NHTSA vehicle safety data

2009 Toyota 4Runner Recalls, Ratings & Complaints

The 2009 Toyota 4Runner has 6 NHTSA recall campaigns and 22 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2009 Toyota 4Runner, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2009 Toyota 4Runner owner complaints

Owners have filed 22 complaints with NHTSA about the 2009 Toyota 4Runner, describing incidents dated May 14, 2009 to June 9, 2024.

Most-cited components

Power Train 10 complaints
Electrical System 4 complaints
Engine 4 complaints
Structure 3 complaints
Air Bags 2 complaints
Fuel/Propulsion System 2 complaints

Of the 22 complaints on file, 4 report a crash and 1 a fire; across all 22 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11594145 · Filed June 13, 2024
The contact owns a 2009 Toyota 4Runner. The contact stated while pulling out of a driveway, the contact observed a grinding noise coming from the front end of the vehicle and the steering wheel violently yanked to the right. Additionally, the contact stated that when the brake pedal was depressed…
ODI #11461419 · Filed April 19, 2022
On 4/8/22, the rear window of our 2009 Toyota 4runner just shattered and fell apart for no reason. We took it to get replaced at Safelite on 4/13/22 and one of their techs asked if we knew what caused the glass to break and we told him we had no idea. We told him it just broke out of nowhere from…
ODI #11377705 · Filed December 3, 2020
TL* THE CONTACT OWNS A 2009 TOYOTA 4RUNNER. THE CONTACT STATED WHILE DRIVING 40 MPH, THEY CRASHED INTO A COW WHICH CAUSED DAMAGED TO THE FRONT OF VEHICLE. THE CONTACT WAS CONCERNED THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO REPORTED INJURIES. A POLICE REPORT WAS FILED. THE LOCAL DEALER WAS NOT…

Read all 22 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2009 Toyota 4Runner in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Recall Query RQ10-003: Unintended and Uncontrolled Acceleration
Closed March 1, 2011

Open and recently closed NHTSA defect investigations

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2006 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Occupant Sensing System Calibration

NHTSA #13V014000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported January 16, 2013 · Southeast Toyota Distributors, LLC

Potentially affected: 3,235 vehicles

Owners notified March 21, 2013

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Safety consequence

If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Manufacturer remedy

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

PEDAL ENTRAPMENT

NHTSA #11V113000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported February 24, 2011 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 1,363,244 vehicles

Toyota campaign 9LG · Owners notified April 13, 2011 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Notes

TOYOTA'S RECALL CAMPAIGN NUMBERS ARE 90L (TOYOTA) AND 90LG (LEXUS).CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.THIS RECALL IS AN EXPANSION OF SAFETY RECALLS 09V-388 AND 10V-023.

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

2009 Toyota 4Runner 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

Electronic Stability Control

1 investigation

22 owner complaints have been filed with NHTSA for the 2009 Toyota 4Runner.

Structure

ODI #11594145

Incident: June 9, 2024 · Filed: June 13, 2024

The contact owns a 2009 Toyota 4Runner. The contact stated while pulling out of a driveway, the contact observed a grinding noise coming from the front end of the vehicle and the steering wheel violently yanked to the right. Additionally, the contact stated that when the brake pedal was depressed, the vehicle pulled to the left inadvertently. The vehicle was stopped and inspected. The contact observed that the front passenger’s side tire was dangling by the rocker arm and the subframe. The vehicle was taken to the residence. The vehicle was then towed to an independent mechanic where it was diagnosed that the front passenger’s side subframe and the rocker arms needed to be replaced due to extreme corrosion. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 114,000.

Unknown or Other

ODI #11461419

Incident: April 8, 2022 · Filed: April 19, 2022

On 4/8/22, the rear window of our 2009 Toyota 4runner just shattered and fell apart for no reason. We took it to get replaced at Safelite on 4/13/22 and one of their techs asked if we knew what caused the glass to break and we told him we had no idea. We told him it just broke out of nowhere from some strange reason, and he told us that it looks like the window breaking was caused by the overheating of the rear defroster and that it was a common issue with 2009 4runners. We were in shock to find this out and are grateful that our son or dog was not in the back seat when this happened. I found out online that Toyota issued a recall for this issue (Warranty Program ZG7) and I spoke with a Toyota customer service rep to see if we could be reimbursed the $100 we paid out of pocket for this manufacturer's defect and they said the warranty program ended in 2018 so they couldn't help us. We were very disappointed to be told this because this is obviously still happening with these 4runners and it's a major safety issue as well.

Air Bags

ODI #11377705

Crash

Incident: November 24, 2020 · Filed: December 3, 2020

TL* THE CONTACT OWNS A 2009 TOYOTA 4RUNNER. THE CONTACT STATED WHILE DRIVING 40 MPH, THEY CRASHED INTO A COW WHICH CAUSED DAMAGED TO THE FRONT OF VEHICLE. THE CONTACT WAS CONCERNED THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO REPORTED INJURIES. A POLICE REPORT WAS FILED. THE LOCAL DEALER WAS NOT CONTACTED.THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE MANUFACTURER WAS CONTACTED HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 145,000. *LN

Steering; Suspension; Unknown or Other

ODI #11210138

Crash

Incident: May 1, 2019 · Filed: May 27, 2019

LESS THAN 80K MILES AND FRAME IS COMPLETELY ROTTING APART. WHILE DRIVING APPROXIMATELY 40 MPH I LOST CONTROL BECAUSE THE CONTROL ARM COMPLETELY SEPARATED FROM THE FRAME! COMPLETELY UNSAFE AND DEATH TRAPS

Steering

ODI #11153258

Incident: November 10, 2018 · Filed: November 22, 2018

STEERING WAS VERY HARD TO DO AND REALLY JERKY.TOOK IT TO DEALERSHIP AND WAS TOLD THAT THE RACK AND PIN NEEDED TO BE COMPLETELY CORRODED AND NEEDED TO BE REPLACED. YET ANOTHER PART I HAVE TO EAT THE COST DUE TO CORROSION. I HAVE READ MULTIPLE COMPLAINTS ABOUT THE SAME PROBLEMS. WHY IS NOTHING BEING DONE?

Suspension; Power Train; Structure

ODI #10985534

Incident: May 8, 2017 · Filed: May 13, 2017

EXCESSIVE RUST ON FRAME WITH JEOPARDIZED INTEGRITY AT JOINS CONNECTING BRAKES, FUEL LINES AND SUSPENSIONS SYSTEM.

Vehicle Speed Control; Engine

ODI #10631983

Incident: September 6, 2010 · Filed: September 9, 2014

UPON ACCELERATION, THE VEHICLE HESITATES FOR 2-3 SECONDS. THIS HAPPENS ON STARTING OFF, DRIVING DOWN THE ROAD, PULLING INTO TRAFFIC. I HAVE HAD IT TO THE DEALER 15-20 TIMES AND THEY CAN'T FIND THE CAUSE. THEY SAID IT HAD TO FAIL FOR AT LEAST 5 SECONDS FOR IT TO REGISTER ON THE COMPUTER MODULE. IT NEVER LASTS MORE THAN 2-3 SECONDS AND, I CONSIDER IT 'VERY DANGEROUS'. DATES ABOVE ARE APPX. IT DOES IT EVERY DAY. *TR

Fuel System, Gasoline

ODI #10594345

Incident: May 24, 2014 · Filed: May 27, 2014

DRIVING ALONG A TWO LANE U.S. HIGHWAY AT THE POSTED SPEED, I NOTICED THAT MY FUEL GAUGE WAS SHOWING FULLY EMPTY, AND THE WARNING LIGHT WAS FLASHING. PUSHING THE ODOMETER TRIP BUTTON, I NOTICED THAT I HAD NOT YET REACHED THE MILEAGE FOR A "NORMAL" FILL UP, WHERE I ROUTINELY GET 20-21 MPG. AT THE END OF THAT TRIP,WHEN I TURNED THE VEHICLE OFF AND RESTARTED IT, THE FUEL GAUGE SHOWED HALF FULL. USING THE TRIP ODOMETER, I DROVE AN ADDITIONAL ESTIMATED 30 MILES TO HOME. THE FUEL GAUGE CONTINUED TO DISPLAY HALF FULL. THE NEXT MORNING, I DROVE APPROXIMATELY 3 MILES TO THE GAS STATION, AND WAS SURPRISED WHEN IT TOOK ALMOST 15 GALLONS TO FILL THE TANK. THE NEEDLE ON THE GAUGE THEN WENT TO FULL. SINCE THEN IT HAS ONLY COME DOWN TO ONE HALF, YET MY MILEAGE NOW IS AT THE POINT (261-270) WHERE I NORMALLY FILL UP WHEN THE NEEDLE NEAR THE EMPTY LINE. I BELIEVE THIS PROBLEM IS NO DOUBT WIDESPREAD. *TR

Air Bags

ODI #10552260

Crash 1 injury

Incident: September 10, 2009 · Filed: November 14, 2013

I WAS DRIVING IN THE LEFT/FAST LANE ON A TOLL ROAD WHEN ANOTHER VEHICLE WHO WAS SPEEDING IN EXCESS OF 55MPH ENTERING THE TOLL ROAD CROSSING AND CUTTING OFF THE OTHER LANES OF TRAFFIC RUNNING INTO ME ON THE PASSENGER SIDE FORCING ME INTO THE CONCRETE WALL/BARRIER HEAD ON. HIS VEHICLE SWUNG INTO AGAIN INTO MY PASSENGER REAR SIDE THEN BOUNCED OFF. I WAS STUNNED, IN SHOCK, UNABLE TO EXIT ON MY SIDE AND DIDN'T SEE IT COMING. I WAS THROWN LEFT INTO THE FRAME AND WINDOW AND JERKED AROUND EVEN THOUGH I HAD MY SEAT BELT FASTENED. THE AIR BAGS DID NOT DEPLOY. I HAD FRONT AND SIDE CURTAIN AIRBAGS AND HAD ONLY JUST PURCHASED THE 4RUNNER A FEW MONTHS PRIOR. IT WAS DECLARED TO BE TOTALED. I PERMANENTLY INJURED MY NECK, BACK AND BROKE MY NOSE. IN ADDITION, I HAVE ANXIETY AND PANIC ATTACKS ABOUT DRIVING. THE OTHER DRIVER WAS CITED AT FAULT FOR FAILURE TO CONTROL SPEED AND UNSAFE LANE CHANGES AND HIS INSURANCE PAID FOR MY TOTALED VEHICLE AND WHAT LITTLE INSURANCE COVERAGE HE HAD FOR MY PERSONAL INJURIES. I WAS JUST NOW NOTIFIED THAT THERE WAS A PROBLEM WITH MY VEHICLE'S AIR BAGS AND SENSORS (A RECALL), NOW THAT IT IS ALMOST EXACTLY 4 YEARS FROM THE ACCIDENT, THERE IS NOTHING I CAN APPARENTLY DO TO HOLD TOYOTA AT FAULT DUE TO STATUTE OF LIMITATIONS. THIS VERY UPSETTING. I AM FULLY DISABLED NOW AND WILL BE ON PAIN MANAGEMENT AND PERIODIC PHYSICAL THERAPY FOR THE REST OF MY LIFE, AND CAN NO LONGER EVEN PERFORM SIMPLE CHORES. *TR

Fuel System, Gasoline; Electrical System; Engine

ODI #10536598

Crash

Incident: August 21, 2013 · Filed: August 21, 2013

WHEN MY WIFE STEPPED ON THE GAS TO PULL INTO A PARKING SPOT,THE 4RUNNER JUST LURCHED FORWARD INTO A FENCE. LUCKILY NO ONE WAS IN FRONT OF THE 4RUNNER. THE BUMPER AND FENCE WAS DAMAGED. SHE IS NOW VERY SCARED TO DRIVE THE 4RUNNER. *TR

Other Toyota 4Runner model years

Check your 2009 Toyota 4Runner VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota 4Runner at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN