try.vin
Log in

NHTSA vehicle safety data

2005 Chrysler Town And Country Recalls & Complaints

The 2005 Chrysler Town And Country has 7 NHTSA recall campaigns and 857 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chrysler dealer.

NHTSA recall and complaint data for the 2005 Chrysler Town And Country. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Chrysler Town And Country owner complaints

Owners have filed 857 complaints with NHTSA about the 2005 Chrysler Town And Country, describing incidents dated April 1, 2004 to September 3, 2024.

Most-cited components

  • Electrical System 164 complaints
  • Air Bags 153 complaints
  • Steering 121 complaints
  • Exterior Lighting 116 complaints
  • Fuel/Propulsion System 95 complaints
  • Engine 91 complaints

Of the 857 complaints on file, 47 report a crash and 14 a fire; across all 857 complaints, owners report 55 injuries (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11613666 · Filed

    Headlights: low beams do not work at all but high beams do. Second time this vehicle has had the same problem. Last time Chrysler replaced under a lifetime replacement, just short of a recall yet here I am having the same problem again.

  • ODI #11605249 · Filed

    The contact owns a 2005 Chrysler Town and Country. The contact stated while attempting to make a left turn at a red light at approximately 15 MPH, the vehicle stalled almost causing the contact to crash into another vehicle. No warning light was illuminated. The vehicle was drivable and was taken to…

  • ODI #11461396 · Filed

    The contact owned a 2005 Chrysler Town & Country. While driving on a country road when a truck turned in the front on the contact. The motor came through the firewall crushing his legs and trapping the contact in the vehicle. The neighbor came and pulled the contact out of the vehicle. The contact…

Read all 857 complaints

Owner-reported

2005 Chrysler Town And Country mileage at failure

697 of the 857 complaints on file for the 2005 Chrysler Town And Country give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Electrical SystemMedian 85,000 milesMiddle half 45,000–120,000 milesBased on 135 complaints
Air BagsMedian 60,000 milesMiddle half 45,000–90,000 milesBased on 114 complaints
SteeringMedian 55,000 milesMiddle half 40,000–80,000 milesBased on 96 complaints
Exterior LightingMedian 90,000 milesMiddle half 60,000–115,000 milesBased on 103 complaints
Fuel/Propulsion SystemMedian 75,000 milesMiddle half 55,000–105,000 milesBased on 88 complaints
EngineMedian 70,000 milesMiddle half 30,000–105,000 milesBased on 80 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Chrysler Town And Country in 7 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

2 more NHTSA investigations
Open and recently closed NHTSA defect investigations

AFTERMARKET RECEIVER HITCH

NHTSA #10E034000 · Equipment · NHTSA notice

Reported August 10, 2010 · CURT MFG. INC.

Potentially affected: 6,686 vehicles

Owners notified August 13, 2010

Defect description

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Safety consequence

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT AIR BAG CRASH SENSOR FAILURE

NHTSA #10V008000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported January 11, 2010 · CHRYSLER GROUP LLC

Potentially affected: 308,950 vehicles

Chrysler campaign J38 · Owners notified April 19, 2010 · Vehicles built January 19, 2005 – April 5, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Safety consequence

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Manufacturer remedy

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes

CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIR BAG SENSORS

NHTSA #07V192000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported May 3, 2007 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 270,958 vehicles

Manufacturer campaign G09/X16 · Owners notified July 2, 2007 · Vehicles built April 24, 2003 – February 2, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS INSTALLED IN THESE VEHICLES MAY CORRODE AND CRACK ALLOWING WATER TO ENTER THE SENSOR. THESE SENSORS PROVIDE ENHANCED AIR BAG PERFORMANCE IN CERTAIN TYPES OF FRONTAL CRASHES.

Safety consequence

IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.

Manufacturer remedy

FOR VEHICLES REGISTERED IN THE RECALL STATES, DEALERS WILL REPLACE THE ORIGINAL UF AIR BAG SENSORS WITH ONES WITH GREATER CORROSION RESISTANCE. VEHICLES REGISTERED IN OTHER STATES WILL OBTAIN A LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. THE CAMPAIGN BEGAN ON JULY 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER'S CAMPAIGN NOS. G09/X16. DAIMLERCHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, IT HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE. CUSTOMERS ALSO MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

BRAKE HYDRAULIC MASTER CYLINDER

NHTSA #06E022000 · Service Brakes, Hydraulic · NHTSA notice

Reported March 13, 2006 · BRAKE PARTS, INC.

Potentially affected: 7,440 vehicles

Owners notified March 20, 2006

Defect description

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Safety consequence

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT WINDSHIELD WIPER MOTOR

NHTSA #06V067000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported March 8, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 268,800 vehicles

Manufacturer campaign F10 · Owners notified June 19, 2006 · Vehicles built March 27, 2005 – July 1, 2005 (per NHTSA)

Defect description

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Safety consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DAIMLERCHRYSLER/SEAT BELT RETRACTOR ASSEMBLY

NHTSA #04V047000 · Seat Belts — Front — Retractor · NHTSA notice

Reported February 3, 2004 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 3,200 vehicles

Manufacturer campaign D04 · Owners notified February 23, 2004 · Vehicles built October 20, 2003 – January 16, 2004 (per NHTSA)

Defect description

AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.

Safety consequence

AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. D04.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Chrysler Town And Country model years

Check your 2005 Chrysler Town And Country VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chrysler Town And Country at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chrysler VIN