NHTSA vehicle safety data

2012 GMC Yukon XL Recalls & Complaints

The 2012 GMC Yukon XL has 4 NHTSA recall campaigns and 13 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2012 GMC Yukon XL. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2012 GMC Yukon XL owner complaints

Owners have filed 13 complaints with NHTSA about the 2012 GMC Yukon XL, describing incidents dated May 1, 2015 to November 1, 2023.

Most-cited components

Air Bags 5 complaints
Unknown or Other 5 complaints
Electrical System 3 complaints
Structure 3 complaints
Engine 2 complaints
Power Train 1 complaint

Newest complaints

ODI #11557861 · Filed December 1, 2023
The contact owns a 2012 GMC Yukon XL. The contact stated that while in a parking lot, the contact attempted to shift the vehicle into drive however, the transmission failed to shift into gear. The contact stated that the gear shifter cable had detached. There were no warning lights illuminated. The…
ODI #11414353 · Filed April 28, 2021
TL* THE CONTACT OWNS A 2012 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STALLED. ADDITIONALLY, THE BRAKES FAILED TO ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ 85023)…
ODI #11398112 · Filed February 26, 2021
TL* TAKATA RECALL. THE CONTACT OWNS A 2012 GMC YUKON XL. THE CONTACT STATED THE DASHBOARD WAS CRACKED IN THREE PLACES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V051000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED ALLEN GMC (28332…

Read all 13 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2012 GMC Yukon XL in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V054000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 1,778,128 vehicles

Repair completion: 63.26% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328800 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V051000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 284,645 vehicles

Repair completion: 54.46% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328770 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328770.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Ignition Lock Actuator may Bind

NHTSA #14V827000 · Electrical System — Ignition · NHTSA notice

Reported December 30, 2014 · General Motors LLC

Potentially affected: 84,192 vehicles

Repair completion: 63.29% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14696 and 14912 · Owners notified February 12, 2015 · Vehicles built May 9, 2011 – May 21, 2012 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Safety consequence

If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Manufacturer remedy

GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

STEERING GEAR PITMAN SHAFT

NHTSA #12V112000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported March 22, 2012 · GENERAL MOTORS LLC

Potentially affected: 6,159 vehicles

Manufacturer campaign 12055 · Owners notified April 4, 2012 · Vehicles built February 7, 2012 – February 22, 2012 (per NHTSA)

Defect description

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND SUBURBAN VEHICLES, AND GMC SAVANA AND YUKON XL HEAVY DUTY VEHICLES. THE STEERING GEAR PITMAN SHAFT MAY NOT HAVE BEEN ADEQUATELY HARDENED AND COULD FRACTURE.

Safety consequence

IF THIS CONDITION OCCURS, A LOSS OF STEERING COULD RESULT, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE STEERING GEAR AND, IF NECESSARY, REPLACE THE STEERING GEAR PITMAN SHAFT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON APRIL 4, 2012.

Notes

GMS SAFETY RECALL CAMPAIGN NUMBER IS 12055. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2012 GMC Yukon XL. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

13 owner complaints have been filed with NHTSA for the 2012 GMC Yukon XL.

Power Train

ODI #11557861

Incident: November 1, 2023 · Filed: December 1, 2023

The contact owns a 2012 GMC Yukon XL. The contact stated that while in a parking lot, the contact attempted to shift the vehicle into drive however, the transmission failed to shift into gear. The contact stated that the gear shifter cable had detached. There were no warning lights illuminated. The contact called the dealer and was informed that the vehicle needed to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the issue and referred the contact to the dealer for diagnostic testing. The failure mileage was approximately 248,000.

Electrical System; Engine

ODI #11414353

Incident: April 28, 2021 · Filed: April 28, 2021

TL* THE CONTACT OWNS A 2012 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STALLED. ADDITIONALLY, THE BRAKES FAILED TO ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ 85023) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS BATTERY RELATED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000.

Air Bags; Structure

ODI #11398112

Incident: February 1, 2019 · Filed: February 26, 2021

TL* TAKATA RECALL. THE CONTACT OWNS A 2012 GMC YUKON XL. THE CONTACT STATED THE DASHBOARD WAS CRACKED IN THREE PLACES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V051000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED ALLEN GMC (28332 CAMINO CAPISTRANO, LAGUNA NIGUEL, CA 92677, (949) 391-9094) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 75,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Air Bags; Structure

ODI #11170805

Incident: January 16, 2019 · Filed: January 18, 2019

DASH HAS 2 CRACKS. ONE ABOVE SPEEDOMETER. THE OTHER IS CRACKED ON THE TOP LEFT CORNER OF THE DASH THAT SURROUNDS THE PASSENGER AIRBAG. VEHICLE WAS PURCHASED 1/16/19. I AM SIMPLY ADDING MINE TO THE LARGE VOLUME OF COMPLAINTS BECAUSE I BELIEVE IT MAY BE A SAFETY HAZARD. NOT SURE HOW LONG IT HAS BEEN THERE, BUT THIS VEHICLE WAS EXTREMELY WELL MAINTAINED AND GARAGED IT'S WHOLE LIFE.

Electrical System; Service Brakes

ODI #11139924

Incident: October 12, 2018 · Filed: October 12, 2018

REAR BRAKE LIGHTS ARE INOPERABLE. DEALER SAYS ASSEMBLIES MUST BE REPLACED AT $2K. SEEMS TO BE A WIDESPREAD ISSUE AND AN EXTREME SAFETY ISSUE. PLEASE ENSURE GMC RECALLS AND REPAIRS THIS WIDESPREAD ISSUE.

Air Bags; Unknown or Other

ODI #11119259

Incident: August 1, 2017 · Filed: August 10, 2018

ABOUT ONE YEAR AGO WE NOTICED A SMALL CRACK AT THE CORNER OF THE 'LID' TO THE PASSENGER SEAT AIR BAG. NOW WE HAVE A CRACK AT THE HUMP OF THE STEERING WHEEL THIS IS A HUGE SAFETY CONCERN TO US AS IT COULD RESULT IN TERRIBLE INJURY IN ANY NUMBER OF WAYS. 1THE AIR BAG COULD EXPLODE AT ANY TIME DUE TO THE CRACK IN THE LID AREA, WITHOUT ANY WARNING AND WITHOUT THE RESULT OF BEING IN AN ACCIDENT THUS HARMING ANYONE IN THE PASSENGER SEAT 2THE BROKEN DASH COULD RESULT IN TERRIFIC INJURY IN THE EVENT OF AN ACCIDENT AND AIR BAG DEPLOYMENT AS THE BRITTLE PIECES AND SHARP EDGES OF CRACKED PLASTIC BECOME FLYING IN THE CAR 3THE AIRBAG COULD MISFIRE DUE TO THE DAMAGED LID (FOR EXAMPLE; HITTING AND BREAKING THE WINDSHIELD AND NOT PROTECTING THE HEAD OF THE PASSENGER) CAUSING FURTHER INJURY AND HARM 4THE CRACK IN THE PLASTIC OF THE DASHBOARD COULD BE EVEN MORE EXTENSIVE THAN WE CAN SEE. THE ENTIRE DASHBOARD COULD BE DEFECTIVE AND CRACKED AND SUDDENLY FALL OFF AS THE RESULT OF A BUMP OR POTHOLE CAUSING INJURY AND POSSIBLE ACCIDENT 5THE DEFECTIVE DASHBOARD PLASTIC COULD HAVE CRACKS THAT WOULD CAUSE WIRING TO BE PINCHED, CUT OR SEVERED CAUSING HEAT, FIRE, AND POSSIBLE ACCIDENTS AND INJURIES 6SUN SHINING THRU THE WINDSHIELD COULD CAUSE THE CRACKS TO WIDEN 7OUR FAVORITE 87 YEAR OLD MOM USUALLY RIDES IN THE PASSENGER SEAT. SHE IS IRREPLACEABLE AND INVALUABLE. 8THIS IS AND HAS BEEN A 'KNOWN' ISSUE TO GMC. 9WE ARE BOTH DISABLED AND ON FIXED INCOMES. WE ARE UNABLE TO REPAIR THIS OURSELVES AND SHOULD NOT HAVE TO. SAFETY AND DEPENDABILITY IS ONE OF THE REASONS WE ALWAYS PURCHASED GMC YUKONS. THIS IS OUR 4TH GMC YUKON/SUBURBAN. WE NEVER DOUBTED THAT GMC MADE QUALITY PRODUCTS THAT WERE CONSUMER SAFE. NOW THIS DASHBOARD AIRBAG ISSUE HAS US VERY WORRIED AND CONCERNED FOR OUR HEALTH AND SAFETY AND THE HEALTH AND SAFETY OF ALL OUR FAMILY AND PASSENGERS

Air Bags; Unknown or Other

ODI #11055971

Incident: May 1, 2015 · Filed: December 21, 2017

AT SOME POINT NEAR 65000 MILES, A VERY LARGE CRACK APPEARED OVER THE INSTRUMENT PANEL, AS WELL AS A SMALL CRACK EXTENDING INTO THE PASSENGER SIDE AIRBAG AREA. I WORRY ABOUT MY CHILDREN'S SAFETY IF WE WERE IN AN ACCIDENT AND PLASTIC PIECES GO FLYING.

Visibility

ODI #11052503

Incident: December 4, 2017 · Filed: December 5, 2017

TL* THE CONTACT OWNS A 2012 GMC YUKON XL. WHILE DRIVING, THE SUN ROOF INADVERTENTLY EXPLODED. THERE WERE NO INJURIES. THE CONTACT HEARD WIND BLOWING THROUGH THE SUN ROOF. UPON FURTHER INSPECTION, HE NOTICED A HOLE IN THE SUN ROOF GLASS. THE CONTACT CALLED BRIAN HARRIS CHEVROLET AT (225) 910-6907 (15015 FLORIDA BLVD, BATON ROUGE, LA 70819) AND WAS INFORMED THAT THE DEALER WAS CLOSED AND HE WOULD BE CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

Steering; Electrical System; Engine

ODI #11020021

Incident: August 26, 2017 · Filed: August 28, 2017

WHILE DRIVING CAR AT RANDOM TIMES IT WILL SHUTOFF AND YOU WILL LOOSE STEERING AND ALL ELECTRONICS MOMENTARILY AND THEN CAR WILL TURN BACK ON. IT ONLY DOES THIS WHILE DRIVING STRAIGHT OR TURNING ON ROUGHER PAVEMENT. ONCE THIS HAPPENS THE NEXT TIME YOU TURN OFF THE CAR AND TRY TO START THE CAR THE KEY WILL NOT TURN ON ANY OF THE ELECTRONICS AND WILL NOT START THE VEHICLE. IF YOU CONTINUOUSLY TAKE THE KEY OUT AND REINSERT UNTIL AND THE CAR WILL EVENTUALLY START.

Unknown or Other

ODI #10967330

Incident: February 9, 2017 · Filed: March 20, 2017

THE DASHBOARD SPONTANEOUSLY CRACKED ABOVE THE INSTRUMENT PANEL SECTION. THERE ARE MULTIPLE SECTIONS TO THE CRACK AND IS APPROXIMATELY 6"-8" IN LENGTH. THE VEHICLE WAS PARKED AT THE TIME OF THE CRACK. SUBSEQUENTLY, THE DASHBOARD MAKES VARIOUS VIBRATION, CHATTERING, AND RATTLING NOISES.

Other GMC Yukon XL model years

Check your 2012 GMC Yukon XL VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Yukon XL at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN