2006 Toyota Highlander Recalls, Ratings & Complaints

Incident: September 23, 2026 · Filed: October 7, 2026

Multiple warning lights appeared on the dash board including ABS, also check VSC system in the dialogue window. Code C1391 (Abnormal leak in accumulator) appeared in a diagnostic scan. After some internet research, it appears this a common problem with the 2006 Toyota Highlander and is a very costly repair $2000-$4000. The leaky accumulator creates an unsafe driving condition as the ABS and VSC system are disabled due to the leak. Due to the high number of failures for these vehicles, I feel that Toyota should take responsibility and warranty this part and repair. Thank you

Incident: September 5, 2026 · Filed: September 12, 2026

The Antilock Braking Actuator has failed. This seems to be a known issue and was already recalled on the Toyota Camry. Toyota sells the part for $1500 locally and labor will be added to that as well - which will put the cost of replacing this critical part almost above the current value of the vehicle. This is a safety issue if I lose braking capability. It has not yet catastrophically failed, but is making a buzzing sound which is the indication of this unit losing brake fluid pressure and trying to keep the brake booster pump running to restore the pressure. The booster pump will burn out, possibly catch fire and/or blow the fuse and then the braking will loose power assist, and with unit in place....that makes braking almost impossible as it is NOT a typical brake system, all fluid goes through this failed module and without the electronic boost assist, one can not press the pedal hard enough to engage the brakes.

Incident: August 29, 2026 · Filed: September 1, 2026

The ABS/Brake Actuator is going out. There is a stuttering as I'm coming to a stop, but when I brake from normal speeds to slow down, there is no stutter/vibration. Only when I'm going very slow and about to stop the car is when I feel a vibration/stutter in the vehicle. When pressing the brakes all the way down, there is a weird chirping/clicking noise that comes from under the hood towards the passenger side of the car. I do not have and did not get any warning lights about this, even still I don't have any. I have taken it to 2 mechanic shops now and they both have diagnosed the brake/ABS actuator failing.

Incident: June 19, 2026 · Filed: August 5, 2026

ABS actuator/accumulator issue on 2006 Toyota Highlander hybrid limited. Internal component failure there are recalls on others but not this particular year. Was driving along hit the brakes and got hard pedal. Yes there were other indicator lights on including the VSC system and traction control I came to an intersection and I couldn't stop I couldn't even kind of stop it was all hard pedal were before it was normal as if there wasn't an issue. I've done a lot of research and I've seen a lot of forums and people are complaining that Toyota isn't backing this problem my 2006 Toyota is in perfect condition not a single problem except for this break issue and if you take it to Toyota the park cost $2,200 in about roughly over $5,000 to fix it well who wants to put that kind of money into a car of that year the problem is it's just a shame and a safety deal that it put my family's life at risk we could have crashed it if I wasn't an actual driver by trade I wouldn't have known how to react in other families could be harmed in this. It's worth looking into I did not need to make her police report because I veered off into a field that saved my family's life. As of now I'm hoping to open a recall campaign and just have that part replaced I could have a car that could drive another 100,000 miles and give and keepToyota good name

Incident: June 26, 2026 · Filed: July 1, 2026

The contact owns a 2006 Toyota Highlander. The contact stated that while driving approximately 60 MPH, the vehicle failed to decelerate while the brake pedal was depressed. The contact stated that excessive pressure was needed on the brake pedal to stop the vehicle. The ABS and ESC warning lights were illuminated. In addition, there was an abnormal sound coming from underneath the vehicle. The vehicle was towed to a local independent mechanic, where it was diagnosed and determined that the ABS unit needed to be replaced. The vehicle was towed to another independent mechanic for a second opinion, and it was confirmed that the ABS unit needed to be replaced. The vehicle was taken to a local dealer, where it was diagnosed and determined that the brake actuator needed to be upgraded. The vehicle was diagnosed, and parts were ordered for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 195,000.

Incident: January 12, 2026 · Filed: January 12, 2026

My 2006 Toyota Highlander Hybrid Limited has an ABS fault that has caused my vehicle to undergo several maintenance issues and poses a serious safety hazard. My vehicle has less than 150,000, and over the course of the last year, my ABS light, my emergency brake light, my TSC light, and my tire pressure sensor light have all come on and refuse to go away. Additionally, the maintenance light, along with a "CHECK VSC SYSTEM" message has been on my dash for months and will not reset. My ABS has been making an intermittent buzzing sound that cycles every ten seconds when my car is on. That has been going one since shortly before the lights. When the lights came on, I noticed a serious change in my braking. The pedal would become spongy one moment and rock solid the next, or my car would brake intensely with the lightest pressure or require my foot basically to the floor to stop it. This has caused a serious issue for the safety of myself and my family. After using and OBDII scanner with ABS capabilities, the codes I received point to the ABS assembly failing to retain pressure, hence the persistent cycling to compensate for it loosing pressure. This was confirmed after the battery voltage/connection, relays, fuses, and speed sensors had all been tested. After doing further research, several other owners of similar configurations to mine share the same issue. My dashboard even makes an incredibly distracting ringing noise that can only be stopped by removing all the fuses and relays to the ABS entirely. This has not been caused as a lack of proper maintenance as this vehicle has only been in my possession for the past 3 years, of which before it came from the Toyota dealership. The dealership wants over $3,000 to fix the issue, and the part alone is $1,850 since the part has been discontinued. This fix costs more than the car is worth given its age and mileage. During any inclement weather, or in traffic, the car is unpredictable in how hard it might brake.

Incident: May 1, 2025 · Filed: December 26, 2025

Toyota’s part number 44050-48190 brake actuator assembly failed, as it has in other models and is very commonly doing in the Highlander model. It is triggering other warning lights issues in the vehicle. Vehicle safety is at risk. Many others have reported the same issue.

Incident: August 1, 2025 · Filed: August 13, 2025

I was on the interstate driving about 72 mph when the car just shut off all the dash lights came on and the dash it said check hybrid system I had no brakes or steering I got it off the road turned it off and back on again it started up and I drove it home but the dash still displayed check hybrid system , a week later I get in it to go to work and there’s an alarm that won’t cut off and the abs , traction control and brake light and warning light and tire pressure light are all on and the brakes are hard and there’s a weird noise coming from somewhere when u push on the brake and it says check VSC system on the dash now

Incident: April 26, 2025 · Filed: May 23, 2025

The vehicle suffers from an ABS module failure. I've been researching that this is common problem with the Toyota Highlander Hybrid and presents a danger of failing brakes while driving. My brakes partially failed with my [XXX] son in the car. When attempting to stop, I had no hydraulic pressure and luckily was able to get the vehicle stopped after the car had regained some pressure. The vehicle had been running for several minutes, so it wasn't related to a fresh start and the system not having time to pressurize, if that's a thing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: March 1, 2025 · Filed: March 16, 2025

The brakes on my 06 Highlander hybrid AWD have been finicky at best since I’ve owned the vehicle. The car lunges forward when braking, all the way until a complete stop. While driving at around 55 MPH a medium sized dog ran out into the road. I braked hard but the brakes just lunging and trying to stop. At one point feels like it’s not braking anymore and just hope to veer out of the way. This can be fatal not only to the driver but to others driving as well. The fact that people are still having this issue, and Toyota hasn’t come up with a proper long term solution speaks to how much Toyota cares about its customer bases’ safety. It is honestly disgusting that people have had accidents and may have fatal and Toyota continues to not care. Please urge Toyota to look into this further and attempt to fix this permanently!