try.vin
Log in

NHTSA vehicle safety data

2006 Thomas Built Buses SAF-T-Liner C2 Recalls & Complaints

The 2006 Thomas Built Buses SAF-T-Liner C2 has 21 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Thomas Built Buses dealer.

NHTSA recall and complaint data for the 2006 Thomas Built Buses SAF-T-Liner C2. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Thomas Built Buses SAF-T-Liner C2 owner complaints

Owners have filed 2 complaints with NHTSA about the 2006 Thomas Built Buses SAF-T-Liner C2, describing incidents dated April 23, 2007 to February 3, 2011.

Most-cited components

  • Electrical System 1 complaint
  • Equipment 1 complaint
  • Parking Brake 1 complaint

Of the 2 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #10395455 · Filed

    2006 THOMAS/FREIGHTLINER SCHOOL BUS CAUGHT FIRE AND BURNT WHILE PARKED. INVESTIGATION FOUND FIRE ORIGIN FROM FLOOR MOUNTED BATTERY CABLES TO THE LEFT OF DRIVER'S SEAT. FURTHER INVESTIGATION INTO NINE SIMILAR BUSES IN THE FLEET FOUND HEAVY CORROSION AT THE BATTERY CABLE ISOLATORS IS OCCURRING WHICH…

  • ODI #10189089 · Filed

    AIR BRAKES WOULD NOT RELEASE. REPLACED CMU PART NUMBER 06-34530-006, PART HAD WATER INSIDE UNIT. THIS IS THE SECOND REPLACEMENT FOR THIS SCHOOL BUS. THE BUS IS A 2006 THOMAS SAF-T-LINER 72 PASSENGER. THE CMU IS LOCATED BEHIND THE BATTERY BOX ON THE DRIVER SIDE. THIS SECOND UNIT WAS SUPPOSED TO BE AN…

Read all 2 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Thomas Built Buses SAF-T-Liner C2 in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #18V083000 · Equipment · NHTSA notice

Reported January 30, 2018 · Daimler Trucks North America LLC

Potentially affected: 606 vehicles

Repair completion: 1.49% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-759 · Owners notified April 11, 2018 · Vehicles built April 15, 2002 – December 11, 2015 (per NHTSA)

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Pocket Track may not Anchor Wheelchair in a Crash

NHTSA #17V453000 · Equipment · NHTSA notice

Reported July 17, 2017 · Daimler Trucks North America LLC

Potentially affected: 1,462 vehicles

Repair completion: 37.21% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-743 · Owners notified December 20, 2017 · Vehicles built December 1, 2004 – May 30, 2017 (per NHTSA)

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 school buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.

Safety consequence

In the event of a crash, an unsecured wheelchair may increase the risk of injury.

Manufacturer remedy

DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim notice was sent to owners on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Pocket Track may not Anchor Wheelchair in a Crash

NHTSA #17V454000 · Equipment · NHTSA notice

Reported July 17, 2017 · Daimler Trucks North America LLC

Potentially affected: 32 vehicles

Repair completion: 28.13% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-743 · Owners notified December 20, 2017 · Vehicles built December 1, 2004 – May 30, 2017 (per NHTSA)

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 transit buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair.

Safety consequence

In the event of a crash, an unsecured wheelchair may increase the risk of injury.

Manufacturer remedy

DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim letter was mailed on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Wheel Chair Lift Link Arm Pivot Holes

NHTSA #15V565000 · Equipment Adaptive/Mobility · NHTSA notice

Reported September 4, 2015 · Daimler Trucks North America LLC

Potentially affected: 4,334 vehicles

Repair completion: 1.5% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-686 · Owners notified November 2, 2015 · Vehicles built January 3, 2006 – August 1, 2014 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Safety consequence

If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Manufacturer remedy

DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-686.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Exterior Emergency Door Handle may Detach

NHTSA #15V432000 · Structure — Body — Door · NHTSA notice

Reported July 7, 2015 · Daimler Trucks North America LLC

Potentially affected: 103,038 vehicles

Repair completion: 40.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-685 · Owners notified December 24, 2015 · Vehicles built February 5, 2001 – May 29, 2012 (per NHTSA)

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 school buses manufactured from February 5, 2001, through May 29, 2012. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.

Safety consequence

If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.

Manufacturer remedy

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. Daimler issued an interim notification to owners on August 25, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Exterior Emergency Door Handle may Detach

NHTSA #15V425000 · Structure — Body — Door · NHTSA notice

Reported July 6, 2015 · Daimler Trucks North America LLC

Potentially affected: 3,013 vehicles

Repair completion: 14.58% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign FL-685 · Owners notified December 24, 2015

Defect description

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 non-school buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode.

Safety consequence

If the stem corrodes, the door handle could detach from the emergency door opening mechanism, delaying the opening of the door and the evacuation of the bus. In the event of an emergency, this may increase the risk of injury to the bus occupants.

Manufacturer remedy

DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was mailed to owners on August 28, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

PASS-THROUGH POWER STUDS/POSSIBLE FIRE

NHTSA #11V503000 · Electrical System · NHTSA notice

Reported October 18, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 3,109 vehicles

Manufacturer campaign FL-616 · Owners notified December 15, 2011 · Vehicles built April 5, 2004 – December 26, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2004 THROUGH DECEMBER 26, 2005. THE PASS-THROUGH POWER CABLE CONNECTIONS LOCATED BEHIND THE DRIVER'S SIDE KICK PANEL MAY CORRODE POTENTIALLY RESULTING IN AN ELECTRIC FAULT OR SHORT CIRCUIT.

Safety consequence

AN ELECTRIC FAULT OR SHORT CIRCUIT OF AN UN-FUSED POWER CABLE MAY RESULT IN A VEHICLE FIRE.

Manufacturer remedy

THE FINAL REMEDY IS BEING DEVELOPED. DTNA WILL SEND OWNERS AN INTERIM NOTICE ADVISING THEM TO INSPECT THEIR BUSES FOR CORROSION IN THE AREA OF THE POWER TERMINALS, AND IF EXCESSIVE CORROSION IS FOUND, TO TAKE THEIR VEHICLE TO AN AUTHORIZED SERVICE FACILITY. REPAIRS WILL BE MADE BY DTNA FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-616.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

BRAKE LINE CHAFE

NHTSA #11V505000 · Service Brakes, Hydraulic · NHTSA notice

Reported October 18, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 700 vehicles

Manufacturer campaign FL-615 · Owners notified December 27, 2011 · Vehicles built March 9, 2004 – January 2, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 9, 2004, THROUGH JANUARY 2, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES, HYDRAULIC BRAKES, AND A FUEL WATER SEPARATOR. THE FUEL LINE GOING FROM THE FUEL WATER SEPARATOR TO THE ENGINE MAY RUB ON THE HYDRAULIC BRAKE LINES POTENTIALLY RESULTING IN BRAKE FLUID LEAK.

Safety consequence

A BRAKE FLUID LEAK MAY REDUCE BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLES TO ENSURE THAT THERE IS THE CORRECT CLEARANCE BETWEEN THE FUEL AND BRAKE LINES. DAMAGED LINES WILL BE REPLACED. REPAIRS WILL BE MADE BY DTNA AUTHORIZED SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-615.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

GEN EM-1 EVAPORATORS/CARRIER

NHTSA #11V222000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported April 6, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,831 vehicles

Manufacturer campaign FL-604 · Owners notified May 20, 2011 · Vehicles built January 2, 2006 – January 31, 2011 (per NHTSA)

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Safety consequence

IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-604.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

TIRE LOAD RANGE CERTIFICATION LABEL

NHTSA #11V201000 · Equipment — Other — Labels · NHTSA notice

Reported March 31, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,360 vehicles

Manufacturer campaign FL-601 · Owners notified May 17, 2011 · Vehicles built April 17, 2000 – December 21, 2009 (per NHTSA)

Defect description

CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Safety consequence

INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-601.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

HYDRAULIC BRAKE SWITCHES

NHTSA #10V177000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported April 30, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,548 vehicles

Manufacturer campaign FL-577 · Owners notified May 27, 2011 · Vehicles built January 19, 2005 – April 16, 2010 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

Safety consequence

THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-577.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

ADJUSTABLE BRAKE PEDAL ASSEMBLIES

NHTSA #09V461000 · Service Brakes, Hydraulic — Pedals and Linkages · NHTSA notice

Reported December 1, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 2,631 vehicles

Manufacturer campaign FL-569 · Owners notified December 22, 2009 · Vehicles built October 5, 2004 – November 25, 2009 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES BUILT ON FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 15, 2004 THROUGH NOVEMBER 25, 2009, EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

Safety consequence

A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712.

Notes

DAIMLER TRUCKS' CAMPAIGN NUMBER IS FL-569.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

IMPROPER HANDRAIL INSTALLATION

NHTSA #09V010000 · Structure — Body — Door — Hinge and Attachments · NHTSA notice

Reported January 8, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 22,206 vehicles

Manufacturer campaign FL-543 · Owners notified April 14, 2009 · Vehicles built October 1, 2004 – November 24, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS IS RECALLING 22,206 THOMAS BUILT MY 2005 THROUGH 2010 SCHOOL BUSES MANUFACTURED FROM OCTOBER 2004 THROUGH NOVEMBER 24, 2008. THE LOWER END OF THE FRONT ENTRANCE DOOR AFT ASSIST HANDRAIL MAY BE LOCATED TOO CLOSE TO THE STEP.

Safety consequence

IT MAY BE POSSIBLE FOR ITEMS SUCH AS DRAWSTRINGS AND STRAPS TO BECOME CAUGHT ON THE HANDRAILS POTENTIALLY LEADING TO INJURY OR DEATH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS AND DIRECT WARRANTY CUSTOMER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 6, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Notes

DAIMLER TRUCKS' RECALL NO. FL-543.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRACTURED FUEL LINES OR TRANSFER TUBES/FIRE

NHTSA #08V668000 · Fuel System, Other — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported December 17, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 24,650 vehicles

Manufacturer campaign FL-542 · Owners notified March 9, 2009 · Vehicles built March 9, 2004 – August 18, 2006 (per NHTSA)

Defect description

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE.

Safety consequence

A FRACTURED FUEL LINE MAY LEAK DIESEL FUEL POSSIBLY RESULTING IN A FIRE OR FUEL MAY BE SPILLED ON THE ROAD CAUSING A SLIPPERY SURFACE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.

Notes

DTNA'S RECALL NO. FL-452.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AIR MANAGEMENT UNIT (AMU) PRESSURE SWITCH

NHTSA #08V602000 · Exterior Lighting — Brake Lights · NHTSA notice

Reported November 19, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 15,686 vehicles

Manufacturer campaign FL-538 · Owners notified March 18, 2009 · Vehicles built March 1, 2005 – May 31, 2008 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING.

Safety consequence

INOPERATIVE BRAKE LAMPS WOULD NOT PROVIDE A SIGNAL TO FOLLOWING DRIVERS THAT THE BRAKES ARE APPLIED AND A CRASH MAY OCCUR.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.

Notes

DAIMLER TRUCKS' RECALL NO. FL-538.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 403/BRAUN WHEELCHAIR LIFTS/THRESHOLD WARNING

NHTSA #08V088000 · Equipment Adaptive/Mobility · NHTSA notice

Reported February 26, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 760 vehicles

Manufacturer campaign FL-524 · Owners notified August 8, 2008 · Vehicles built July 6, 2005 – July 19, 2006 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Safety consequence

SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Notes

DAIMLER TRUCKS RECALL NO. FL-524.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

EMERGENCY EXIT DOOR HANDLE

NHTSA #08V087000 · Structure — Body — Door — Hinge and Attachments · NHTSA notice

Reported February 26, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 243,435 vehicles

Manufacturer campaign FL-525 · Owners notified August 18, 2008 · Vehicles built January 1, 1994 – March 10, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.

Safety consequence

IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Notes

DAIMLER TRUCKS RECALL NO. FL-525.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 217/ROOF EMERGENCY EXIT

NHTSA #07V459000 · Structure · NHTSA notice

Reported September 21, 2007 · FREIGHTLINER LLC

Potentially affected: 3,581 vehicles

Manufacturer campaign FL-510 · Owners notified December 4, 2007 · Vehicles built March 8, 2006 – August 10, 2007 (per NHTSA)

Defect description

CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.

Safety consequence

IMPROPERLY IDENTIFIED EMERGENCY EXITS MAY HINDER EVACUATION EFFORTS.

Manufacturer remedy

THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-510.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SR-7 SPRING BRAKE VALVE ASSEMBLY/BENDIX/PARKER

NHTSA #07V302000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice

Reported July 16, 2007 · FREIGHTLINER LLC

Potentially affected: 75,000 vehicles

Manufacturer campaign FL-504 · Owners notified January 11, 2008 · Vehicles built July 1, 2002 – July 3, 2007 (per NHTSA)

Defect description

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.

Safety consequence

THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Manufacturer remedy

FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS NO. 301/FUEL FILL TUBE

NHTSA #07V250000 · Fuel System, Other — Delivery · NHTSA notice

Reported June 13, 2007 · FREIGHTLINER LLC

Potentially affected: 7,192 vehicles

Manufacturer campaign FL-498 · Owners notified August 10, 2007 · Vehicles built December 1, 2003 – October 10, 2006 (per NHTSA)

Defect description

CERTAIN MY 2005-2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN DECEMBER 1, 2003, AND OCTOBER 10, 2006. FASTENERS USED TO SECURE THE FUEL TUBE MOUNTING BRACKET TO THE BUS FLOOR MAY BE MISSING OR IMPROPERLY INSTALLED. VEHICLES WITH MISSING OR IMPROPERLY INSTALLED FUEL FILL TUBE MOUNTING BRACKET FASTENERS DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY."

Safety consequence

THIS COULD RESULT IN FUEL SPILLAGE DURING OR AFTER A VEHICLE CRASH POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-498.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

EXTERNAL WARNING LIGHTS MALFUNCTION

NHTSA #07V212000 · Exterior Lighting · NHTSA notice

Reported May 18, 2007 · FREIGHTLINER LLC

Potentially affected: 9,970 vehicles

Manufacturer campaign FL-496 · Owners notified January 21, 2008 · Vehicles built December 1, 2003 – May 18, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN 2005 THROUGH 2008 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM DECEMBER 1, 2003 TO MAY 18, 2007. THE EXTERNAL WARNING LIGHTS MAY STOP FUNCTIONING UNEXPECTEDLY IF THE FRONT ENTRANCE DOOR CLOSES WITHOUT THE DRIVER'S INPUT.

Safety consequence

FAILURE OF THE EXTERNAL WARNING LIGHTS TO REMAIN ON DURING THE LOADING OR UNLOADING PROCESS COULD POSSIBLY RESULT IN A STUDENT BEING STRUCK BY A PASSING MOTORIST WHILE BOARDING OR EXITING THE BUS.

Manufacturer remedy

FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-496.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Thomas Built Buses SAF-T-Liner C2 model years

Check your 2006 Thomas Built Buses SAF-T-Liner C2 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Built Buses SAF-T-Liner C2 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thomas Built Buses VIN