NHTSA vehicle safety data

2001 Chevrolet Malibu Recalls, Ratings & Complaints

The 2001 Chevrolet Malibu has 4 NHTSA recall campaigns and 721 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2001 Chevrolet Malibu, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Chevrolet Malibu owner complaints

Owners have filed 721 complaints with NHTSA about the 2001 Chevrolet Malibu, describing incidents dated September 1, 2000 to January 31, 2023.

Most-cited components

Electrical System 285 complaints
Engine 174 complaints
Exterior Lighting 108 complaints
Service Brakes 88 complaints
Steering 41 complaints
Fuel/Propulsion System 40 complaints

Of the 721 complaints on file, 36 report a crash and 1 a fire; across all 721 complaints, owners report 29 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11504789 · Filed January 31, 2023
The contact owns a 2001 Chevrolet Malibu. The contact received notification of NHTSA Campaign Numbers: 03V327000 (Exterior Lighting) and 14V400000 (Electrical System) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.
ODI #11373867 · Filed November 9, 2020
THE BLINKERS RANDOMLY WORK; MOST LIKELY NEEDS A NEW HAZARD SWITCH. THE CAR'S TEMPERATURE GAUGE WOULD RISE WHEN SITTING IN IDLE; NEEDED A NEW WATER PUMP AND THERMOSTAT AS OF 11/2020.
ODI #11363209 · Filed October 7, 2020
WHEN STARTING THE MALIBU THE DASHBOARD LIGHTS ILLUMINATE AND WHEN THE KEY IS TURNED TO START THE CAR THE LIGHTS GO OUT AND THE FUEL GAUGE DROPS TO ZERO OR EMPTY AND THE CAR WILL NOT START. THIS PROBLEM ALSO OCCURS WHEN DRIVING THE CAR AND THE IGNITION SYSTEM SHUTS DOWN LEAVING YOU WITH NO STEERING…

Read all 721 complaints

Owner-reported

2001 Chevrolet Malibu mileage at failure

438 of the 721 complaints on file for the 2001 Chevrolet Malibu give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 90,000 miles	Middle half 65,000–110,000 miles	Based on 188 complaints
Engine	Median 60,000 miles	Middle half 45,000–90,000 miles	Based on 108 complaints
Exterior Lighting	Median 65,000 miles	Middle half 40,000–95,000 miles	Based on 63 complaints
Fuel/Propulsion System	Median 70,000 miles	Middle half 50,000–120,000 miles	Based on 32 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Chevrolet Malibu in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA02-028: ERRATIC FUEL GAUGE
Closed December 30, 2003
Engineering Analysis EA02-037: TURN SIGNAL FAILURES
Closed September 5, 2003
- Recall 03V-327
Preliminary Evaluation PE02-064: TURN SIGNAL FAILURE
Closed December 23, 2002
Service Query SQ01-002: ERRATIC FUEL GAUGE
Closed September 30, 2002

Open and recently closed NHTSA defect investigations

Ignition Switch may Turn Off

NHTSA #14V400000 · Electrical System — Ignition · NHTSA notice

Reported July 3, 2014 · General Motors LLC

Potentially affected: 5,877,718 vehicles

Repair completion: 37.05% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14350 · Owners notified September 8, 2014

Defect description

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Safety consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Manufacturer remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/HAZARD WARNING SWITCH

NHTSA #03V327000 · Exterior Lighting — Hazard Flashing Warning Lights — Switch · NHTSA notice

Reported August 28, 2003 · GENERAL MOTORS CORP.

Potentially affected: 670,740 vehicles

Manufacturer campaign 03043 · Owners notified February 5, 2004 · Vehicles built March 23, 2000 – May 31, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.

Safety consequence

WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Notes

GM RECALL NO. 03043.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Chevrolet Malibu 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 2, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

4 investigations

721 owner complaints have been filed with NHTSA for the 2001 Chevrolet Malibu.

Exterior Lighting

ODI #11504789

Incident: January 31, 2023 · Filed: January 31, 2023

The contact owns a 2001 Chevrolet Malibu. The contact received notification of NHTSA Campaign Numbers: 03V327000 (Exterior Lighting) and 14V400000 (Electrical System) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

Electrical System; Exterior Lighting; Engine

ODI #11373867

Incident: November 9, 2020 · Filed: November 9, 2020

THE BLINKERS RANDOMLY WORK; MOST LIKELY NEEDS A NEW HAZARD SWITCH. THE CAR'S TEMPERATURE GAUGE WOULD RISE WHEN SITTING IN IDLE; NEEDED A NEW WATER PUMP AND THERMOSTAT AS OF 11/2020.

Electrical System

ODI #11363209

Incident: August 10, 2020 · Filed: October 7, 2020

WHEN STARTING THE MALIBU THE DASHBOARD LIGHTS ILLUMINATE AND WHEN THE KEY IS TURNED TO START THE CAR THE LIGHTS GO OUT AND THE FUEL GAUGE DROPS TO ZERO OR EMPTY AND THE CAR WILL NOT START. THIS PROBLEM ALSO OCCURS WHEN DRIVING THE CAR AND THE IGNITION SYSTEM SHUTS DOWN LEAVING YOU WITH NO STEERING ASSIST AND THE ENGINE IS NOT RUNNING. SO THIS PROBLEM IS BOTH IN A STANDING START AND WHILE OPERATING THE CAR. I HAD INITIALLY BROUGHT THE CAR TO DEVAN LOWE GM DEALER AND SERVICE DEPARTMENT FOR REPAIRS AND THEY DISCOVERED THE FUEL PUMP WAS NOT WORKING PROPERLY. THEY REPLACED THE FUEL PUMP AND THE PROBLEM WITH THE IGNITION IS STILL PERSISTING. THIS CREATES A DANGEROUS CONDITION FOR THE DRIVER AND OTHER CARS ON THE ROAD. I WOULD REQUEST THAT GMC HAVE THE CAR TOWED TO THE DEVAN LOWE SERVICE DEPARTMENT FOR TROUBLESHOOTING PURPOSES IN COORDINATION WITH GM TECHNICAL DEPARTMENT AND REACH A RESOLUTION AS TO THE CAUSE OF THE PROBLEM AND ISSUE A RECALL FOR ALL AFFECTED CARS.

Engine

ODI #11287911

Incident: June 1, 2018 · Filed: December 9, 2019

TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, UNKNOWN WARNING INDICATORS ILLUMINATED. WHEN THE VEHICLE WAS STARTED, THE IGNITION HAD TO BE TURNED TO THE ON POSITION AND THE CONTACT HAD TO WAIT FOR THE INSTRUMENT PANEL TO LIGHT UP COMPLETELY FOR THE VEHICLE TO START. THE PROCESS WORKED INTERMITTENTLY. THE VEHICLE FAILED TO START EVERY TIME THE CONTACT WOULD ATTEMPT TO START THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO REPLACED THE IGNITION SWITCH; HOWEVER, THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Electrical System

ODI #11279249

Incident: November 9, 2019 · Filed: November 10, 2019

VEHICLE STARTS AND FULLY OPERATES PROPERLY FOR AN INDEFINITE PERIOD OF TIME, THEN IT STALLS ABRUPTLY (AND AT VERY EMBARRASSING AND PERILOUS TIMES). WHEN IT DOES, ALL THE GAUGES ARE NON-OPERATIONAL, WITH THE FUEL GAGE READING, EMPTY. VEHICLE WILL CRANK BUT WILL NOT RESTART. AFTER A PERIOD (AS LONG AS HALF AN HOUR) THE FUEL GAGE WILL JUMP TO ITS PROPER LEVEL, AND ONLY THEN WILL THE VEHICLE RESTART AND RUN FOR YET ANOTHER INDETERMINATE PERIOD. THIS HAS BEEN AN ON-GOING PROBLEM FOR MONTHS, BEFORE I WAS MADE AWARE OF POTENTIAL RE-CALLS ON THIS VEHICLE.

Electrical System; Fuel/Propulsion System

ODI #11246695

Incident: October 1, 2018 · Filed: August 27, 2019

TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S PASS LOCK SYSTEM FAILED AND SHUT OFF THE FUEL PUMP. WHILE THE CONTACT WAS DRIVING 65 MPH, THE PASS LOCK SYSTEM WOULD SHUT OFF THE FUEL PUMP SYSTEM, WHICH CAUSED THE ENGINE TO SEIZE WITHOUT WARNING. THE CONTACT SPOKE WITH JAMES CHEVROLET OF JOHNSTOWN (108 S COMRIE AVE, JOHNSTOWN, NY 12095, 518-762-5555) AND WAS INFORMED THAT THEY COULD REPLACE THE IGNITION SWITCH AND THE PASS LOCK SYSTEM. THE CONTACT WAS PROVIDED A COST ESTIMATE FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,000.

Electrical System

ODI #11242359

Incident: April 15, 2018 · Filed: August 7, 2019

TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED FRIENDLY CHEVROLET (7501 HWY 65 NE, FRIDLEY, MN 55432, (612) 276-2955), BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Electrical System

ODI #11166166

Incident: January 6, 2019 · Filed: January 9, 2019

TURN SIGNALS DO NOT WORK INTERMITTENTLY WHILE DRIVING. DON'T KNOW WHEN THEY WILL WORK OR NOT WORK. IT CAN HAPPEN ANY PLACE, AND TIME. DANGEROUS, ESPECIALLY WHEN DRIVING AT NIGHT. BELOW DATE IS THE MOST RECENT TIME IT HAPPENED. WILL FOR LONG TIME, THEN OUT OF NO WHERE, TURN SIGNAL WILL NOT WORK. THEN WORK AGAIN, UNTIL IT HAPPENS AGAIN.

Fuel/Propulsion System

ODI #11156807

Incident: May 14, 2018 · Filed: December 7, 2018

TAKATA INFLATORS, THE CAR THAT I OWN SMELLS LIKE GASOLINE EVERYDAY AND EACH TIME THAT THE CAR IS STARTED IN THE MORNING. WHEN I TURN ON THE HEAT OR AIR THE GAS SMELL IS EVEN STRONGER I AM AFRAID THAT THE CAR WILL ONE DAY EXPLODE EVEN WITHOUT ME SMOKING.

Fuel/Propulsion System

ODI #11110202

Incident: July 5, 2018 · Filed: July 9, 2018

THEFT DETERRENT SYSTEM (PASSLOCK) ACTIVATES SHUTTING OFF THE FLOW OF FUEL TO VEHICLE. CONSULTED YOUTUBE FOR HELP, HUNDREDS OF PEOPLE HAVE HAD HE SAME PROBLEM THAT THE DEALER FIXES WITH A NEW INGINITION MODULE.

Other Chevrolet Malibu model years

Check your 2001 Chevrolet Malibu VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Malibu at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN