander, AWD, with 89,000 miles on it. I feel the steering issue could be very dangerous at some point.