2016 GMC Yukon XL Recalls & Complaints

Incident: October 5, 2026 · Filed: October 23, 2026

While driving at about 35-40 mph, vehicle went into limp mode and then stalled. Vehicle would not restart until hours later after being towed. When vehicle started there is the sound of a rod(s) knocking in the engine.

Incident: December 4, 2025 · Filed: September 17, 2026

The contact owns a 2016 GMC Yukon XL. The contact stated that while driving 30 MPH, the steering wheel locked up. Several unknown warning lights were illuminated. The contact associated the failure with NHTSA Campaign Number: 16V256000 (Suspension); however, the VIN was not included in the recall. The dealer was contacted. The manufacturer was contacted by phone and was made aware of the failure but stated that the VIN was not included in the recall. The failure mileage was approximately 108,346.

Incident: August 15, 2026 · Filed: September 3, 2026

1. My vehicle is having transmission issues with shuddering and shifting. M5U RPO code 8L90 transmission. 2. My safety and the safety of others is a concern if the transmission is not working as intended my vehicle could be at risk an accident that could be avoided. 3. The problem has not be reproduced or confirmed by a dealer I work on my own vehicles and I am going to repair this issue myself if able. 4. There are no trouble codes on my vehicle when scanned with an OBD2 scanner.

Incident: June 1, 2026 · Filed: June 25, 2026

After my child had thrown up all over the car seat her father had taken her inside to clean up and I took the car seat apart to throw the pieces into the washer to clean them. The harness strap did not come out fully clean so I contacted Graco for a replacement piece and I was told that they don’t replace those and that the strap being removed totaled my car seat. It has a woven material tab that goes up through the hard plastic base and locks in by opening itself. It’s essentially a T in the material so it can be folded to go back through the hard plastic base. I was told that since the manual doesn’t provide instructions regarding that piece that I should know it’s not to be removed. No where in the manual, on the car seat or on the strap says it’s not to be removed. I did not damage/break/cut any pieces to get it in or out of the car seat. I was a mom in a panic trying to clean the car seat as quickly as possible so I could tend to my sick child. There were no warning signs telling me anywhere not to remove it. I don’t want other parents to do what I did and have a totaled car seat that they continue to use. I did not have the manual at the time of removing the pieces for cleaning but I have since located the PDF and read through all 96 pages.

Incident: April 21, 2026 · Filed: April 22, 2026

My wife was driving down the highway and out of no where there was a loud taping sound, the vehicle started running real bad (skipping), the vehicle lost power and she lost control of the steering. As a result, she ran off the road into a ditch. this is a known concern with the 6.2 liter engines and all signs are pointing to lifter failure. She could have ben seriously injured and GM is responsible for this.

Incident: April 1, 2026 · Filed: April 19, 2026

TRANSMISSION FAILURE ON 8L90 8 SPEED TRANSMISSION. 93,000 MILES.

Incident: February 28, 2026 · Filed: March 25, 2026

I am submitting this complaint to report what I believe to be a serious and systemic safety defect involving GM 6.2L engines equipped with fuel efficiency systems such as Active Fuel Management (AFM) or Dynamic Fuel Management (DFM). I have experienced catastrophic engine failure in two separate GMC Yukon Denali vehicles with nearly identical symptoms, which strongly suggests a broader design defect rather than isolated mechanical issues. My first vehicle, a 2015 GMC Yukon Denali XL, developed significant engine performance problems consistent with known lifter and camshaft failures widely reported in GM vehicles using these fuel efficiency systems. Due to ongoing reliability concerns and the financial burden of potential repair, I was forced to trade this vehicle at a loss. My second vehicle, a 2016 GMC Yukon Denali XL equipped with the same engine platform, suffered sudden and catastrophic engine failure in February 2026. This failure occurred abruptly and without meaningful prior warning, rendering the vehicle inoperable and creating a potentially hazardous situation. Sudden engine failure of this nature presents a significant safety risk, particularly if it occurs at highway speeds or in heavy traffic. An oil service had been performed on this vehicle in December 2025 at a Jiffy Lube franchise. After the failure, an independent service provider documented that the oil fill cap had been left loose. However, the Jiffy Lube franchise and its insurance carrier have denied responsibility, asserting that the engine failure is attributable to known defects and reliability issues associated with GM’s fuel efficiency engine systems. As a result, both the manufacturer and the service provider are denying responsibility for a catastrophic mechanical failure that has serious safety implications. This leaves consumers exposed to sudden engine failure risk with no meaningful recourse. Based on my direct experience with two separate vehicles exhibiting similar catastroph

Incident: November 10, 2025 · Filed: February 23, 2026

AFM system failed resulting in engine replacement.

Incident: January 11, 2026 · Filed: February 19, 2026

I was test driving the vehicle after some and as I was test, driving it, the steering lot up on me. Luckily, I was entering a residential area when it occurred down the street from my residency; in which I was able to drive it to my residency, during that short ride, you could smell a burning smell coming out along with some crackling noises. I had to get the vehicle towed a week later to the mechanic shop where they fix one of my engine problems and verified that I needed a new power steering unit and gave me a quote, I couldn’t afford the word and started doing research and came across the recall for the power steering within my vehicle year, make and model. I replaced the power steering unit, but I’m having a difficult time celebrating the system..

Incident: January 30, 2026 · Filed: February 11, 2026

My vehicle has been in 16 times since I bought it the most recent incident is for the engine which started about six months ago. It’s been in since then for other issues concurrently with this one it hesitates like it’s getting stuck in sand before it wants to go first the mechanic told me he didn’t sense it but the thermostat was stuck open so they fix that. Second time it went in they thought it was some sort of a filter and some other components I’m not sure. Again it was not fixed then my son and I were out in Minnesota freezing cold night in November and go and drive and then when again it was the drive train this time that got fixed a month ago about a week ago it starts making a noise like there’s too much snow in the tires. I get my car washed every few days but I got it washed again and that didn’t fix it so it’s in the shop again and I’m paying for a rental again. I have the Walser guard thank the Lord because it’s paid for itself about 15 times over. I’ve gotten two transmissions, an air conditioner, two sensors the arm that other people have complained about I don’t know exactly the name of it the trailer component that you plug into also blew out my seven way and I had to have my seven way wire fixed so I’m nervous about plugging that back in. My dad passed away and I spent $70,000 of my inheritance by this car. I should’ve flushed it down a toilet instead. Everybody makes fun at work that this car is literally gonna kill my kids and I because every other day it feels like we’re stuck on the side of the road.