NHTSA vehicle safety data

2004 Honda Odyssey Recalls, Ratings & Complaints

The 2004 Honda Odyssey has 13 NHTSA recall campaigns and 585 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Honda dealer.

NHTSA recall and complaint data for the 2004 Honda Odyssey, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Honda Odyssey owner complaints

Owners have filed 585 complaints with NHTSA about the 2004 Honda Odyssey, describing incidents dated September 16, 2003 to August 27, 2026.

Most-cited components

Power Train 221 complaints
Air Bags 111 complaints
Engine 72 complaints
Structure 55 complaints
Electrical System 53 complaints
Fuel/Propulsion System 24 complaints

Of the 585 complaints on file, 41 report a crash and 6 a fire; across all 585 complaints, owners report 45 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11760283 · Filed August 28, 2026
On XXX while traveling at approximately 50 mph on a smooth highway, both front airbags and the seatbelt pretensioners spontaneously deployed and exploded without warning. There was absolutely no collision, crash, road debris, or pothole impact. There were no vehichles in front or behind me. The…
ODI #11710719 · Filed January 13, 2026
The contact owns a 2004 Honda Odyssey. The contact stated that while driving 45 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The contact pulled over to the right side of the roadway, turned off the vehicle for approximately 30-minutes before restarting the…
ODI #11674512 · Filed July 18, 2025
The contact owned a 2004 Honda Odyssey equipped with Michelin CrossClimate 2 Tires, Tire Size 255/60R112VXL, DOT Number: Not Available. The contact stated that while her husband was driving at an unknown speed and turning a corner, the front driver's side tire suddenly blew out, causing the vehicle…

Read all 585 complaints

Owner-reported

2004 Honda Odyssey mileage at failure

427 of the 585 complaints on file for the 2004 Honda Odyssey give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Power Train	Median 110,000 miles	Middle half 90,000–135,000 miles	Based on 191 complaints
Air Bags	Median 115,000 miles	Middle half 80,000–155,000 miles	Based on 50 complaints
Engine	Median 95,000 miles	Middle half 80,000–130,000 miles	Based on 64 complaints
Structure	Median 85,000 miles	Middle half 60,000–130,000 miles	Based on 34 complaints
Electrical System	Median 105,000 miles	Middle half 80,000–160,000 miles	Based on 40 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2004 Honda Odyssey in 5 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page
Preliminary Evaluation PE13-020: Inadvertent Air Bag Deployment
Closed January 6, 2014
- Recall 13V-412
Preliminary Evaluation PE12-026: Ignition Interlock Failure - Rollaway
Closed January 14, 2013
- Recall 12V-573

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #19V501000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,657,752 vehicles

Repair completion: 47.72% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign E5D, X5C · Owners notified August 12, 2019 · Vehicles built August 20, 2003 – August 13, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V499000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 3,947 vehicles

Repair completion: 29.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign Q5A, Y58 · Owners notified August 12, 2019 · Vehicles built August 25, 2003 – August 11, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V182000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported March 6, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,101,534 vehicles

Repair completion: 54.23% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign U40,M45,O41,G44 · Owners notified April 10, 2019 · Vehicles built August 20, 2003 – August 13, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.

Safety consequence

An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Improperly Installed Passenger Air Bag

NHTSA #18V268000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported April 26, 2018 · Honda (American Honda Motor Co.)

Potentially affected: 1,335 vehicles

Repair completion: 86.4% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign C1X, N2L, U2M · Owners notified June 22, 2018 · Vehicles built October 9, 2003 – June 25, 2004 (per NHTSA)

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.

Safety consequence

An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.

Manufacturer remedy

Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V344000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 23, 2016 · Honda (American Honda Motor Co.)

Potentially affected: 1,790,894 vehicles

Repair completion: 57.83% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign KA0, KA1, KA2, KA3 · Owners notified June 29, 2016 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Frontal Air Bag May Rupture

NHTSA #15V320000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · Honda (American Honda Motor Co.)

Potentially affected: 6,281,043 vehicles

Repair completion: 79.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JQ9 & JR0-JR8 · Owners notified July 1, 2015 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Inadvertent Air Bag Deployment

NHTSA #15V045000 · Air Bags — Frontal · NHTSA notice

Reported January 28, 2015 · Honda (American Honda Motor Co.)

Potentially affected: 374,177 vehicles

Repair completion: 53.39% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JP5, JP6 · Owners notified February 22, 2016 · Vehicles built February 13, 2002 – August 13, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Honda is recalling certain model year 2003-2004 Honda Odyssey vehicles manufactured February 13, 2002, to August 13, 2004, and 2003 Acura MDX vehicles manufactured February 21, 2002, to September 23, 2003. Due to electrical noise, a component in the air bag control module may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Safety consequence

Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Manufacturer remedy

Honda dealers will replace the supplemental restraint system electronic control unit (SRS ECU). The recall began on February 22, 2016. Owners may contact Honda customer service at 1-800-999-1009. Honda's number for this recall is JN6 (Odyssey), and JN7 (MDX). Note: This recall supersedes recall 13V-412. Vehicles that had a noise filter installed as the remedy for that campaign need to have the SRS ECU replaced under this campaign.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Air Bag Inflator May Rupture

NHTSA #14V700000 · Air Bags · NHTSA notice

Reported November 4, 2014 · Honda (American Honda Motor Co.)

Owners notified January 26, 2015 · Vehicles built June 19, 2001 – August 13, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger side air bag inflator, free of charge. The recall began January 26, 2015. Owners may contact Honda customer service at 1-800-999-1009.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.Note: This recall supersedes safety recall 14V-353, with the exception of vehicles originally sold, or ever registered, in California.Those vehicles will continue to be addressed, and a free remedy provided, under that safety recall campaign.This recall also includes vehicles in the specific geographic areas listed above that were included within safety recalls 13V-132 and 14V-349.

Passenger Side Air Bag Inflator may Rupture

NHTSA #14V353000 · Air Bags · NHTSA notice

Reported June 20, 2014 · Honda (American Honda Motor Co.)

Potentially affected: 133,207 vehicles

Repair completion: 70% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JH6,JH7,JH8,JH9,JJ0 · Owners notified September 12, 2014 · Vehicles built February 4, 2003 – August 13, 2004 (per NHTSA)

Recall group: Takata airbag inflators

Defect description

American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped with Takata-brand air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Safety consequence

Manufacturer remedy

Honda will notify owners, and dealers will replace the inflators in all affected vehicles, free of charge. The recall is expected to begin during August 2014. Owners may contact Honda customer service at 1-800-999-1009.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Inadvertent Air Bag Deployment

NHTSA #13V412000 · Air Bags · NHTSA notice

Reported September 19, 2013 · Honda (American Honda Motor Co.)

Potentially affected: 374,618 vehicles

Repair completion: 50.75% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JC2/JC3 · Owners notified November 1, 2013 · Vehicles built August 20, 2003 – February 2, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Honda is recalling certain model year 2003 and 2004 Odyssey and model year 2003 Acura MDX vehicles. Due to electrical noise, a component in the air bag control module may fail causing the front air bags, side curtain air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Safety consequence

Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Manufacturer remedy

Honda will notify owners, and dealers will install a noise suppressor unit, free of charge. The recall began on November 1, 2013. A renotification letter went out on July 11, 2014 for the 2003 Acura and the 2003-2004 Odyssey. Owners may contact Honda at 1-800-999-1009. Honda's recall numbers are JC2 (Honda Odyssey) and JC3 (Acura MDX).

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Ignition Interlock may Deform Allowing Rollaway

NHTSA #12V573000 · Electrical System — Ignition — Switch · NHTSA notice

Reported December 11, 2012 · Honda (American Honda Motor Co.)

Potentially affected: 807,161 vehicles

Honda campaign S73/S74 · Owners notified February 22, 2013 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Honda is recalling certain model year 2003 and 2004 Pilot and Odyssey and 2003 through 2006 Acura MDX passenger vehicles manufactured from November 26, 2001, through August 30, 2006. The interlock lever of the ignition switch may deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated.

Safety consequence

Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the park position can allow the vehicle to roll away, increasing the risk of a crash.

Manufacturer remedy

Honda will notify owners and instruct them to take their vehicle to a Honda or Acura dealer. The dealer will install an updated shift interlock lever and, if necessary, replace any necessary part of the ignition switch, free of charge. The recall began on February 22, 2013. Owners may contact Honda at 1-800-999-1009.

Notes

Honda's recall campaign numbers are S73 and S74.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HONDA/FUEL PUMP

NHTSA #04V420000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 27, 2004 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 69,538 vehicles

Honda campaign P43 · Owners notified September 27, 2004 · Vehicles built February 3, 2004 – July 15, 2004 (per NHTSA)

Defect description

ON CERTAIN MINIVANS, THE FUEL PUMP MAY FAIL DUE TO CORROSION OF AN ELECTRICAL TERMINAL.

Safety consequence

IF THE PUMP STOPS WORKING, EHT ENGINE WILL STALL WITHOUT WARNING, AND A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL CHECK THE ELECTRICAL COUPLER TERMINAL OF THE FUEL PUMP. IF ANY CORROSION IS FOUND, THE PUMP WILL BE REPLACED. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.

Notes

HONDA RECALL NO. P43.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

HONDA/AUTOMATIC TRANSMISSION

NHTSA #04V176000 · Power Train — Automatic Transmission · NHTSA notice

Reported April 15, 2004 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 1,099,796 vehicles

Honda campaign P30/P31 · Owners notified April 27, 2004 · Vehicles built August 20, 2002 – December 15, 2003 (per NHTSA)

Defect description

ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE.

Safety consequence

GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECALL BEGAN ON APRIL 21, 2004, FOR PILOT, ODYSSEY, AND MDX OWNERS. OWNERS OF THE ACCORD VEHICLES WILL START RECEIVING LETTERS ON JUNE 28, 2004, AND ON JUNE 29, 2004, FOR OWNERS OF THE TL AND CL VEHICLES. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.

Notes

HONDA RECALL NOS. P30 (ODYSSEY AND PILOT),P31 (MDX), P38 (ACCORD) AND P39 (ACURA).CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 Honda Odyssey w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

5 investigations

585 owner complaints have been filed with NHTSA for the 2004 Honda Odyssey.

Air Bags; Seat Belts

ODI #11760283

Incident: August 27, 2026 · Filed: August 28, 2026

On XXX while traveling at approximately 50 mph on a smooth highway, both front airbags and the seatbelt pretensioners spontaneously deployed and exploded without warning. There was absolutely no collision, crash, road debris, or pothole impact. There were no vehichles in front or behind me. The vehicle continued smoothly for 100 yards post-blast. The vehicle's exterior and undercarriage remain completely undamaged. COMPONENTS FAILED: The Supplemental Restraint System (SRS) electronic control unit failed catastrophically. The explosive blast shattered the windshield, locked the seatbelt assemblies, and inflicted immediate blast-induced acoustic trauma/severe tinnitus. The vehicle is completely disabled but safely secured on private property and is available for immediate physical inspection. MANUFACTURER AND DEALER CONFIRMATION: The manufacturer (American Honda Corporate) has officially cross-referenced this vehicle and confirmed that the safety remedy for the known SRS control unit defect (NHTSA Recall Campaign 13V-412) was previously performed on XXX, at an authorized dealer (Billy Wood Honda in [XXX]). This incident represents a catastrophic failure of a certified manufacturer safety remedy. American Honda Corporate has opened a high-priority Level 1 Product Liability Investigation under Corporate Case Number XXX. RISK AND WARNING SYMPTOMS: Driver safety was put at extreme risk due to an unprovoked explosive detonation at highway speeds, causing temporary blindness from white smoke and sudden hearing deprivation. The SRS warning lamp was confirmed illuminated immediately following the zero-impact deployment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle Speed Control

ODI #11710719

Incident: January 3, 2026 · Filed: January 13, 2026

The contact owns a 2004 Honda Odyssey. The contact stated that while driving 45 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The contact pulled over to the right side of the roadway, turned off the vehicle for approximately 30-minutes before restarting the vehicle; however, the failure persisted. The vehicle was towed to her residence. The failure had occurred several times. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 284,000.

Tires

ODI #11674512

Crash 1 injury1 death

Incident: March 31, 2025 · Filed: July 18, 2025

The contact owned a 2004 Honda Odyssey equipped with Michelin CrossClimate 2 Tires, Tire Size 255/60R112VXL, DOT Number: Not Available. The contact stated that while her husband was driving at an unknown speed and turning a corner, the front driver's side tire suddenly blew out, causing the vehicle to roll a few times, then flip, crashing into a tree where it came to a stop. The air bags did deploy. The driver sustained a fracture to the neck, and he was declared deceased on the scene. The vehicle was towed and totaled. A police report was filed. The dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was unknown.

Unknown or Other

ODI #11664239

Incident: April 25, 2024 · Filed: June 1, 2025

I’ve seen several recalls on the transmission for Honda odysseys that are 2004 just like mine . My transmission has been horrible for the entire time Ive had it. When accelerating, it jumps super hard from 1st into 2nd gear. switching from first gear to 2nd. Sometimes I have to manually switch it into D3 just to get the vehicle moving again. I’ve found this to be pretty scary at times . I’ve searched and searched to see if I had a recall for the transmission and I haven’t but It did show the SRS system recall which I did have serviced. I’m making this complaint because I feel like my vehicle has been affected and overlooked

Air Bags; Seat Belts

ODI #11579840

Incident: March 28, 2024 · Filed: March 28, 2024

SRS light is on they said it was the air bag or riverside buckle

Engine

ODI #11567034

Incident: November 30, 2023 · Filed: January 22, 2024

The contact owns a 2004 Honda Odyssey. The contact stated while driving at approximately 55 MPH, the engine revved up high however, the vehicle failed to respond as needed. Additionally, the contact stated that there was a burning odor coming from the vehicle. There were no warning lights illuminated. The contact pulled over and waited for a while before restarting the vehicle and driving to the residence. The vehicle was not taken to an independent mechanic nor a local dealer. The vehicle was not diagnosed. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000.

Air Bags

ODI #11530848

Incident: July 5, 2023 · Filed: July 7, 2023

As the result of a recall, my driver airbag inflator was replaced. Soon afterwards, my horn started honking when hitting, bumps or moving the steering wheel. I returned the vehicle to the dealership, and they said they adjusted something that seem to help for a short period of time. However, the problem returned upon taking the car to another dealership. I found that the automotive repairman stated that the wrong part for the inflator had been installed. I returned it to the original dealership and they refused to address the problem. The dealer is persons Honda at 15525 Frederick Rd., Rockville, MD 20855.

Air Bags

ODI #11505893

Crash

Incident: January 24, 2023 · Filed: February 6, 2023

The contact owns a 2004 Honda Odyssey. The contact stated while driving 20 MPH the driver-side front air bag deploy on its own without any impact, causing the contact to drive off the road and struck a tree and causing damages to the front end of the vehicle. No one was injured. No police report was filed. The vehicle was not towed, but the contact was able to drive the vehicle home. The manufacturer was not contacted. The failure mileage was 168,000.

Electrical System

ODI #11503862

Incident: January 24, 2023 · Filed: January 26, 2023

The contact owns a 2004 Honda Odyssey. The contact stated that while driving 60 MPH, the vehicle lost motive power without warning. The contact self-diagnosed the vehicle with an ignition switch failure. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 308,000.

Air Bags; Wheels

ODI #11487045

Incident: September 19, 2022 · Filed: September 29, 2022

Good Morning, On Monday, September 19, 2022. I talked with Chris from Honda. com. He told me to take the vehicle back to the same repair dealership where I had issues with repairing the vehicle. I said trusting them is hard for me because they had the vehicle 3 different times and the airbags and vehicle are still not repaired. Chris told me " I will call you back later, by the end of this week". As of yet, I have not heard back from Chris at Honda.com thank you. John Phillips. Ps. receipts were previously submitted.

Other Honda Odyssey model years

Check your 2004 Honda Odyssey VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Honda Odyssey at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Honda VIN