NHTSA vehicle safety data

2010 Toyota Highlander Recalls, Ratings & Complaints

The 2010 Toyota Highlander has 10 NHTSA recall campaigns and 216 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA also files the 2010 Toyota Highlander separately as Highlander Hybrid — 4 recall campaigns.

NHTSA recall and complaint data for the 2010 Toyota Highlander, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2010 Toyota Highlander owner complaints

Owners have filed 216 complaints with NHTSA about the 2010 Toyota Highlander, describing incidents dated October 31, 2009 to May 21, 2026.

Most-cited components

Electrical System 53 complaints
Visibility/Wiper 42 complaints
Service Brakes 30 complaints
Vehicle Speed Control 22 complaints
Steering 21 complaints
Unknown or Other 15 complaints

Of the 216 complaints on file, 18 report a crash and 2 a fire; across all 216 complaints, owners report 14 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11740752 · Filed May 28, 2026
My car all of a sudden went into limp mode while driving on the 91 freeway with my kids in the car on may 21 2026. It had master warning ️ light and check engine light and a circle warning light that is the braking system also it said on the screen check hybrid system stop the vehicle in a safe…
ODI #11722240 · Filed March 5, 2026
When applying the brake slowly all of a sudden the car went full acceleration and crashed 500ft away at high speed. The car is crashed but available for inspection for a short period of time until the insurance company takes full posession. There are not open recalls. The only lights on the dash…
ODI #11706861 · Filed December 23, 2025
The contact owns a 2010 Toyota Highlander. The contact stated that the gear shifter had been stuck on several occasions. The vehicle was taken to the dealer, where the fuses were replaced on several occasions; however, the failure persisted. The vehicle was taken back to the dealer, where it was…

Read all 216 complaints

Owner-reported

2010 Toyota Highlander mileage at failure

167 of the 216 complaints on file for the 2010 Toyota Highlander give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 60,000 miles	Middle half 45,000–90,000 miles	Based on 42 complaints
Visibility/Wiper	Median 50,000 miles	Middle half 35,000–60,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2010 Toyota Highlander in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA18-006: Steering Column Separation
Closed April 2, 2024
Preliminary Evaluation PE18-005: Upper Steering Column Separation
Closed November 20, 2018

Open and recently closed NHTSA defect investigations

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Power Window Master Switch may Melt

NHTSA #15V689000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported October 22, 2015 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,814,284 vehicles

Repair completion: 45.68% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign C0M · Owners notified November 25, 2015 · Vehicles built August 1, 2008 – December 31, 2010 (per NHTSA)

Defect description

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Safety consequence

If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Manufacturer remedy

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2005 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Air Bag may not Deploy

NHTSA #14V168000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported April 9, 2014 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,486,413 vehicles

Repair completion: 57.8% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 27, 2014 · Vehicles built March 6, 2007 – July 7, 2010 (per NHTSA)

Defect description

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

Safety consequence

If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Manufacturer remedy

Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Inaccurate Load Carrying Capacity Labels

NHTSA #13V123000 · Equipment — Other — Labels · NHTSA notice

Reported April 9, 2013 · Southeast Toyota Distributors, LLC

Potentially affected: 7,525 vehicles

Owners notified May 28, 2013

Defect description

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Safety consequence

An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Manufacturer remedy

Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Occupant Sensing System Calibration

NHTSA #13V014000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported January 16, 2013 · Southeast Toyota Distributors, LLC

Potentially affected: 3,235 vehicles

Owners notified March 21, 2013

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Safety consequence

If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Manufacturer remedy

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

PEDAL ENTRAPMENT

NHTSA #10V023000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported January 27, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 1,126,915 vehicles

Toyota campaign 90L · Owners notified March 30, 2010

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 9LG/90L.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STICKING ACCELERATOR PEDAL

NHTSA #10V017000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported January 21, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 2,230,661 vehicles

Toyota campaign AOA · Owners notified February 5, 2010 · Vehicles built September 16, 2009 – January 26, 2010 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Safety consequence

THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA SAFETY RECALL NO. AOA. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

2010 Toyota Highlander 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

17% rollover risk

Safety Technology

Electronic Stability Control

3 investigations

216 owner complaints have been filed with NHTSA for the 2010 Toyota Highlander.

Fuel/Propulsion System

ODI #11740752

Incident: May 21, 2026 · Filed: May 28, 2026

My car all of a sudden went into limp mode while driving on the 91 freeway with my kids in the car on may 21 2026. It had master warning ️ light and check engine light and a circle warning light that is the braking system also it said on the screen check hybrid system stop the vehicle in a safe place immediately and contact a dealer. It smelled like smoke as I was trying to get out of traffic and drive it to the shoulder.I towed the car to the Toyota dealer in Orange and was told it's the inverter and its fried and needs to be replaced.

Electrical System; Vehicle Speed Control

ODI #11722240

Crash 2 injuries

Incident: March 4, 2026 · Filed: March 5, 2026

When applying the brake slowly all of a sudden the car went full acceleration and crashed 500ft away at high speed. The car is crashed but available for inspection for a short period of time until the insurance company takes full posession. There are not open recalls. The only lights on the dash were for TPMS sensor.

Electrical System

ODI #11706861

Incident: October 9, 2025 · Filed: December 23, 2025

The contact owns a 2010 Toyota Highlander. The contact stated that the gear shifter had been stuck on several occasions. The vehicle was taken to the dealer, where the fuses were replaced on several occasions; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed and determined that the rearview mirror wiring had failed. The vehicle was repaired. The contact related the failure to an unknown recall. The manufacturer was not notified of the failure. The failure mileage was unknown.

Electrical System

ODI #11654081

Incident: April 6, 2025 · Filed: April 11, 2025

The contact owns a 2010 Toyota Highlander. The contact stated that while driving 40 MPH, the vehicle lost automotive power and started to drift to the right side of the road. The brake pedal was depressed, and the vehicle was able to come to a complete stop. The contact mentioned she waited for AAA for roadside assistance. The vehicle was towed to an independent mechanic, where it was diagnosed alternator needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure but offered no assistance. The failure mileage was approximately 185,420.

Exterior Lighting

ODI #11630386

Incident: September 23, 2022 · Filed: December 12, 2024

Headlamps become cloudy and burn out new, expensive bulbs in months. Internet search says Toyota is aware of problem, but prior to my search my dealership wanted to charge me hundreds of dollars to 'evaluate electrical system'

Service Brakes; Forward Collision Avoidance

ODI #11604358

Incident: May 1, 2024 · Filed: July 24, 2024

We received this from Toyota. Customer Support Program Bulletin Date: Page: POL19-06 6/6/2019 1 of 3 REVISED 8/28/19 CUSTOMER SUPPORT PROGRAM BULLETIN (ZKC): REPAIR COVERAGE FOR BRAKE ACTUATOR ASSEMBLY AND BRAKE BOOSTER PUMP ASSEMBLY ON CERTAIN 2008-2010 MY HIGHLANDER HYBRID VEHICLE. When we received this bulletin, we asked our Toyota Dealer Service Department (Stevenson Toyota East, Denver, CO) to address this issue multiple times when bringing in our vehicle for service in 2019 and 2020 and were told repeatedly they would not fix this issue since the ABS light was not on. Now that this bulletin is expired the ABS light is on. We took our Highlander to the Toyota Dealership in Melbourne, Florida and were told that this repair will now cost us $2473.89. Our 2010 Highlander is barely worth that, and now we have to repair this on our own even though Toyota knew the brake actuator assembly and brake booster pump would eventually fail at some point in time. Despite this, Toyota refused to resolve this issue when we asked (more than once) right after receiving the service bulletin in 2019 and as a result is causing a safety issue for our college aged son who drives this car, and all other drivers on the road should the ABS system fail. The attached estimate states the ABS service light has not come back on but this is not true and my son is having issues with the brakes.

Engine

ODI #11569155

Incident: December 12, 2023 · Filed: January 31, 2024

The engine failed and locked up. Maintenance is completed every 3-4 months on schedule. There was no oil or water. Car was towed to a mechanic.

Service Brakes

ODI #11566144

Crash

Incident: January 17, 2024 · Filed: January 17, 2024

When traveling a slow speeds (less than 15 mph) and needing to stop, the brakes are pressed but do not respond. This has happened on several occasions and has caused two separate accidents where the Highlander has failed to stop and it runs into the car in front. After the first accident, we looked for recalls (2015) and there were none for any model Toyota for brakes or brake systems. We brought the car in to the mechanic and had all the brakes and pads replaced, although they said nothing was wrong with the shoes nor pads. Now, years later, another accident in the exact same way. Luckily, due to the slow speed, no one was hurt but this is definitely a problem with the car. There have never been any warning lights, or sounds that would indicate an issue.

Service Brakes

ODI #11563768

Incident: December 26, 2023 · Filed: January 5, 2024

Affected by the faulty Brake Actuator & Accumulator on 2010 Toyota Highlander Hybrid. Brake malfunction and ABS disabled lights popped up on my Multi-Information Display. This issue disables ABS & VSC systems, which therefore makes this a safety hazard. Upon doing research, I have concluded that many complaints about this specific "Brake actuator & accumulator" have been issued. In the past, Toyota has provided a "Customer Support Program" which expired in 2020, but this does not help current owners like myself, who are stuck with this problem.

Service Brakes

ODI #11551728

Incident: October 19, 2023 · Filed: October 24, 2023

On approx. October 19, 2023 my vehicle started showing 4 error messages on the display: Brake Malfunction, Check ABS, Check VSC System, and Check Brake System. At the same time, these 5 warning lamps became illuminated: Brake System Warning Light and Warning Buzzer (Red), Brake System Warning Light (Yellow), Master Warning Light (Yellow), ABS Warning Light (Yellow), and SLIP Indicator (Yellow). A car repair technician obtained the following error codes from the vehicle in a diagnosis: C1391 (Abnormal Leak in Accumulator). I was informed that the VSC (vehicle stability control) safety feature of the vehicle is disabled while the error codes and messages are present. Toyota previously issued a customer support bulletin (No. POL19-06) on June 6, 2019, titled "Customer Support Program ZKC: Certain 2008-2010 Model Year Highlander Hybrid Vehicles Coverage for Brake Actuator Assembly and Brake Booster Pump Assembly". In the bulletin, Toyota acknowledged that its 2008-2010 Highlander Hybrid models had "certain internal malfunctions of the Brake Actuator Assembly". Affected error codes include C1391 and C1253, among others. Affected warning lamps consists of all 5 of the warning lamps that were illuminated in my vehicle. Affected parts include 04008-26448 (Actuator Assy, Brake w/ Fluid) and 04008-51148 (Pump Kit, Brake Booster w/ Accumulator). Instead of issuing a recall for this hazardous defect, Toyota opted to offer "Customer Support Program ZKC". The malfunction that manifested my vehicle is not eligible for this program. Toyota should issue a proper recall to address this safety hazard.

Other Toyota Highlander model years

Check your 2010 Toyota Highlander VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Highlander at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN