NHTSA vehicle safety data

1999 Toyota 4Runner Recalls, Ratings & Complaints

The 1999 Toyota 4Runner has 2 NHTSA recall campaigns and 220 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 1999 Toyota 4Runner, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1999 Toyota 4Runner owner complaints

Owners have filed 220 complaints with NHTSA about the 1999 Toyota 4Runner, describing incidents dated January 1, 1998 to June 25, 2023.

Most-cited components

Structure 111 complaints
Suspension 61 complaints
Unknown or Other 34 complaints
Fuel/Propulsion System 24 complaints
Power Train 17 complaints
Steering 14 complaints

Of the 220 complaints on file, 12 report a crash and 2 a fire; across all 220 complaints, owners report 7 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11528720 · Filed June 25, 2023
The frame above the RT rear tire has rusted completely through. It's where the rear end bolts to the frame, at a wedge welded to the frame with bolt holes in it. It's like it wants to flip over and darts left or right every time there's a dip or rough spot in the road. I chained it and put a tow…
ODI #11487184 · Filed September 30, 2022
The contact's wife owns a 1999 Toyota 4Runner. The contact stated that while his daughter was driving at a slow speed, the back end of the vehicle began to wobble. The contact stated that his daughter pulled the vehicle into a parking lot and had the vehicle towed to the contact's home. The vehicle…
ODI #11437192 · Filed October 18, 2021
The component that is failing is the frame. The vehicle is available for inspection upon request. The safety of myself and others is at risk due to the frame falling apart due to the lack of integrity. The lack of integrity and strength is from oxidation or major rust. The vehicle has not been…

Read all 220 complaints

Owner-reported

1999 Toyota 4Runner mileage at failure

177 of the 220 complaints on file for the 1999 Toyota 4Runner give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 180,000 miles	Middle half 130,000–210,000 miles	Based on 89 complaints
Suspension	Median 180,000 miles	Middle half 150,000–215,000 miles	Based on 52 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

1999 Toyota 4Runner 4-DR. 4x4

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

220 owner complaints have been filed with NHTSA for the 1999 Toyota 4Runner.

Suspension

ODI #11528720

Incident: June 25, 2023 · Filed: June 25, 2023

The frame above the RT rear tire has rusted completely through. It's where the rear end bolts to the frame, at a wedge welded to the frame with bolt holes in it. It's like it wants to flip over and darts left or right every time there's a dip or rough spot in the road. I chained it and put a tow strap around everything I could to keep the rear end from coming out & killing me or someone behind me

Suspension

ODI #11487184

Incident: September 9, 2022 · Filed: September 30, 2022

The contact's wife owns a 1999 Toyota 4Runner. The contact stated that while his daughter was driving at a slow speed, the back end of the vehicle began to wobble. The contact stated that his daughter pulled the vehicle into a parking lot and had the vehicle towed to the contact's home. The vehicle was inspected and severe corrosion was discovered on the driver's side rear lower control arm mount. The dealer was notified of the failure and informed him that there are no recalls on the vehicle. The manufacturer was also notified of the failure and the contact was given the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 240,000.

Structure; Unknown or Other

ODI #11437192

Incident: June 1, 1999 · Filed: October 18, 2021

The component that is failing is the frame. The vehicle is available for inspection upon request. The safety of myself and others is at risk due to the frame falling apart due to the lack of integrity. The lack of integrity and strength is from oxidation or major rust. The vehicle has not been inspection by a 3rd party. The rust is a common issue in this year/model from other owners and has appeared to be a manufacturing error.

Steering; Suspension; Service Brakes

ODI #11420795

Incident: June 14, 2021 · Filed: June 14, 2021

Over the years of ownership, my vehicle has been overwhelmed with rust issues. All four axles are rusted to include the brake components. I didn't realize how bad the rusting was until I heard "popping" noise when making turns The rear suspension sway bar link was rusted so bad, it broke free. I had the rack and pinion replaced in August of 2020 because rust ate through the lines. The frame appears to have separations due to rust as well.

Suspension

ODI #11416238

Incident: April 5, 2021 · Filed: May 12, 2021

RIGHT REAR CHASSIS RUSTED OUT

Seats

ODI #11406561

Crash

Incident: February 18, 2021 · Filed: April 5, 2021

DRIVING EASTBOUND INTO PORTLAND (OR) ON HWY.26 (SUNSET HWY.), THREE LANES INBOUND. THREE LANES INBOUND, I WAS IN THE RIGHT LANE.AS WE NEARED THE TUNNELS, TRAFFIC STOPPED BUMPER-TO-BUMPER, AS IT OFTEN DOES. I STOPPED, LEAVING A SMALL BUFFER BETWEEN MY VEHICLE AND THE ONE AHEAD OF ME, AND WATCHED THE RED MAZDA CX-5 APPROACHING BEHIND, NOT SLOWING, AND BRACED FOR THE BUMP. BAM! IT WAS A SERIOUS JOLT. WE PULLED OFF ONTO THE SHOULDER. TRAFFIC WAS BUSY, SO IT TOOK A WHILE TO GET OUT TO INSPECT DAMAGE. I WAS EXPECTING MORE THAN I FOUND, AND ACTUALLY NOTICED NO DAMAGE AT THE TIME. THE MAZDA THAT HAD REAR-ENDED ME SUSTAINED SOME SERIOUS COSMETIC DAMAGE, BUT WAS STILL DRIVEABLE. WE TRADED INFO, AND I HEADED ON TO MT.HOOD TO SKI. A COUPLE OF DAYS LATER, I NOTICED THAT MY DRIVERS SEAT WAS A BIT WOBBLY. WHEN I GOT A CHANCE TO CHECK THE CAUSE,I FOUND THAT THE FRONT LEFT BOLT HOLDING THE SEAT WAS LOOSE.I TIGHTENED IT BACK DOWN.,BUT IT CAME LOOSE AGAIN AFTER THE EMBEDDED NUT CAME LOOSE FROM THE FRAME. A GOOGLE SEARCH REVEALED A PLEATHORA OF 4RUNNER AND TACOMA OWNERS ENCOUNTERING SIMILAR FAILURES.TO FIX, I DRILLED A 1/2" HOLE THROUGH THE BOLT HOLE AND THROUGH THE BOTTOM OF THE FRAME CHAMBER, RAN A 4"X1/2" STEEL BOLT THROUGH THE HOLE, FASTENED WITH A LARGE WASHER, LOCK WASHER, AND NUT, SOME THREAD-LOCK, AND SLATHERED ON THE BLACK SILICONE RTV. ALL DONE. SEEMS JUST FINE, NOW. CBS NEWS DID A STORY ON THEIR MORNING SHOW LAST THURSDAY, REGARDING DANGERS OF SIMILAR SEAT FAILURES IN HONDAS, I BELIEVE. I'M SURPRISED THAT THESE COMPANIES HAVE NOT DONE RECALLS ON THESE DESIGN FAILURES,ALREADY.

Unknown or Other

ODI #11396718

Incident: January 21, 2015 · Filed: February 17, 2021

THE FRAME IS RUSTING FROM THE INSIDE OUT

Structure

ODI #11396194

Incident: February 14, 2021 · Filed: February 14, 2021

MY FRAME IS RUSTED ALMOST TO PIECES. I KNOW THIS IS A COMMON PROBLEM WITH 4RUNNER OF THE SAME YEAR MODELS. AND I HOPE TO GET A RECALL BECAUSE IT'S PUTTING ME AND OTHERS AT RISK OF WRECKING THE CAR AND POSSIBLE INJURIES.

Seats

ODI #11366873

Incident: October 1, 2019 · Filed: October 28, 2020

TL* THE CONTACT OWNS A 1999 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE DRIVER'S SIDE FRONT SEAT ADJUSTER LEVER WAS FRACTURED. NEITHER THE LOCAL DEALER NOR THE MANUFACTURER WERE CONTACTED OR INFORMED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS 100,000.

Suspension

ODI #11364832

Incident: August 3, 2020 · Filed: October 17, 2020

MY VEHICLE IS VERY CLEAN AND WELL MAINTAINED AND HAD NO INDICATION OF TROUBLE OR HANDLING ISSUES. A REPAIR SHOP WAS TAKING IT BACK TO FIX AN EXHAUST PROBLEM WHEN HE NEARLY LOST CONTROL. I COULDN'T BELIEVE IT WHEN HE NOTIFIED ME IT WAS UNSAFE TO DRIVE, BUT FOUND OUT THAT ONE SECTION OF THE FRAME HAD TOTALLY RUSTED THROUGH WHERE THE AXLE LINK MOUNTS TO THE FRAME. IT COULD HAVE TORN THE AXLE OUT FROM UNDER THE VEHICLE WITH NO PREVIOUS WARNING. I HAD BEEN DRIVING ON 4 LANE INTERSTATE AT 70 JUST DAYS BEFORE WITH NO HANDLING ISSUES AT ALL. I PERSONALLY HAVE CHANGED THE OIL AND GREASED THE DRIVE TRAIN ALL BUT ONCE OVER THE PAST FIVE YEARS AND NOT NOTICED THIS SMALL AREA OF SEVERE RUST THROUGH. I HAVE ALSO SPENT OVER $3000 ON EXHAUST, TIRES, AND MAINTENANCE REPAIR OVER THE PAST YEAR BECAUSE I THOUGHT IT WAS WORTHY OF 5-10 MORE YEARS AND 100,000 MORE MILES. MY 2001 CAMRY IS DRIVEN BY MY SON NOW AND HAS APPROXIMATELY 390,000 MILES ON IT. I JUST SOLD MY 1994 JEEP CHEROKEE WITH OVER 300,000 MILES ON IT AND THIS 4RUNNER BODY IS IN MUCH BETTER CONDITION THAN THOSE AND THAT WAS WHY I EXPECTED THIS WOULD TOO. THIS IS DEFINITELY A WEAK SPOT HARD TO DETECT BECAUSE MYSELF AND 3 OTHER MECHANIC PLACES HAD NOT SEEN IT WHEN SERVICING IT BUT YET IT IS ALSO A VERY CRITICAL FUNCTION THAT CAN CAUSE COMPLETE LOSS OF CONTROL WHEN THE LEFT SIDE OF THE AXLE IS TORN LOOSE AND OUT FROM THE VEHICLE. HEAD-ON COLLISIONS, ROLLOVERS, ETC ARE VERY LIKELY. THEREFORE, I BELIEVE THAT THIS WARNING MUST BE MADE KNOWN TO OTHER DRIVERS OF THESE 4RUNNERS AND A RECALL TO REPLACE THE FRAME AS NEEDED JUST LIKE TOYOTA HAS DONE FOR OTHER TRUCKS OF THEIRS, I.E. TUNDRA, SEQUOIA, TACOMA WITH FULL FRAME LIKE THIS. THANK YOU FOR YOUR CONSIDERATION OF THIS FOR PROTECTION OF OUR PUBLIC.I HAVE PLENTY MORE PHOTOS OF THE VEHICLE THAT I CAN SHARE TO SUBSTANTIATE THE SOUNDNESS OF THE REST OF THE VEHICLE OR BAD SPOT RUSTING.

Other Toyota 4Runner model years

Check your 1999 Toyota 4Runner VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota 4Runner at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN