NHTSA vehicle safety data

2008 Toyota Highlander Recalls, Ratings & Complaints

The 2008 Toyota Highlander has 13 NHTSA recall campaigns and 405 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA also files the 2008 Toyota Highlander separately as Highlander Hybrid — 8 recall campaigns.

NHTSA recall and complaint data for the 2008 Toyota Highlander, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 Toyota Highlander owner complaints

Owners have filed 405 complaints with NHTSA about the 2008 Toyota Highlander, describing incidents dated November 25, 2007 to October 5, 2026.

Most-cited components

Service Brakes 81 complaints
Engine 76 complaints
Air Bags 58 complaints
Vehicle Speed Control 45 complaints
Electrical System 44 complaints
Steering 40 complaints

Of the 405 complaints on file, 44 report a crash and 14 a fire; across all 405 complaints, owners report 42 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11772534 · Filed October 20, 2026
We own a 2008 Toyota Highlander. The SRS airbag warning light on the dash is lit. It is a sensor issue that has been fixed once. It is a safety issue because, as I understand it, the airbags will not deploy when this warning light is on. I would like to know if this is an issue with other 2008…
ODI #11765753 · Filed September 21, 2026
Odometer Fraud. The contact purchased a 2008 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that at the time of purchase the mileage was 106,000. After obtaining a Carfax report, the contact became aware that the mileage…
ODI #11722415 · Filed March 6, 2026
The contact owned a 2008 Toyota Highlander. The contact stated that while driving at approximately 20 MPH, an abnormal, booming sound was emitted from the vehicle as heavy, black smoke entered her vehicle. Due to the smoke, the contact's vision became obstructed, and the contact immediately shifted…

Read all 405 complaints

Owner-reported

2008 Toyota Highlander mileage at failure

311 of the 405 complaints on file for the 2008 Toyota Highlander give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 100,000 miles	Middle half 75,000–130,000 miles	Based on 63 complaints
Air Bags	Median 80,000 miles	Middle half 65,000–100,000 miles	Based on 45 complaints
Vehicle Speed Control	Median 25,000 miles	Middle half 10,000–50,000 miles	Based on 40 complaints
Steering	Median 90,000 miles	Middle half 60,000–130,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2008 Toyota Highlander in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA18-006: Steering Column Separation
Closed April 2, 2024
Preliminary Evaluation PE18-005: Upper Steering Column Separation
Closed November 20, 2018

Open and recently closed NHTSA defect investigations

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Power Window Master Switch may Melt

NHTSA #15V689000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported October 22, 2015 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,814,284 vehicles

Repair completion: 45.68% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign C0M · Owners notified November 25, 2015 · Vehicles built August 1, 2008 – December 31, 2010 (per NHTSA)

Defect description

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Safety consequence

If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Manufacturer remedy

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2005 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Air Bag may not Deploy

NHTSA #14V168000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported April 9, 2014 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,486,413 vehicles

Repair completion: 57.8% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 27, 2014 · Vehicles built March 6, 2007 – July 7, 2010 (per NHTSA)

Defect description

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

Safety consequence

If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Manufacturer remedy

Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Power Window Master Switch may Melt

NHTSA #12V491000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported October 10, 2012 · Toyota Motor Engineering & Manufacturing

Potentially affected: 2,519,424 vehicles

Repair completion: 66.99% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified November 5, 2012 · Vehicles built May 25, 2007 – July 31, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Safety consequence

If the switch overheats, it may melt, possibly resulting in a fire.

Manufacturer remedy

Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

INADVERTENT SIDE AIRBAG DEPLOYMENT

NHTSA #11V245000 · Air Bags · NHTSA notice

Reported April 21, 2011 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 307,848 vehicles

Toyota campaign BOE-B1E · Owners notified January 9, 2012 · Vehicles built May 25, 2007 – January 31, 2008 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.

Safety consequence

INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.

Manufacturer remedy

TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA SAFETY RECALL NO. BOE-B1E.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

PEDAL ENTRAPMENT

NHTSA #10V023000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported January 27, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 1,126,915 vehicles

Toyota campaign 90L · Owners notified March 30, 2010

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 9LG/90L.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INCORRECT GVWR LABELS

NHTSA #09V223000 · Equipment — Other — Labels · NHTSA notice

Reported June 15, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 27,080 vehicles

Owners notified September 18, 2009 · Vehicles built September 1, 2005 – May 4, 2009 (per NHTSA)

Defect description

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Safety consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Notes

AFTERMARKET STAINLESS STEEL EXHAUST TIPS/CLAMP

NHTSA #09E028000 · Equipment · NHTSA notice

Reported May 14, 2009 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 3,499 vehicles

Owners notified June 15, 2009

Defect description

SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Safety consequence

THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.

Notes

AFTERMARKET STAINLESS STEEL EXHAUST TIPS/CLAMP

NHTSA #09E022000 · Equipment · NHTSA notice

Reported April 27, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 39,100 vehicles

Toyota campaign SSC 90E · Owners notified May 4, 2009

Defect description

TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING THE CLAMP TO BREAK.

Safety consequence

THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM THROUGH 4:00 PM PACIFIC TIME.

Notes

TOYOTA'S RECALL NO. SSC 90E.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 208/THIRD ROW REAR SEAT BELTS

NHTSA #08V181000 · Seat Belts — Rear/Other · NHTSA notice

Reported April 18, 2008 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 90,189 vehicles

Toyota campaign 80D · Owners notified December 10, 2008 · Vehicles built May 31, 2007 – March 7, 2008 (per NHTSA)

Defect description

TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.

Safety consequence

HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.

Manufacturer remedy

DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 80D.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2008 Toyota Highlander 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

17% rollover risk

Safety Technology

Electronic Stability Control

2 investigations

405 owner complaints have been filed with NHTSA for the 2008 Toyota Highlander.

Air Bags

ODI #11772534

Incident: October 5, 2026 · Filed: October 20, 2026

We own a 2008 Toyota Highlander. The SRS airbag warning light on the dash is lit. It is a sensor issue that has been fixed once. It is a safety issue because, as I understand it, the airbags will not deploy when this warning light is on. I would like to know if this is an issue with other 2008 Highlanders. This has happened twice since we have owned the vehicle. The dealership fixed the issue the first time but has no record of the repair. This time the repair could be over $1000.00 for me to drive a safe vehicle. I believe this should be looked into to see if it is an issue with other 2008 Toyota Highlanders.

Electrical System

ODI #11765753

Incident: September 21, 2026 · Filed: September 21, 2026

Odometer Fraud. The contact purchased a 2008 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that at the time of purchase the mileage was 106,000. After obtaining a Carfax report, the contact became aware that the mileage listed was 264,000.

Engine

ODI #11722415

Fire 1 injury

Incident: February 6, 2026 · Filed: March 6, 2026

The contact owned a 2008 Toyota Highlander. The contact stated that while driving at approximately 20 MPH, an abnormal, booming sound was emitted from the vehicle as heavy, black smoke entered her vehicle. Due to the smoke, the contact's vision became obstructed, and the contact immediately shifted into park and jumped out of her vehicle for safety. It was unknown if there were any warning lights. As a result, the contact injured her right hip and strained her vocal cords. The vehicle quickly became engulfed in flames as authorities were called to the scene. The fire department extinguished the flames as both a fire and a police report were filed. The vehicle was towed to an independent mechanic, where it was deemed a total loss. There was no property damage. The origin of the fire was unknown, and an investigation was opened by the insurance company. The contact sought medical attention the next day and was treated for the strain on her right hip. The manufacturer was notified of the failure, and the contact was given a case number. The contact was also informed that she would receive a response from them within 45 days. The vehicle was destroyed. The failure mileage was approximately 100,000.

Service Brakes

ODI #11689649

Incident: June 16, 2025 · Filed: September 25, 2025

THERE WAS NO INCIDENT. WHEN THE BRAKE MALFUNCTION SCREEN DISPLAYED, I DROVE THE VEHICLE TO THE NEAREST TOYOTA DEALER IN PUEBLO, COLORADO. I RECEIVED THE ATTACHED SERVICE MESSAGE AND PICKING TICKET; 17june2025. IT ALSO NEEDS NEW BRAKE PADS, ROTOR ADJUSTMENT, AND 5 NEW TIRES. TOTAL~$6000. WAY TOO PRICY! I PAID FOR THE DIAGNOSTIC TEST, AND DROVE HOME CAREFULLY! THE VEHICLE HAS BEEN SITTING IN MY CARPORT SINCE, AND I AM WALKING THE CITY LIMITS FOR ALL PURPOSES. THE 12V BATTERY DIED MID-JULY, WITHOUT REPLACEMENT SINCE. I LIVE IN LA JUNTA, 70 MILES EAST OF THE DEALER. SO WE'RE LOOKING AT 99,000 TOTAL MILES AS IT SITS.

Electrical System; Service Brakes

ODI #11686896

Incident: September 10, 2025 · Filed: September 12, 2025

My 2008 Toyota Highlander Hybrid is having severe issues with the ABS system. Toyota is reporting that it needs an ABS actuator and ABS pump replacements. These were a part of Toyota's previous Customer Support Program, but the program expired before I owned the vehicle. That is EXTREMELY dangerous and the issue with the ABS system should be considered a Safety Recall that is ALWAYS available to Toyota customers to rectify and paid for by Toyota. It is a BRAKING ISSUE. It is not just brake pads, or normal wear and tear. This is a known issue and regardless of the timeline, Toyota should absolutely pay for the repair.

Electrical System

ODI #11681187

Incident: August 1, 2025 · Filed: August 17, 2025

The Intelligent power module failed on the vehicle. I read this is common for my vehicle however there is no recall matching my VIN. Vehicle was purchased out of state one year ago. We took the vehicle to a Toyota dealership who suggested I inquire about the issue because it’s possible this VIN should have been included.

Electrical System

ODI #11680713

Incident: August 14, 2025 · Filed: August 14, 2025

Odometer Fraud. The contact purchased a 2008 Toyota Highlander. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 123,399, and at the time of registration, it was discovered that the mileage was 271,890.

Service Brakes

ODI #11674307

Incident: May 25, 2025 · Filed: July 17, 2025

Good Afternoon, The brake actuator and booster pump failed on my 2008 Toyota Highlander Hybrid. ABS, Brake, and VSC warning lights came on, and the brakes became weak and unsafe. A repair shop confirmed the issue with codes C1252, C1256, and C1391. I tried to fix it at a local shop last year, but the problem came back. It seems this repair can only be fully done at a Toyota dealer due to software requirements. However, the dealer repair cost is very high. I cannot afford the repair or a new car right now because of family budget limits — we have three children and rely on this vehicle every day(only one car). Toyota declined to help, even though I later found this issue was once covered under Program ZKC, which I missed. The vehicle is still unsafe and available for inspection. Thank you very much for considering my issue!

Service Brakes

ODI #11627605

Incident: November 26, 2024 · Filed: November 26, 2024

Brake actuator failure. Have to manually brake, stopping distance significantly increased. 3,145$ to replace at Toyota dealership.

Service Brakes

ODI #11621337

Incident: October 14, 2024 · Filed: October 22, 2024

In June 2019, Toyota issued a recall for ABS malfunction, diagnostic code C1391 - brake actuator and accumulator. New parts were issued by Toyota in 2019 as part of the recall. My vehicle experienced ABS malfunction, diagnostic code C1391 in March 2022 and was repaired by Toyota with the new and improved parts issued as part of the recall. As of October 14, 2024, my vehicle is experiencing the same issue again - ABS brake malfunction diagnostic code C1391, with the brake system light, master warning light, abs light and ABS Malfunction warning noted on the screen. The vehicle can be inspected. Toyota has inspected and confirmed it is the same issue again. The new and improved parts from 2019 should not fail within 20,000 miles. Toyota did confirm that they used the new parts issued as part of the recall and cannot explain why they failed faster than the original parts causing dangerous braking issues.

Other Toyota Highlander model years

Check your 2008 Toyota Highlander VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Highlander at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN