NHTSA vehicle safety data

1997 Toyota 4Runner Recalls, Ratings & Complaints

The 1997 Toyota 4Runner has 4 NHTSA recall campaigns and 139 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 1997 Toyota 4Runner, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1997 Toyota 4Runner owner complaints

Owners have filed 139 complaints with NHTSA about the 1997 Toyota 4Runner, describing incidents dated June 15, 1996 to April 7, 2023.

Most-cited components

Structure 69 complaints
Suspension 65 complaints
Unknown or Other 17 complaints
Power Train 11 complaints
Steering 10 complaints
Vehicle Speed Control 7 complaints

Of the 139 complaints on file, 12 report a crash and 2 a fire; across all 139 complaints, owners report 8 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11523903 · Filed May 25, 2023
I have had this vehicle since 12/1997 and it had always been garaged. The body is in very good condition. I live in northern Wisconsin and road salt is prevalent during the harsh winters. At the first part od April I was driving on Hwy, 47 toward Minocqua and suddenly the steering felt vague. I…
ODI #11360061 · Filed September 20, 2020
PURCHASED A USED 1997 4-RUNNER WITH CA. 258000 MILES EARLY IN 2020. ENGINE AND WHOLE BODY WAS GOOD. HOWEVER, 6 MONTH LATER THE CAR STARTED TO SHAKE VIOLENTLY IN THE REAR AT HIGHWAY SPEEDS SWINGING LIKE A BOAT, WHICH I THOUGH WAS DUE TO A BROKEN SHOCK, SPRINGS WERE NEWLY INSTALLED IN 2020. I NOTICED…
ODI #11316783 · Filed March 7, 2020
MY FIANCE AND I WERW DRIVING A BORROWERED 1997 TOYOTA 4RUNNER. WE WERE DRIVING AT 65 M AND ALL I REMEMBER JUST GETTIN ON THE FREEWAY.AND BLANKING OUT.. WHEN I WOKE UP I SADLY DISCOVERD THAT MY FIANCE LOST CONTROL AND VEERED TO THE RIGHT AND HIT A GUARDRAIL THEN A POST SIGN AND THEN RESTED ON A…

Read all 139 complaints

Owner-reported

1997 Toyota 4Runner mileage at failure

118 of the 139 complaints on file for the 1997 Toyota 4Runner give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 180,000 miles	Middle half 150,000–215,000 miles	Based on 64 complaints
Suspension	Median 170,000 miles	Middle half 150,000–225,000 miles	Based on 53 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

TOYOTA/REAR SUSPENSION

NHTSA #02V021000 · Suspension · NHTSA notice

Reported January 18, 2002 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 273,743 vehicles

Toyota campaign SSC 20A · Owners notified February 28, 2002 · Vehicles built November 20, 1995 – February 28, 1998 (per NHTSA)

Defect description

ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.

Safety consequence

THIS MAY RESULT IN A LOSS OF CONTROL AND COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE REAR SUSPENSION PARTS. ALTHOUGH THE 4WD 4RUNNERS DO NOT EXHIBIT THE HANDLING CONDITION, TOYOTA WILL RECALL THESE VEHICLES TO AVOID ANY PUBLIC CONFUSION AS TO WHICH VEHICLES SHOULD RECEIVE THE REPLACEMENT PARTS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. SSC 20A.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

1997 Toyota 4Runner 4-DR. 4x4

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 3

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

139 owner complaints have been filed with NHTSA for the 1997 Toyota 4Runner.

Suspension

ODI #11523903

Incident: April 7, 2023 · Filed: May 25, 2023

I have had this vehicle since 12/1997 and it had always been garaged. The body is in very good condition. I live in northern Wisconsin and road salt is prevalent during the harsh winters. At the first part od April I was driving on Hwy, 47 toward Minocqua and suddenly the steering felt vague. I moved the steering wheel slighlty and the vehicle went out of control, I managed to avoid oncoming traffic and pulled to the side of the road. I was still near home and drove very slowly to get home. Upon examining the cundercarriage at a local mechanic, we found that the frame was rusted and had broken where the rear trailing arm is attached, leaving the rear axle loose. I ended up giving the car to the mechanic. After driving it for 26 years it was a very sad moment since ran great and was my daily driver. I called Toyota and they told my vehicle was not included in the recall for

Suspension; Power Train

ODI #11360061

Incident: July 20, 2020 · Filed: September 20, 2020

PURCHASED A USED 1997 4-RUNNER WITH CA. 258000 MILES EARLY IN 2020. ENGINE AND WHOLE BODY WAS GOOD. HOWEVER, 6 MONTH LATER THE CAR STARTED TO SHAKE VIOLENTLY IN THE REAR AT HIGHWAY SPEEDS SWINGING LIKE A BOAT, WHICH I THOUGH WAS DUE TO A BROKEN SHOCK, SPRINGS WERE NEWLY INSTALLED IN 2020. I NOTICED THAT REAR STABILIZER ARM ON PASSENGER SIDE HAD BROKEN OFF DUE TO RUST. WHEN DRIVING TO REPAIR SHOP THE CAR REAR AXLE BROKE LOOSE, SHIFTED, AND THE REAR DRIVE SHAFT FELL OUT - I COULD PULL OVER IN 4 WHEEL DRIVE MODE. PLEASE KNOW THAT THE RUST AN EXTENSIVE FRAME ROT ON THE THE REAR FRAME ON BOTH SIDES WAS NOT VERY VISIBLE FROM OUTSIDE. REPAIRS FOR FRAME WELD WERE 2500 -3000 USD. THE 1997 4-RUNNER, V6 IS A VERY UNSAFE VEHICLE TO DRIVE!

Tires; Unknown or Other; Air Bags

ODI #11316783

Crash 1 injury1 death

Incident: February 4, 2014 · Filed: March 7, 2020

MY FIANCE AND I WERW DRIVING A BORROWERED 1997 TOYOTA 4RUNNER. WE WERE DRIVING AT 65 M AND ALL I REMEMBER JUST GETTIN ON THE FREEWAY.AND BLANKING OUT.. WHEN I WOKE UP I SADLY DISCOVERD THAT MY FIANCE LOST CONTROL AND VEERED TO THE RIGHT AND HIT A GUARDRAIL THEN A POST SIGN AND THEN RESTED ON A TREE..HE PASSED AWAY ON IMPACT. I SUFFERED A T1 TO T3 SPINE FRACTURE.MY LEFT WRIST FRACTURED.A BROKEN NOSE. AS I WOKE UP FROM MY 3 WEEK COMA. I REALISED HE PASSED AWAY. NOW THE TRUCK WAS BORRWED, NOT LENDED OR BOUGHT. THE DEALER GAVE US THE KEYS TO USE WHILE HE FIXED THE CAR WE RENTED .. NO PAPERS SIGNED NOR DOCUMENTS . EARLIER THAT DAY I REMEMBER HIM CALLING ME SAYING THAT THE TRUCK WAS MAKING WIERED NOISES. THE ACCIDENT HAPPEND ON 2/4/14 A 6.15.PM *DT *AS

Vehicle Speed Control

ODI #11316570

Crash 1 injury1 death

Incident: February 4, 2014 · Filed: March 6, 2020

TL* THE CONTACT WAS LOANED A 1997 TOYOTA 4RUNNER. THE CONTACT MENTIONED THE VEHICLE WAS LOANED FROM A USED DEALER (MCFARLAND AUTO SALES LOCATED AT 231 FRONTAGE RD MC, MCFARLAND, CA 93250). THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING 65 MPH, THE VEHICLE VEERED TO THE RIGHT INDEPENDENTLY CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. AS A RESULT, THE DRIVER CRASHED INTO A GUARD RAIL, A WOODEN POST, A FENCE AND CAME TO A STOP AT A TREE. THE CONTACT DOES NOT REMEMBER IF THE FRONT DRIVER AIR BAG DEPLOYED, BUT STATED THE FRONT PASSENGER SIDE AIR BAG DID DEPLOY. THE CONTACT STATED SHE SUSTAINED A FRACTURE NOSE, SPINE, LEFT WRIST, RIGHT LUNG WAS PUNCTURED, AND 3 FRACTURED RIBS ON HER LEFT. THE CONTACT STATED SHE WAS IN A COMA AND HOSPITALIZED FOR 3 WEEKS. THE DRIVER WAS PRONOUNCED DECEASED AT THE SCENE. THE VEHICLE WAS NOT DRIVE-ABLE AND WAS TOWED TO AN INDEPENDENT TOW LOT. A POLICE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE. *LN

Suspension

ODI #11300559

Incident: December 20, 2019 · Filed: January 20, 2020

REAR FRAM STABILIZER BRACE RUSTED OUT AND BROKE AWAY FROM FRAME, SO AXLE TO FRAME STALIZER DOES NOT STABILIZE REAR AXLE

Suspension; Structure; Unknown or Other

ODI #11235080

Incident: July 26, 2019 · Filed: July 26, 2019

VERY RUSTED OUT UNDERCARRIAGE. MY OTHER IS ONLY 3 YEARS NEWER AND HAS NOTHING LIKE THIS ON IT. I WAS ADVISED TO SELL IT BY A SUSPENSION SHOP THAT NOTED MY BROKEN, RUSTED OUT UNDERCARRIAGE, BAD SHOCK AND THE CONDITION OF THE REAR OF THE TRUCK'S FRAME IN GENERAL. THERE IS NOTHING WRONG WITH THE TRUCK OTHER THAN THIS RUST.

Suspension; Structure

ODI #11208714

Incident: May 1, 2019 · Filed: May 20, 2019

FRAME RUST MAKES VEHICLE DANGEROUS WHILE DRIVING.

Structure; Unknown or Other

ODI #11184202

Incident: March 4, 2019 · Filed: March 4, 2019

HEY I HAVE A 1997 4 RUNNER I HAVE A PROBLEM OF THE FRAME GETTING RUSTED OUT. IT IS ON THE 4 LINK WHERE IT HOOKS TO THE AXLE IT COULD HAVE KILLED ME MY REAR AXLE ABOUT CAME OFF AND IT ALMOST GOT ME INTO A RECK. ALL I DONE IS HIT THE BRAKES THEN HURT POP AND REAR END WENT CRAZY. I WAS ON A BUSY CITY STEET WHEN IT HAPPENED

Suspension; Structure

ODI #11173583

Incident: January 30, 2019 · Filed: February 1, 2019

TL* THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. WHILE REVERSING OUT OF THE DRIVEWAY, THE VEHICLE SWAYED BACK AND FORTH. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED AND THERE WAS NOTHING SUPPORTING THE STABILIZER ARM. FOX TOYOTA (228 FOX FAMILY LN, CLINTON, TN 37716, (865)-494-0228) WAS CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 271,000.

Structure

ODI #11165289

Incident: December 26, 2018 · Filed: January 4, 2019

THE FRAME SNAPPED FROM RUST AS I WAS DRIVING

Other Toyota 4Runner model years

Check your 1997 Toyota 4Runner VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota 4Runner at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN