try.vin
Log in

NHTSA vehicle safety data

1996 Toyota 4Runner Recalls, Ratings & Complaints

The 1996 Toyota 4Runner has 5 NHTSA recall campaigns and 72 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 1996 Toyota 4Runner, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1996 Toyota 4Runner owner complaints

Owners have filed 72 complaints with NHTSA about the 1996 Toyota 4Runner, describing incidents dated June 12, 1996 to September 1, 2021.

Most-cited components

  • Structure 38 complaints
  • Suspension 23 complaints
  • Unknown or Other 10 complaints
  • Vehicle Speed Control 4 complaints
  • Visibility/Wiper 3 complaints
  • Air Bags 2 complaints

Of the 72 complaints on file, 5 report a crash and 1 a fire; across all 72 complaints, owners report 3 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11436237 · Filed

    I have noticed that my vehicle doesn’t seem to be balance and most of the time i am afraid the tires will fall off by the movement of the vehicle. And the metal parts that attachment part it looks very bad on the metal parts like it rusted so bad. I hope they will be able to figure out whats wrong…

  • ODI #11405797 · Filed

    TL* THE CONTACT OWNS A 1996 TOYOTA 4RUNNER. THE CONTACT STATED WHILE DRIVING 70 MPH, THE SUN ROOF DETACHED AND FLEW OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE…

  • ODI #11219278 · Filed

    MY VEHICLE HAS BEEN SLIPPING A LOT CAUSING ME TO LOSE CONTROL OF THE VEHICLE IT'S NOT THE FIRST TIME IT HAS HAPPENED JUST RECENTLY IT HAPPENED AGAIN AND I WAS TOLD TO CHECK IF THERE WAS A RECALL ON THE VEHICLE BUT THERE WASN'T BUT AFTER RESEARCHING MY 4RUNNER I'VE READ THERE WAS SOME RECALLS ON THE…

Read all 72 complaints

Owner-reported

1996 Toyota 4Runner mileage at failure

54 of the 72 complaints on file for the 1996 Toyota 4Runner give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
StructureMedian 185,000 milesMiddle half 160,000–250,000 milesBased on 31 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

TOYOTA/REAR SUSPENSION

NHTSA #02V021000 · Suspension · NHTSA notice

Reported January 18, 2002 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 273,743 vehicles

Toyota campaign SSC 20A · Owners notified February 28, 2002 · Vehicles built November 20, 1995 – February 28, 1998 (per NHTSA)

Defect description

ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.

Safety consequence

THIS MAY RESULT IN A LOSS OF CONTROL AND COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE REAR SUSPENSION PARTS. ALTHOUGH THE 4WD 4RUNNERS DO NOT EXHIBIT THE HANDLING CONDITION, TOYOTA WILL RECALL THESE VEHICLES TO AVOID ANY PUBLIC CONFUSION AS TO WHICH VEHICLES SHOULD RECEIVE THE REPLACEMENT PARTS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. SSC 20A.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Equipment — Other — Labels

NHTSA #96V098000 · NHTSA notice

Reported June 12, 1996 · TOYOTA MOTOR CO., LTD.

Potentially affected: 15,707 vehicles

Owners notified July 15, 1996 · Vehicles built November 1, 1995 – April 1, 1996 (per NHTSA)

Defect description

THE STICKER REQUIRED BY PART 575, "CONSUMER INFORMATION REGULATIONS" TO ALERT THE DRIVER OF "THE PARTICULAR HANDLING AND MANEUVERING CHARACTERISTICS OF UTILITY VEHICLES" WAS NOT AFFIXED TO THE DRIVER'S SIDE SUN VISOR.

Safety consequence

CONSEQUENCE OF NON-COMPLIANCE: OWNERS MAY NOT BE AWARE OF THE HANDLING AND MANUEVERING CHARACTERISTICS OF THIS VEHICLE INCREASING THE RISK OF A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL REPLACE THE SUN VISORS ON THE AFFECTED VEHICLES WITH VISORS CONTAINING THE CORRECT LABELS.

Notes

SYSTEM: EQUIPMENT; OTHER LABELS; PART 575. VEHICLE DESCRIPTION: 2-WHEEL DRIVE PASSENGER MULTI-PURPOSE VEHICLE. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN JULY 10, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Other Toyota 4Runner model years

Check your 1996 Toyota 4Runner VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota 4Runner at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN