NHTSA vehicle safety data

1999 Peterbilt 387 Recalls & Complaints

The 1999 Peterbilt 387 has 7 NHTSA recall campaigns on file as of October 21, 2026. try.vin has no NHTSA owner complaints on file for the 1999 Peterbilt 387. Recall repairs are usually free at an authorized Peterbilt dealer.

NHTSA recall and complaint data for the 1999 Peterbilt 387. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

PACCAR/ARVINMERITOR/SKF/FRONT AXLE HUBS

NHTSA #03V125000 · Suspension — Front — Hub · NHTSA notice

Reported April 1, 2003 · PACCAR INCORPORATED

Potentially affected: 154 vehicles

Manufacturer campaign 303-A/03KW2 · Owners notified July 16, 2003 · Vehicles built October 13, 1998 – March 26, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Safety consequence

SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.

Manufacturer remedy

DEALERS WILL REPLACE ALL FRONT AXLE HUBS. NOTIFICATION BEGAN JULY 16, 2003. THE MANUFACTURER HAS ADVISED US THAT PARTS WILL NOT BE AVAILABLE UNTIL SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITH A REASONABLE TIME SHOULD CONTACT PETERBILT AT 940-591-4201 OR KENWORTH 425-828-5440.

Notes

KENWORTH RECALL NO. 03KW2 AND PETERBILT RECALL NO. 303-A.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/ARVINMERITOR/TRW TIE ROD ENDS (20EDL)

NHTSA #02V037003 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported July 15, 2002 · PACCAR, INCORPORATED

Potentially affected: 4,513 vehicles

Manufacturer campaign 102A/02KW2 · Owners notified July 15, 2002 · Vehicles built December 11, 1999 – September 30, 2000 (per NHTSA)

Defect description

HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN ARVINMERITOR AND DANA AXLES. PETERBILT WILL RECALL 1,434 VEHICLES EQUIPPED WITH ARVINMERITOR AXLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 14, 2000, AND FROM JULY 22 TO SEPTEMBER 30, 2000. KENWORTH WILL RECALL 859 VEHICLES EQUIPPED WITH ARVINMERITOR VEHICLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 23, 2000, AND FROM JULY 27, 2000, TO SEPTEMBER 30, 2000 AND KENNWORTH WILL RECALL AN ADDITIONAL 4,151 VEHICLES EQUIPPED WITH DANA AXLES AND MANUFACTURED FROM JUNE 23 TO DECEMBER 6, 1999, AND FROM MAY 23 TO SEPTEMBER 30, 2000. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Safety consequence

THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Manufacturer remedy

DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4201 OR KENWORTH AT 1-425-828-5440.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/TRW TIE ROD ENDS (20EDL)

NHTSA #01V140006 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported August 28, 2001 · PACCAR, INCORPORATED

Potentially affected: 2,294 vehicles

Owners notified October 24, 2001 · Vehicles built June 14, 1999 – December 10, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Safety consequence

THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Manufacturer remedy

DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN OCTOBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000 OR KENWORTH AT 1-425-828-5000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/RFIM ELECTRICAL

NHTSA #01V131000 · Electrical System — Wiring · NHTSA notice

Reported April 13, 2001 · PACCAR, INCORPORATED

Potentially affected: 1,449 vehicles

Manufacturer campaign 401-D · Owners notified June 13, 2001 · Vehicles built August 16, 1999 – October 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THESE VEHICLES ARE EQUIPPED WITH PETERBILT'S SMARTGAGE SYSTEM CONTAINING A REDUCED FUNCTION INTERFACE MODULE (RFIM). THIS MODULE RECEIVES DATA FROM VARIOUS COMPONENTS/SYSTEMS ON THE VEHICLE THEN SENDS THE INFORMATION TO A MICROPROCESSOR. A MANUFACTURING DEFECT IN THE RFIM'S CAN ALLOW WATER TO PENETRATE INTO THE PRESSURE BLOCK PORTION OF THE MODULE, CAUSING AN ELECTRICAL SHORT IN THE PRESSURE TRANSDUCER CONNECTOR.

Safety consequence

THIS RESULTS IN AN ERRONEOUS AIR PRESSURE READING ON THE GAUGE IN THE DASH.

Manufacturer remedy

THE RFIM DATE CODE WILL BE INSPECTED AND ALL RFIM'S BUILT PRIOR TO SEPTEMBER 9, 2000 WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/TRW STEERING SYSTEMS/TIE ROD

NHTSA #01V044005 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported March 1, 2001 · PACCAR, INCORPORATED

Potentially affected: 6,392 vehicles

Manufacturer campaign 201C/01KW03 · Owners notified April 10, 2001 · Vehicles built July 14, 1999 – November 1, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Safety consequence

IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN ON APRIL 10, 2001, TO KENWORTH OWNERS AND ON APRIL 25, 2001, TO PETERBILT OWNERS. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000, PETERBILT AT 1-940-591-4000 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/SIDE FAIRING HINGE BAR

NHTSA #00V185000 · Fuel System, Gasoline — Storage — Tank Assembly — Mounting · NHTSA notice

Reported July 6, 2000 · PACCAR, INCORPORATED

Potentially affected: 154 vehicles

Manufacturer campaign 600-F · Owners notified August 14, 2000 · Vehicles built April 16, 1999 – May 23, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE SIDE FAIRING HINGE BAR AND MOUNTS CAN DETACH FROM THE FUEL TANK STRAPS. THE HINGE BAR CAN ROTATE AND SEPARATE FROM THE FAIRING, ALLOWING THE HINGE BAR ASSEMBLY TO FALL OFF OF THE VEHICLE.

Safety consequence

THIS COULD CAUSE A ROAD HAZARD, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL AN ADDITIONAL NUT PLATE AND IF THE BRACKET IS CRACKED, THE FUEL TANK STRAP WILL BE REPLACED WITH A NEW STRAP AND BRACKET ASSEMBLY.

Notes

OWNER NOTIFICATION BEGAN AUGUST 14, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/THROTTLE/BRAKE PEDAL

NHTSA #00V017000 · Service Brakes, Hydraulic — Pedals and Linkages · NHTSA notice

Reported January 19, 2000 · PACCAR, INCORPORATED

Potentially affected: 125 vehicles

Manufacturer campaign 100-A · Owners notified February 4, 2000 · Vehicles built April 7, 1999 – January 3, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THERE IS AN INTERFERENCE BETWEEN THE THROTTLE PEDAL AND THE BRAKE PEDAL.

Safety consequence

THE BRAKE PEDAL MAY NOT OPERATE AS INTENDED, RESULTING IN GREATER BRAKE PEDAL EFFORT AND/OR DELAYED BRAKE RELEASE.

Manufacturer remedy

DEALERS WILL REPLACE THE THROTTLE PEDAL BRACKET.

Notes

OWNER NOTIFICATION BEGAN FEBRUARY 4, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 1999 Peterbilt 387. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

try.vin has no NHTSA owner complaints on file for the 1999 Peterbilt 387.

Other Peterbilt 387 model years

Check your 1999 Peterbilt 387 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Peterbilt 387 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Peterbilt VIN