try.vin
Log in

NHTSA vehicle safety data

2008 Peterbilt 387 Recalls & Complaints

The 2008 Peterbilt 387 has 14 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Peterbilt dealer.

NHTSA recall and complaint data for the 2008 Peterbilt 387. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 Peterbilt 387 owner complaints

Owners have filed 4 complaints with NHTSA about the 2008 Peterbilt 387, describing incidents dated November 5, 2007 to August 2, 2015.

Most-cited components

  • Engine 3 complaints
  • Electrical System 1 complaint
  • Fuel/Propulsion System 1 complaint
  • Power Train 1 complaint
  • Service Brakes 1 complaint

Newest complaints

  • ODI #10782295 · Filed

    BEFORE THE ABOVE TRUCK WAS PURCHASED, OF NOTE IS THAT THE CHECK ENGINE LIGHT WAS ON, AS WELL AS AFTER THE PURCHASE OF SAME TRUCK. FUSSELL TRUCK SALES RESET THE ENGINE LIGHT ON WEDNESDAY, SEPTEMBER 23, 2015. I PLACED VEHICLE ON A DIAGNOSTIC COMPUTER ON TODAY, SEPTEMBER 29TH, 2015, AND WAS NOTIFIED…

  • ODI #10725891 · Filed

    TL* THE CONTACT OWNS A 2008 PETERBILT 387. WHILE DRIVING VARIOUS SPEEDS, THE DPF MALFUNCTIONED AND CAUSED THE ENGINE TO OVERHEAT AND THE VEHICLE TO STALL. NO FURTHER INFORMATION WAS AVAILABLE. THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE FAILURE ON MULTIPLE OCCASIONS AND HAD BEEN SERVICED…

  • ODI #10617036 · Filed

    FIRST, MY TURBO WENT OUT JUNE24TH 2014. SECOND THE D.P.F FILTER AND SENSORS. I ONLY HAD THE TRUCK FOR 90DAYS AND ALREADY SPENT OVER 9000 DOLLARS ON IT. *JS

Read all 4 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2008 Peterbilt 387 in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

Driver not Warned when ABS Offline/FMVSS 121, 136

NHTSA #20V199000 · Electronic Stability Control (ESC) · NHTSA notice

Reported April 6, 2020 · PACCAR Incorporated

Potentially affected: 460,515 vehicles

Repair completion: 33.98% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 20pbc AND 20KWB · Owners notified May 26, 2020

Defect description

PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."

Safety consequence

If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.

Manufacturer remedy

PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Incorrect Tire Information on Label/FMVSS 110

NHTSA #15V132000 · Equipment — Other — Labels · NHTSA notice

Reported March 6, 2015 · PACCAR Incorporated

Potentially affected: 213,230 vehicles

Repair completion: 91.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 215-D · Owners notified June 19, 2015 · Vehicles built July 25, 2005 – February 26, 2016 (per NHTSA)

Defect description

PACCAR Incorporated (PACCAR) is recalling certain model year 2006-2016 Peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured July 25, 2005, to February 26, 2016. The affected vehicles may be equipped with Tire and Rim Certification Labels that list a tire pressure below the actual correct amount. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 120, "Tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."

Safety consequence

If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (GVWR) load listed without experiencing tire failure which would increase the risk of a crash.

Manufacturer remedy

Peterbilt will notify owners and mail them a corrected Tire and Rim certification label, free of charge. The recall began on June 19, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 215-D.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

KENWORTH/PETERBILT/FAST IDLE CONTROL

NHTSA #11V380000 · Electrical System — Software · NHTSA notice

Reported July 21, 2011 · PACCAR INCORPORATED

Potentially affected: 211 vehicles

Manufacturer campaign E038R · Owners notified August 22, 2011 · Vehicles built April 20, 2010 – June 11, 2011 (per NHTSA)

Defect description

PACCAR IS RECALLING CERTAIN MODEL YEAR 2011-2012 KENWORTH T660, T700, AND T800 VEHICLES MANUFACTURED FROM APRIL 19, 2010, THROUGH MAY 13, 2011, AND MODEL YEAR 2008, 2010, AND 2011 PETERBILT 365, 367, 384, 386, 387, 388 AND 587 VEHICLES MANUFACTURED FROM APRIL 20, 2010, THROUGH JUNE 11, 2011, AND EQUIPPED WITH PACCAR MX ENGINES AND EATON ULTRASHIFT DM OR ALLISON AUTOMATIC TRANSMISSIONS (WITHOUT AUTO-NEUTRAL). THE FAST IDLE CONTROL MAY BE ACTIVATED BY THE OPERATOR WHILE THE TRANSMISSION IS IN GEAR.

Safety consequence

IF THE FAST IDLE CONTROL FUNCTION IS ENGAGED WITH THE TRANSMISSION IN GEAR, THE VEHICLE COULD UNEXPECTEDLY ACCELERATE AND OVERRIDE THE PARKING BRAKE AND , CREATING A RISK OF A CRASH AND DAMAGE TO OTHER VEHICLES OR PROPERTY AND THE POTENTIAL FOR INJURY TO NEARBY PEDESTRIANS.

Manufacturer remedy

KENWORTH AND PETERBILT DEALERS WILL UPDATE THE ENGINE SOFTWARE FOR THE AFFECTED CHASSIS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 22, 2011. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.

Notes

KENWORTH AND PETERBILT SAFETY RECALL NO. E038R.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

KENWORTH/PETERBILT/CENTRIFUGAL SPINNER CAP

NHTSA #11V127000 · Fuel System, Other — Storage — Tank Assembly · NHTSA notice

Reported February 23, 2011 · PACCAR INCORPORATED

Potentially affected: 4,664 vehicles

Manufacturer campaign E026R · Owners notified March 4, 2011

Defect description

PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2012 KENWORTH T2000, T660, T700, T800, AND W900, AS WELL AS MODEL YEAR 2009-2012 PETERBILT 365, 367, 384, 386, 387, 388, 389, AND 587 TRUCKS EQUIPPED WITH PACCAR MX ENGINES. THE OIL MODULE CENTRIFUGAL SPINNER FILTER CAP IN THE PACCAR MX ENGINE MAY BECOME LOOSE, POSSIBLY ALLOWING THE CAP TO COME OFF AND ENGINE OIL TO PARTIALLY DISCHARGE FROM THE OIL MODULE ONTO EXHAUST COMPONENTS.

Safety consequence

THE DISCHARGE OF ENGINE OIL ONTO EXHAUST COMPONENTS WHICH ARE HOT, SUCH AS WHEN THE ENGINE IS UNDER SIGNIFICANT LOAD, MAY CAUSE A FIRE.

Manufacturer remedy

DEALERS WILL RE-TORQUE THE OIL MODULE FILTER CAP AND INSTALL A SECONDARY RETENTION DEVICE ON THE SECONDARY CENTRIFUGAL SPINNER FILTER CAP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

KENWORTH/PETERBILT/INTERAXLE DRIVELINE FAILURES

NHTSA #10V634000 · Power Train — Axle Assembly · NHTSA notice

Reported December 13, 2010 · PACCAR INCORPORATED

Potentially affected: 12,873 vehicles

Manufacturer campaign K-10KWL P-1201F · Owners notified March 4, 2011 · Vehicles built February 2, 2006 – April 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

PACCAR IS RECALLING CERTAIN MODEL YEAR 2007-2008 KENWORTH AND PETERBILT VEHICLES MANUFACTURED FROM FEBRUARY 2, 2006 THROUGH APRIL 30, 2007. THE BEARING SURFACES OF THE EXTENDED LUBE UNIVERSAL JOINT THAT ATTACHES THE INTER-AXLE DRIVELINE TO THE DRIVE AXLE MAY BECOME PREMATURELY WORN DUE TO BREAKDOWN OF LUBRICATION AND/OR EXCESSIVE HEAT. PREMATURELY WORN BEARING SURFACES MAY RESULT IN THE U-JOINT BECOMING LOOSE AND/OR BINDING. THIS CONDITION MAY RESULT IN UNIVERSAL JOINT FAILURE, ALLOWING THE INTER-AXLE DRIVELINE TO DETACH FROM THE AXLE.

Safety consequence

DETACHMENT OF THE DRIVELINE FROM THE AXLE MAY CAUSE THE VEHICLE TO LOSE POWER AND BECOME DISABLED IN THE ROADWAY. ALSO, THE DRIVELINE COULD DROP FROM THE VEHICLE INTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Manufacturer remedy

PACCAR IS WORKING WITH ITS SUPPLIER TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2011. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 940-591-4196.

Notes

KENWORTH RECALL NO. 10KWL & PETERBILT RECALL NO. 1201F.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

KENWORTH/PETERBILT/STEERING SHAFT WELD/TRW

NHTSA #10V308000 · Steering — Column · NHTSA notice

Reported July 2, 2010 · PACCAR INCORPORATED

Potentially affected: 9,697 vehicles

Manufacturer campaign 10KW-F & 0610-D · Owners notified July 30, 2010 · Vehicles built July 4, 2008 – April 20, 2009 (per NHTSA)

Defect description

PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2010 TRUCKS EQUIPPED WITH TRW STEERING SHAFTS. THE CIRCUMFERENTIAL WELD AROUND THE STEERING SHAFT TUBE THAT WELDS THE SPLINED TUBE TO THE NON-SPLINED TUBE MAY BE MISLOCATED. MISLOCATION OF THE CIRCUMFERENTIAL WELD MAY ALLOW THE SPLINED TUBE AND NON-SPLINED TUBE TO ROTATE RELATIVE TO ONE ANOTHER DURING A LOW SPEED, HIGH TORQUE TURN, POSSIBLY RESULTING IN A SEPARATION OF THE TWO TUBES.

Safety consequence

A SEPARATION OF THE SPLINED AND NON-SPLINED TUBES WOULD CAUSE A LOSS OF STEERING CONTROL AND INCREASE THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE STEERING SHAFT USING A WELD PLACEMENT GAUGE PROVIDED BY TRW. ANY STEERING SHAFT FOUND TO HAVE BEEN WELDED IMPROPERLY WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 30, 2010. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 940-591-4196.

Notes

KENWORTH'S RECALL CAMPAIGN NUMBER IS 10KW-F & PETERBILT RECALL NO. 0610-D. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

ARD EXTENSION PIPES/C15/CATERPILLAR

NHTSA #09V019000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported January 16, 2009 · PACCAR INCORPORATED

Potentially affected: 1,098 vehicles

Manufacturer campaign 09KW1 & 108A · Owners notified January 28, 2009 · Vehicles built February 12, 2007 – December 12, 2008 (per NHTSA)

Defect description

PACCAR IS RECALLING 1098 KENWORTH MY 2008 T800, W900, MY 2008-2009 T2000 AND PETERBILT MY 2007-2009 379 AND 387 TRUCKS EQUIPPED WITH C15 CATERPILLAR DIESEL ENGINES. THE AFTERTREATMENT REGENERATION DEVICE (ARD) MAY DEVELOP A HOLE AND HEAT AND FLAME MAY ESCAPE DURING A REGENERATION OF THE DIESEL PARTICULATE FILTER.

Safety consequence

THIS MAY RESULT IN A FIRE HAZARD.

Manufacturer remedy

PACCAR IS WORKING WITH CATERPILLAR AND WILL INSPECT AND REMEDY THE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, KENWORTH AT 425-828-5440 OR PETERBILT AT 940-591-4196.

Notes

KENWORTH RECALL NO. 09KW1 & PETERBILT RECALL NO. 108A.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

DPF BRACKET STRAPS/CATERPILLAR

NHTSA #08V487000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported September 23, 2008 · PACCAR INCORPORATED

Potentially affected: 4,883 vehicles

Manufacturer campaign 08KWD 908G · Owners notified September 18, 2008

Defect description

PACCAR IS RECALLING 4,883 MY 2006-2009 KENWORTH T600, T660, T800, W900, T2000 AND MY 2008-2009 PETERBILT 365, 367, 379, 384, 386, 387, 388 AND 389 TRUCKS. INADEQUATE STIFFNESS OF THE DIESEL PARTICULATE FILTER (DPF) BRACKET COULD RESULT IN SEPARATION OF THE DPF FROM THE CHASSIS.

Safety consequence

A VEHICLE CRASH COULD OCCUR IF ANOTHER VEHICLE STRIKES THE DPF ON THE ROADWAY.

Manufacturer remedy

PACCAR IS WORKING WITH CATERPILLAR TO REPAIR THESE VEHICLES (PLEASE SEE 08E041). OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4196.

Notes

KENWORTH RECALL NO. 08KWD AND PETERBILT RECALL NO. 908G.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 206/TRIMARK DOOR LATCH

NHTSA #08V065000 · Latches/Locks/Linkages — Doors — Latch · NHTSA notice

Reported February 7, 2008 · PACCAR INCORPORATED

Potentially affected: 6,169 vehicles

Manufacturer campaign 08KW1/108A · Owners notified March 14, 2008 · Vehicles built October 11, 2007 – January 10, 2008 (per NHTSA)

Defect description

PACCAR IS RECALLING 6,169 MY 2008 KENWORTH T300, T660, T800, T2000, W900 AND C500 VEHICLES AND MY 2008-2009 PETERBILT MODELS 365, 367, 384, 387, 388, 389 AND 389 KITS. CERTAIN DOOR LATCH ASSEMBLIES ON THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS." THE ROTOR IN SOME OF THESE DOOR LATCH ASSEMBLIES DID NOT RECEIVE THE PROPER HEAT TREATMENT AND MAY BE SOFT.

Safety consequence

IN THE EVENT OF A CRASH, FORCE COULD CAUSE THE ROTOR TO CRACK AND THE DOOR WOULD NOT HAVE PRIMARY OR SECONDARY CLOSING SECURITY WHICH COULD POSSIBLY LEAD TO INJURY OF THE VEHICLE OCCUPANT.

Manufacturer remedy

PACCAR IS WORKING WITH TRIMARK AND WILL INSPECT AND REPLACE THE DOOR LATCH IF IT IS FOUND TO BE DEFECTIVE. THE RECALL BEGAN ON MARCH 14, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4196.

Notes

KENWORTH RECALL NO. 08KW1 AND PETERBILT RECALL NO. 108A.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 106/AIR BRAKE HOSES/EATON SYNFLEX

NHTSA #08V002000 · Service Brakes, Air — Supply — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported January 8, 2008 · PACCAR INCORPORATED

Potentially affected: 2,794 vehicles

Manufacturer campaign 07KWF 1207L · Owners notified February 22, 2008 · Vehicles built October 16, 2007 – November 14, 2007 (per NHTSA)

Defect description

CERTAIN TRUCKS EQUIPPED WITH EATON SYNFLEX ECLIPSE BRAND EXTRUDED NYLON AIR BRAKE HOSE TUBING FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES." THE TUBING WAS MANUFACTURED WITH ONLY FOUR LAYERS OF NYLON MATERIAL, INSTEAD OF THE SPECIFIED FIVE LAYERS.

Safety consequence

THE DIAMETER OF THE HOSE AFFECTS THE FITTINGS WHICH MAY ALLOW AIR TO LEAK FROM THE BRAKES AND CREATE THE POTENTIAL FOR A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE AIR BRAKE HOSES AND, IF NECESSARY, REPLACE THE HOSES. THE RECALL BEGAN ON FEBRUARY 22, 2008. OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 OR PETERBILT AT 1-940-591-4196.

Notes

KENWORTH RECALL NO. 07KWF AND PETERBILT RECALL NO. 1207L.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING GEARS/TRW

NHTSA #07V591000 · Steering — Gear Box — Shaft Sector · NHTSA notice

Reported December 20, 2007 · PACCAR INCORPORATED

Potentially affected: 559 vehicles

Manufacturer campaign 07KWE & 1107K · Owners notified January 9, 2008 · Vehicles built August 24, 2007 – November 21, 2007 (per NHTSA)

Defect description

ON CERTAIN KENWORTH AND PETERBILT HEAVY DUTY TRUCKS EQUIPPED WITH TAS-85 TRW STEERING GEARS, THE INNER SURFACE OF THE OUTER SECTOR SHAFT TEETH OF THE STEERING GEARS MAY HAVE AN INCORRECT INVOLUTE PROFILE, WHICH MAY LEAD TO CHIPPING AND DAMAGE OF THE GEARING SYSTEM.

Safety consequence

THIS TYPE OF DAMAGE MAY CAUSE A "BIND/STICK" CONDITION IN THE VEHICLE STEERING DURING A TURN INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPAIR AND REPLACE ANY SUSPECT TAS-85 STEERING GEAR ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 9, 2008. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 940-591-4201.

Notes

KENWORTH RECALL NO. 07KWE, PETERBILT 1107K.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ALUMINUM FUEL TANK LONGITUDINAL WELD SEAMS

NHTSA #07V409000 · Fuel System, Diesel — Storage — Tank Assembly · NHTSA notice

Reported September 10, 2007 · PACCAR INCORPORATED

Potentially affected: 319 vehicles

Manufacturer campaign 807J · Owners notified October 8, 2007 · Vehicles built June 26, 2007 – July 31, 2007 (per NHTSA)

Defect description

ON CERTAIN PETERBILT TRUCKS, THE LONGITUDINAL SEAMS ON THE FUEL TANKS WERE FABRICATED USING AN INCORRECT WELD SPEED FOR THE GIVEN MATERIAL THICKNESS. THIS ERROR RESULTED IN A WELD WHICH DID NOT COMPLETELY PENETRATE THE ENTIRE MATERIAL THICKNESS.

Safety consequence

FUEL TANKS POSSESSING THIS DEFECT COULD LEAK DIESEL FUEL IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE ANY DEFECTIVE FUEL TANKS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 8, 2007. OWNERS MAY CONTACT PETERBILT AT 940-591-4201.

Notes

PETERBILT RECALL NO. 807J.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AXLE HOUSING/DANA

NHTSA #07V132000 · Power Train — Axle Assembly · NHTSA notice

Reported March 22, 2007 · PACCAR INCORPORATED

Potentially affected: 245 vehicles

Manufacturer campaign 07KW4 & 107C · Owners notified May 9, 2007 · Vehicles built November 27, 2006 – February 28, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.

Safety consequence

IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE AXLES FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 1-940-591-4196.

Notes

KENWORTH RECALL NO. 07KW4 & PETERBILT RECALL NO. 107C.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIR SUSPENSION MATERIAL

NHTSA #06V490000 · Suspension · NHTSA notice

Reported December 21, 2006 · PACCAR INCORPORATED

Potentially affected: 3,246 vehicles

Manufacturer campaign 1206D · Owners notified January 17, 2007 · Vehicles built August 16, 2006 – November 22, 2006 (per NHTSA)

Defect description

ON SOME PETERBILT TRUCKS, CERTAIN PARTS USED IN THE AIR SUSPENSIONS HAVE A HIGH COPPER CONTENT CAUSING PREMATURE FAILURE.

Safety consequence

FAILURE COULD CAUSE ERRATIC VEHICLE HANDLING WHICH CAN CAUSE A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT AND, WHEN NECESSARY, REPLACE THE DEFECTIVE PARTS. THE RECALL BEGAN ON JANUARY 17, 2007. OWNERS MAY CONTACT PETERBILT AT 1-940-591-4196.

Notes

PACCAR/PETERBILT RECALL NO. 1206D.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Peterbilt 387 model years

Check your 2008 Peterbilt 387 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Peterbilt 387 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Peterbilt VIN